Sealey POWER PRODUCTS SA810 Quick Start Manual

Models: SA810, SA812 & SA813
Thank you for purchasing a Sealey product. Manufactured to a high standard this product will, if used
according to these instructions and properly maintained, give you years of trouble free performance.
IMPORTANT: PLEASE READ THESE INSTRUCTIONS CAREFULLY. NOTE THE SAFE
OPERATIONAL REQUIREMENTS, WARNINGS AND CAUTIONS. USE THE PRODUCT
CORRECTLY AND WITH CARE FOR THE PURPOSE FOR WHICH IT IS INTENDED.
FAILURE TO DO SO MAY CAUSE DAMAGE AND/OR PERSONAL INJURY AND WILL
INVALIDATE THE WARRANTY. PLEASE KEEP INSTRUCTIONS SAFE FOR FUTURE USE.
1. SAFETY INSTRUCTIONS
! Familiarise yourself with the application, limitations and hazards of the air hose reel.
F WARNING! Disconnect the air hose reel from the air supply before changing accessories,
servicing or performing any maintenance.
! Maintain the air hose reel in good condition (use an authorised service agent).
! Replace or repair damaged parts. Use recommended parts only. Unauthorised parts may be
dangerous and will invalidate the warranty.
! Locate and fix the air hose reel in a suitable work area. Do not position the hose in direct sun
light, or in areas of extreme heat or cold. Ensure that there is adequate lighting.
F WARNING! Ensure that the maximum air pressure is not exceeded.
! Keep extended air hose away from heat, oil and sharp edges. Check hose for wear before
each use, and ensure that all connections are secure.
% DO NOT allow the unwound air hose to become a hazard.
! Keep the hose off wet, damp or oily surfaces.
F WARNING! Always wear approved eye or face protection when operating the air hose reel.
! Maintain correct balance and footing. Ensure that the floor is not slippery and wear non-slip shoes.
! Remove ill fitting clothing. Remove ties, watches, rings and other loose jewellery and contain
and/or tie back long hair.
! Keep children and unauthorised persons away from the work area.
% DO NOT operate the air hose reel if any parts are damaged or missing as this may cause
failure and/or personal injury.
% DO NOT exceed the rated capacity of the air hose reel.
% DO NOT use the air hose reel for any purpose other than that for which it is designed.
% DO NOT yank the hose from the air supply.
% DO NOT operate the air hose reel when you are tired or under the influence of alcohol, drugs
or intoxicating medication.
% DO NOT direct air from the air hose at yourself or others.
! When not in use ensure that the air supply is turned off and tools disconnected. Disconnect from
the air supply and retract the hose into case.
F WARNING! DO NOT dismantle the hose reel casing or attempt to remove the screws on the
sides or the lid. To do so may result in damage to the appliance and/or personal injury and will
invalidate the warranty.
Internal maintenance, which will require the opening of the casing, must only be undertaken by
an authorised service agent.
PARTS LIST FOR:
AIR HOSE REELS
SA810, SA812 & SA813 - 1 - 130303