Page 1
KS-FX711/KS-FX511 3 7 63 1515 0 SERVICE MANUAL CASSETTE RECEIVER KS-FX711/KS-FX511 KS-FX711 KS-FX711 TAPE CD CHANGER CONTROL LOU D FM/AM Multi S SM Music Scan DISP MODE L 13942296513 KS-FX511 KS-FX511 TAPE CD CHANGER CONTROL LOU D FM/AM Multi...
Page 2
KS-FX711/KS-FX511 3 7 63 1515 0 Safety precaution Burrs formed during molding may be left over on some parts of the chassis. Therefore, pay attention to such burrs in the case of preforming repair of this system. L 13942296513 u163 http://www.xiaoyu163.com...
Page 3
KS-FX711/KS-FX511 3 7 63 1515 0 Disassembly method <Main body> Removing the front panel assembly (See Fig.1) Press the eject button in the lower right part of the front panel. Remove the front panel assembly from the body. Front panel assembly Eject button Fig.1...
Page 4
KS-FX711/KS-FX511 3 7 63 1515 0 Removing the heat sink (See Fig.4) Remove the three screws A on the left side of the body. Heat sink Fig.4 Joints b Removing the bottom cover (See Fig.5 and 6) Bottom cover...
Page 5
KS-FX711/KS-FX511 3 7 63 1515 0 Removing the main board Rear bracket (See Fig.7) Prior to performing the following procedure, remove the front panel assembly, the front chassis assembly, the heat sink and the bottom cover. Remove the screw B, the five screws C and the two screws D attaching the rear bracket on the back of the body.
Page 6
KS-FX711/KS-FX511 3 7 63 1515 0 Removing the control switch board (See Fig.10 to 12) Prior to performing the following procedure, remove the front panel assembly. Remove the four screws G attaching the rear cover on the back of the front panel assembly.
Page 7
KS-FX711/KS-FX511 3 7 63 1515 0 REFERENCE: Prior performing following procedures, turn the mode gear on the bottom of the body until the respective part comes to the EJECT position (Refer to Fig.1). Removing the cassette guide (See Fig.2)
Page 8
KS-FX711/KS-FX511 3 7 63 1515 0 Cassette holder assembly Removing the cassette hanger assembly / cassette holder (See Fig.4 to 7) Check the mode is set to EJECT. Push down the Boss d Side bracket Cassette hanger front part of the cassette holder and move in the assembly direction of the arrow to release the joint c.
Page 9
KS-FX711/KS-FX511 3 7 63 1515 0 Removing the side bracket assembly Side bracket assembly (See Fig.8 to 10) Joint i Remove the screw A attaching the side bracket assembly. Joint j Detach the front side of the side bracket assembly upward and pull out forward to release the joint i and j in the rear.
Page 10
KS-FX711/KS-FX511 3 7 63 1515 0 Removing the pinch arm (F) assembly (See Fig.11 and 12) Remove the polywasher and pull out the pinch arm (F) assembly. Remove the compulsion spring. Polywasher Pinch arm Polywasher Pinch arm (F) assembly...
Page 11
KS-FX711/KS-FX511 3 7 63 1515 0 Removing the head / tape guide (See Fig.16 and 17) Slide chassis assembly REFERENCE: It is not necessary to remove the slide chassis assembly. Remove the band attaching the wire to the head.
Page 12
KS-FX711/KS-FX511 3 7 63 1515 0 Disassembling the flywheel assembly (F) (See Fig.20 and 21) Push and turn counterclockwise the spring holder (F) Flywheel assembly (F) Flywheel assembly (R) to release the three joints p on the bottom of the flywheel.
Page 13
KS-FX711/KS-FX511 3 7 63 1515 0 Removing the gear base arm / gear base Gear base arm Joint t link assembly (See Fig.25 to 27) Joints s Move the gear base arm in the direction of the arrow. Hook u...
Page 14
KS-FX711/KS-FX511 3 7 63 1515 0 Mode gear Mode switch actuator Removing the mode gear (See Fig.28 and 31) Remove the polywasher on the bottom and pull out the mode gear. Removing the mode switch actuator Polywasher (See Fig.28, 29 and 31) Pull out the mode switch actuator at the bottom.
Page 15
KS-FX711/KS-FX511 3 7 63 1515 0 Slot e' Removing the gear base assembly / take up gear / reflector gear (See Fig.32 to 34) Push in the pin d’ of the gear base assembly on the upper side of the body and move the reflector gear toward the bottom, then pull out.
Page 16
KS-FX711/KS-FX511 3 7 63 1515 0 Removing the side bracket assembly (See Fig.35 to 39) Remove the eject cam plate spring. Push the joint f‘ through the slot to remove the load rack downward. Joint f' Move the eject cam limiter in the direction of the arrow to release it from the boss g’...
Page 17
KS-FX711/KS-FX511 3 7 63 1515 0 Main motor Removing the main motor assembly / assembly sub motor assembly (See Fig.40 to 42) Reduction gear (B) Belt Reduction Remove the belt at the bottom. gear (A) Remove the polywasher and pull out the mode gear.
Page 18
KS-FX711/KS-FX511 3 7 63 1515 0 Adjustment method Test instruments reqired for adjustment Standard volume position 1. Digital osclloscope(100MHz) Balance and Bass,Treble volume .Fader 2. Frequency Counter meter :Center(Indication"0") 3. Electric voltmeter Loudness,Dolby NR,Sound,Cruise:Off 4. Wow & flutter meter Volume position is about 2V at speaker output with 5.
Page 19
KS-FX711/KS-FX511 3 7 63 1515 0 Arrangement of adjusting & test points Cassette mechanism (Surface) Motor assembly Tape speed adjust Azimuth screw A (Forward) Playback head Azimuth screw B (Reverse) Head section view L 13942296513 Azimuth screw B Azimuth screw A...
Page 20
KS-FX711/KS-FX511 3 7 63 1515 0 Arrangment of adjusting VR402:Rch VR401:Rch (Dolby NR level adj) (Dolby NR Frequency response adj) Head amplifier board section (Reverse side) C419 C418 R412 C413 C416 C414 R416 C421 C422 R414 C412 VR401 Q401...
Page 21
KS-FX711/KS-FX511 3 7 63 1515 0 Mechanism adjustment section Item Adjusting & Confirmation Methods Adjust Std. Value 1. Tape running a) At Forward playmode, using mirror tape, make adjustment Azimuth adjustment with Azimuth screw A and Azimuth screw B, without curl of 4 screw A parts of head tape guide.
Page 22
KS-FX711/KS-FX511 3 7 63 1515 0 Description of major ICs AN80T05 (IC901) : Power regulator 1.Terminal layout & Block diagram Reference Voltage ASO & Peak Current Protection Thermal Protection Drive Drive Drive Drive Drive L 13942296513 MODE2 MODE1 5.6V 8.7V...
Page 23
KS-FX711/KS-FX511 3 7 63 1515 0 CXA2560Q (IC401) : Dolby B type noise reduction system with play back equalizer amp. 1.Pin layout & block diagram 7k/12k PBFB2 MSMODE 100k OFF/B PBRIN2 DRSW 300k MS MODE BIAS PBGND TAPESW MUTE...
Page 24
KS-FX711/KS-FX511 3 7 63 1515 0 LA4743K(IC301):Power AMP 1.Block diagram 2200 F 0.022 F Vcc 1/2 Vcc 3/4 IN 1 OUT 1+ 0.22 F OUT 1- PWR GND1 Protective circuit OUT 2+ IN 2 OUT 2- 0.22 F PWR GND2...
Page 25
KS-FX711/KS-FX511 3 7 63 1515 0 2.Terminal layout 3.Pin function LA4743K Pin No. Symbol Function Header of IC Power GND RFO- Outpur(-) for front Rch STBY Stand by input Output (+) for front Rch RFO+ Power input VCC1/2 RRO-...
Page 26
KS-FX711/KS-FX511 3 7 63 1515 0 LC72366-9A74 (IC701) : Micro controller 1. Pin layout 2. Pin function Pin No. Symbol Function Crystal oscillator input port Connect to GND Data input for J-BUS information J-BUS SI Data output for J-BUS information...
Page 27
KS-FX711/KS-FX511 3 7 63 1515 0 LC72366-9A74(2/2) Pin No. Port Name Function Main motor output, H:Transport L: Stop MOTOR Sub-motor output(+), Loading direction to transport output SUBMO+ Sub-motor output(-), Eject direction to transport output SUBMO- Non connection BEEP Switch for detecting to input cassette, L: Cassette in...
Page 28
KS-FX711/KS-FX511 3 7 63 1515 0 HD74HC126P (IC801) : Changer control 1.Pin arrangement 2. Pin function Input Output ( TOP VIEW ) 3. Block diagram L 13942296513 u163 1-28 http://www.xiaoyu163.com...
Page 32
KS-FX711/KS-FX511 3 7 63 1515 0 L 13942296513 u163 VICTOR COMPANY OF JAPAN, LIMITED MOBILE ELECTRONICS DIVISION PERSONAL & MOBILE NETWORK BUSINESS UNIT. 10-1,1Chome,Ohwatari-machi,Maebashi-city,371-8543,Japan 200203 (No.49713) http://www.xiaoyu163.com...
KS-FX711/KS-FX511 3 7 63 1515 0 PARTS LIST [ KS-FX711 ] [ KS-FX511 ] * All printed circuit boards and its assemblies are not available as service parts. Area suffix U --------------------- Other Areas L 13942296513 - Contents - 3- 2 Exploded view of general assembly and parts list (Block No.M1)
Page 40
KS-FX711/KS-FX511 3 7 63 1515 0 Exploded view of general assembly and parts list Block No. L 13942296513 u163 http://www.xiaoyu163.com...
Page 41
FSKS3010-001 FSKW4005-003 TORSION SPRING FSXP3026-002 RLS KNOB FSKW3002-004 COMP.SPRING FSJC3014-003 CASSETTE LID VKW4947-002 DOOR SPRING GE10039-002A FRONT PANEL 1 KS-FX711 L 13942296513 FRONT PANEL 1 KS-FX511 GE10039-001A FINDER ASSY 1 KS-FX711 GE30303-002A FINDER ASSY 1 KS-FX511 GE30303-003A FSJK3014-001 LIGHT LENS...
Page 42
1 REAR BKT+PIN JACK QYSDST2606Z SCREW 1 REAR BKT+CD IN QYSDST2606Z SCREW 1 REAR BKT+REG IC JACK FSYH4036-076 SHEET FSYH4036-077 SHEET 1 PRESET BUTTON FSYH4036-032 SHEET LCD MODULE 1 KS-FX511 LCD 1 QLD0211-002 LCD MODULE 1 KS-FX711 QLD0230-001 L 13942296513 u163 http://www.xiaoyu163.com...
Page 43
KS-FX711/KS-FX511 3 7 63 1515 0 Cassette mechanism assembly and parts list Block No. CDS-802JE1 L 13942296513 u163 http://www.xiaoyu163.com...
Page 44
KS-FX711/KS-FX511 3 7 63 1515 0 Parts list (Cassette mechanism) Block No. MPMM Item Description Parts number Parts name Q'ty Area X-0802-1009S MAIN CHASSIS AS X-0802-1002S SLIDE CHASSIS A X-0802-1003S SIDE BKT ASSY X-0802-1004S CASSETTE HANGER X-0802-1005S PINCH ARM F ASS...
Page 45
KS-FX711/KS-FX511 3 7 63 1515 0 Parts list (Cassette mechanism) Block No. MPMM Item Description Parts number Parts name Q'ty Area 1-0802-4007S GEAR BASE SPG 1-0802-4008S REEL DRIVER SPG 1-0802-4013S COMPULSION SPG 1-0802-5001S BELT 1-0802-5002S FELT 1 7.5*18.5*1.0 AZIMUTH SCREW...
Page 47
KS-FX711/KS-FX511 3 7 63 1515 0 Grease point 2/2 L 13942296513 u163 http://www.xiaoyu163.com...
Page 48
KS-FX711/KS-FX511 3 7 63 1515 0 Electrical parts list (Main board) Block No. 01 Item Parts number Parts name Remarks Area Item Parts number Parts name Remarks Area B 79 ISS254-T2 DIODE C 701 QDUB1HJ-270Y C CAPACITOR QERF1CM-106Z E CAPACITOR...
Page 49
KS-FX711/KS-FX511 3 7 63 1515 0 Electrical parts list (Main board) Block No. 01 Item Parts number Parts name Remarks Area Item Parts number Parts name Remarks Area L 718 QQL231K-470Y INDUCTOR R 331 QRE141J-273Y C RESISTOR 27K 5% 1/4W...
Page 50
KS-FX711/KS-FX511 3 7 63 1515 0 Electrical parts list (Main board) Block No. 01 Item Parts number Parts name Remarks Area R 902 QRE141J-682Y C RESISTOR 6.8K 5% 1/4W R 903 QRE141J-113Y C RESISTOR 11K 5% 1/4W R 908...
Page 51
KS-FX711/KS-FX511 3 7 63 1515 0 Electrical parts list (Front board) Block No. 02 Item Parts number Parts name Remarks Area Item Parts number Parts name Remarks Area C 651 NCB21HK-103X C CAPACITOR R 647 NRSA02J-511X MG RESISTOR C 652...
Page 52
KS-FX711/KS-FX511 3 7 63 1515 0 Electrical parts list (Mecha control board) Block No. 03 Item Parts number Parts name Remarks Area C 401 NDC31HJ-101X C CAPACITOR C 402 NDC31HJ-101X C CAPACITOR C 403 NDC31HJ-101X C CAPACITOR C 404...
Page 53
KS-FX711/KS-FX511 3 7 63 1515 0 < M E M O > L 13942296513 u163 3-15 http://www.xiaoyu163.com...
Page 54
KS-FX711/KS-FX511 3 7 63 1515 0 Packing materials and accessories parts list Block No. Block No. A1,A2 L 13942296513 A12, A13 KIT : A3~A7 u163 3-16 http://www.xiaoyu163.com...
Page 55
POLY BAG 1 KIT QPA01003003 POLY BAG 1 HARD CASE FSYH4036-068 SHEET QPC03004315P POLY BAG 1 SET CARTON GE30407-010A 1 KS-FX711 CARTON 1 KS-FX511 GE30407-011A GE10036-001A ESP CUSHION Parts list (Accessories) Block No. M5MM Item Description Parts number Parts name...