Page 1
PIONEER ELECTRONICS (USA) INC. P.O.Box 1760, Long Beach, CA 90801-1760 U.S.A. PIONEER EUROPE NV Haven 1087 Keetberglaan 1, 9120 Melsele, Belgium PIONEER ELECTRONICS ASIACENTRE PTE.LTD. 253 Alexandra Road, #04-01, Singapore 159936 C PIONEER CORPORATION 2002 K-ZZA. NOV. 2002 Printed in Japan http://www.xiaoyu163.com...
By following the instructions in this manual, be sure to apply the prescribed grease or glue to proper portions by the appropriate amount.For replacement parts or tools, the prescribed ones should be used. DEH-P350/XM/UC http://www.xiaoyu163.com...
- Screws adjacent to ∇ mark on the product are used for disassembly. - For the applying amount of lubricants or glue, follow the instructions in this manual. (In the case of no amount instructions, apply as you think it appropriate.) (1) PACKING(DEH-P350/XM/UC, DEH-P350/XN/UC, DEH-P3500/XM/UC, DEH-P3500/XN/UC) SECTION PARTS LIST Mark No. Description Part No.
3 7 63 1515 0 (2) CONTRAST TABLE DEH-P350/XM/UC, DEH-P350/XN/UC, DEH-P3500/XM/UC and DEH-P3500/XN/UC are constructed the same except for the following: Part No. Mark No. Symbol and Description DEH-P350/XM/UC DEH-P3500/XM/UC 17 Carton CHG4787 CHG4788 18 Contain Box CHL4787 CHL4788 21-1 Owner’s Manual...
Page 14
3 7 63 1515 0 (2) CONTRAST TABLE DEH-P350/XM/UC, DEH-P350/XN/UC, DEH-P3500/XM/UC, DEH-P3500/XN/UC, DEH-P4550/XM/ES and DEH-P4550/XN/ES are constructed the same except for the following: Part No. Mark No. Symbol and Description DEH-P350/XM/UC DEH-P3500/XM/UC DEH-P4550/XM/ES 6 Cord Assy CDE7129 Not used...
3 7 63 1515 0 Note: When ordering service parts, be sure to refer to “EXPLODED VIEWS AND PARTS LIST” or “ELECTRICAL PARTS LIST”. Large size SCH diagram Guide page Detailed page L 13942296513 EJECT SW PANEL UNIT u163 DEH-P350/XM/UC http://www.xiaoyu163.com...
Page 21
TUNER AMP UNIT The > mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation. DEH-P350/XM/UC REAR R CH REAR L CH FRONT...
Page 22
3 7 63 1515 0 L 13942296513 u163 FM/AM TUNER UNIT DEH-P350/XM/UC http://www.xiaoyu163.com...
Page 23
3 7 63 1515 0 L 13942296513 KEYBOARD UNIT CN701 CD CORE UNIT(S10) u163 A-a B DEH-P350/XM/UC http://www.xiaoyu163.com...
CORD ASSY several destination. For further information for respective destinations, be sure to check with the schematic dia- gram. 2.Viewpoint of PCB diagrams Capacitor Connector SIDE A SIDE B Chip Part P.C.Board L 13942296513 u163 DSENS DEH-P350/XM/UC http://www.xiaoyu163.com...
Page 33
3 7 63 1515 0 SIDE A ANTENNA L 13942296513 u163 FRONT CN1950 CN701 DEH-P350/XM/UC http://www.xiaoyu163.com...
Page 34
3 7 63 1515 0 TUNER AMP UNIT L 13942296513 u163 DEH-P350/XM/UC http://www.xiaoyu163.com...
Page 35
3 7 63 1515 0 SIDE B L 13942296513 u163 DEH-P350/XM/UC http://www.xiaoyu163.com...
4.2 PANEL UNIT 3 7 63 1515 0 SIDE A PANEL UNIT CN1901 EJECT L 13942296513 SIDE B PANEL UNIT CN801 CN831 u163 DEH-P350/XM/UC http://www.xiaoyu163.com...
4.3 KEYBOARD UNIT 3 7 63 1515 0 SIDE A KEYBOARD UNIT SIDE B KEYBOARD UNIT BAND CN1951 AUDIO EQ-EX FUNC L 13942296513 DISP SOURCE u163 VOLUME DEH-P350/XM/UC http://www.xiaoyu163.com...
4.4 CD MECHANISM MODULE 3 7 63 1515 0 SIDE A CD CORE UNIT(S10) LOADING /CARRIAGE MOTOR SPINDLE MOTOR L 13942296513 CN651 CN??? HOME PICKUP UNIT (SERVICE)(P10) u163 DEH-P350/XM/UC http://www.xiaoyu163.com...
Page 39
3 7 63 1515 0 SIDE B CD CORE UNIT(S10) 12EJ DSCSNS CLAMP L 13942296513 u163 DEH-P350/XM/UC http://www.xiaoyu163.com...
=====Circuit Symbol and No.===Part Name Part No. =====Circuit Symbol and No.===Part Name Part No. ------ ------------------------------------------ ------------------------- ------ ------------------------------------------ ------------------------- Diode HZS11L(A1) Unit Number : CWM8593(DEH-P350) Diode S5688G CWM8594(DEH-P3500) Diode HZS6L(B2) CWM8596(DEH-P4550) Diode HZS9L(B3) Unit Name : Tuner Amp Unit Diode HZS7L(A1)
• The load and eject operation is not guarantied with the mechanism upside down. If the mechanism is blocked due to mistaken eject operation, reset the product or turn off and on the ACC to restore it. u163 DEH-P350/XM/UC http://www.xiaoyu163.com...
Because of eccentricity in the disc and a slight misalignment of the clamping center the grating waveform may be seen to "wobble" ( the phase difference changes as the disc rotates). The angle specified above indicates the average angle. • Hint Reloading the disc changes the clamp position and may decrease the "wobble". u163 DEH-P350/XM/UC http://www.xiaoyu163.com...
Page 47
3 7 63 1515 0 Ech → Xch 20mV/div, AC Grating waveform Fch → Ych 20mV/div, AC 0° 30° 45° 60° L 13942296513 75° 90° u163 DEH-P350/XM/UC http://www.xiaoyu163.com...
Remarks: Mechanical errors are not displayed (because a CD is turned off in these errors). Unreadable TOC does not constitute an error. An intended operation continues in this case. Upper digits of an error code are subdivided as shown below: 1x: Setup relevant errors, 3x: Search relevant errors, Ax: Other errors. u163 DEH-P350/XM/UC http://www.xiaoyu163.com...
Grille Assy Fig.1 Removing the Tuner Amp Unit (Fig.2) Remove the screw. Remove the three screws. Straight the tabs at three locations indicated. Remove the screw and then remove the Tuner Amp Unit. u163 Tuner Amp Unit Fig.2 DEH-P350/XM/UC http://www.xiaoyu163.com...
Page 50
4. While releasing from the hook of the inner holder, lift the end of the feed screw. Feed Screw Caution: In assembling, move the planet gear to the load/eject position before setting the feed screw in the inner holder. u163 Inner Holder Planet Gear DEH-P350/XM/UC http://www.xiaoyu163.com...
ROMDATA ROM correction : Data input/output u163 EVOL : Strobe output EVOL : Data output EVOL : Clock output IPPW IPBUS : Driver power supply control output ASENBO IPBUS : Slave ACC sense output isens Illumination sense input DEH-P350/XM/UC http://www.xiaoyu163.com...
Page 53
TUNPDO TUNER : Data output(PLL) TUNPCK TUNER : Clock output(PLL) * PD5802A L 13942296513 IC's marked by * are MOS type. Be careful in handling them because they are very liable to be damaged by electrostatic induction. u163 DEH-P350/XM/UC http://www.xiaoyu163.com...
Page 54
3 7 63 1515 0 NJM2391DL1-33 VREF Thermal Over current Shutdown protector L 13942296513 * S-80835ANUP-EDZ u163 DEH-P350/XM/UC http://www.xiaoyu163.com...
Page 55
Dual Illumination (Green) Dual Illumination (Amber) 13–16 KD4–1 Key data input 17-22 KST6–1 Key strobe output 24-73 SEG49–0 LCD segment output 74–77 COM3–0 LCD common output VLCD LCD voltage input 79,80 V2,1 Power supply terminal *PD6294A L 13942296513 u163 DEH-P350/XM/UC http://www.xiaoyu163.com...
Page 56
Output of focus drive PWM Output of tracking drive PWM Output of tracking drive PWM u163 Output of thread drive PWM Output of thread drive PWM Output of spindle drive PWM Output of spindle drive PWM DGND Ground for digital circuits DEH-P350/XM/UC http://www.xiaoyu163.com...
Page 57
Connected to the capacitor for output of REFOUT Reversal input of FE L 13942296513 Output of FE ADCIN TEST Reversal input of TE Output of TE AGND Ground for the analog system PWMSW Servo PWM mode switching * UPD63712GC u163 DEH-P350/XM/UC http://www.xiaoyu163.com...
Page 58
Output pin for preamplifier for thread OPINLSL Input pin for preamplifier for thread OPOUT3 CH3 preamplifier output pin OPIN3(-) Input pin for inverting input for CH3 preamplifier OPIN3(+) Input pin for non-inverting input for CH3 preamplifier L 13942296513 PREVCC PreVcc BA5996FP u163 DEH-P350/XM/UC http://www.xiaoyu163.com...
Page 59
Ground of audio block 23 L ch O L channel output FM stereo “L-ch” signal output or AM audio output 24 R ch O R channel output FM stereo “R-ch” signal output or AM audio output u163 DEH-P350/XM/UC http://www.xiaoyu163.com...
In case of the above signal, the communication with Grille microcomputer may fail. Source keys If the time interval is not 300msec, the oscillator operative may be defective. Source ON SYSPW←H Pin 1 u163 Completes power-on operation. (After that, proceed to each source operation) DEH-P350/XM/UC http://www.xiaoyu163.com...
Before shipping out the product, be sure to clean the following portions by using the prescribed cleaning tools: Portions to be cleaned Cleaning tools CD pickup lenses Cleaning liquid : GEM1004 Cleaning paper : GED-008 L 13942296513 u163 DEH-P350/XM/UC http://www.xiaoyu163.com...