Sealey WRP1600 Quick Start Manual

Thank you for purchasing a sealey product. Manufactured to a high standard, this product will, if used according to these
instructions, and properly maintained, give you years of trouble free performance.
IMPORTANT: PLEASE READ THESE INSTRUCTIONS CAREFULLY. NOTE THE SAFE OPERATIONAL REQUIREMENTS, WARNINGS & CAUTIONS. USE
THE PRODUCT CORRECTLY AND WITH CARE FOR THE PURPOSE FOR WHICH IT IS INTENDED. FAILURE TO DO SO MAY CAUSE DAMAGE AND/OR
PERSONAL INJURY AND WILL INVALIDATE THE WARRANTY. KEEP THESE INSTRUCTIONS SAFE FOR FUTURE USE.
Refer to Wear eye
instructions protection
1. safeTy
Familiarise yourself with the application, limitations and potential hazards of the winch.
9
ensure the winch is maintained in a safe working condition. Inspect the cable regularly. Check for fraying, kinks, broken strands or
9
distortion. If any fault is found, replace the cable using a genuine replacement from your authorised service agent. Check all component
parts, Do noT use if damaged but contact an authorised service agent.
warninG! ensure you know how much load you are pulling/lifting. never exceed the maximum capacity. Take into account any
‰
angle of incline over which the load must be moved. Also account for pulling loads from thick mud, or through snow or water
Chock the wheels of vehicles to be winched and only then release any brakes and place gears in neutral. ensure the load is
9
capable of free movement before pulling/lifting. Take up the strain on the winch before removing the wheel chocks from a vehicle. If
necessary fit an adequate sling, eyebolt or other accessory to the load. ensure that accessories are equal to, or exceed maximum capacity of
puller.
maintain correct balance and footing whilst using the puller.
9
Remove ill fitting clothing. Remove ties, watches, rings and other loose jewellery and contain and/or tie back long hair.
9
Wear appropriate safety clothing, gloves and eye protection.
9
Keep children and non-essential persons away from the operating area. Be aware of the location of other persons assisting you.
9
Take necessary precautions for your personal safety whilst using the winch.
9
Do noT operate the winch if any parts are damaged or missing as this may cause failure and/or personal injury.
8
Do noT feed the rope from the rear of the winch.
8
Do noT operate the release lever while the winch is under load.
8
Do noT operate both levers at the same time.
8
Do noT work behind a load that is under tension, always use additional methods to secure load.
8
warninG! Do noT exceed the maximum capacity of the winch.
‰
warninG! Do noT use the winch for any purpose other than that for which it is designed.
‰
Do noT pull the cable over or around a corner.
8
Do noT wrap cable around any object or hook the cable back on to itself.
8
▲ DanGer! Do noT use a "cheater" pipe, lever, or other device to lengthen the handle for additional leverage, as the puller may fail,
causing damage and/or personal injury.
Do noT operate the winch if you are tired or under the influence of alcohol, drugs or intoxicating medication.
8
Do noT move the handle abruptly when releasing the tension from the load.
8
noTe: Use caution when carrying these winches as the units are heavy.
2. inTroDucTion
Hand operated puller, ideal for lifting and moving vehicles, logs, machines and other heavy objects. All models feature two levers
for extra control when pulling or releasing load. Additional quick release lever saves time when adjusting rope length. Supplied with
removable lever handle and 20mtr wire rope with heavy-duty hook. All units are GS approved.
3. specificaTion
model .......................WRP1600.......................WRP3200
Pulling Capacity ...........1600kg............................3200kg
Wire rope Ø ....................11mm..............................16mm
Wire Rope length .......... 20mtr...............................20mtr
Weight .............................27kg.................................48kg
© Jack Sealey limited
wire rope pullers (jaw winch)
model no:
Wear protective Wear safety
gloves footwear
Original Language Version
wrp1600, wrp3200
Wear protective
clothing
WRP1600, WRP3200 | Issue 3 01/03/18