Table of Contents
Advertisement
Quick Links
See also:
User Manual
CD Soundmachine
CONTENTS
Technical specification .....................................................................1
Service measurement setup..........................................................1-3
Service aids .................................................................................1-4
Instructions on CD playability ...........................................................2
Block diagram................................................................................... 3
Wiring diagram ................................................................................. 4
Circuit diagram ................................................................................. 5
Layout diagram.................................................................................6
Exploded view diagram ....................................................................7
Revision list ...................................................................................... 8
©
Copyright 2012 Philips Consumer Electronics B.V. Eindhoven, The Netherlands
All rights reserved. No part of this publication may be reproduced, stored in a retrieval
system or transmitted, in any form or by any means, electronic, mechanical, photocopying,
or otherwise without the prior permission of Philips.
Published by ZH 1312 Service Audio Subject to modification
Version 1.0
AZ329/98
3140 038 60100
Advertisement
Table of Contents
Related Manuals for Philips AZ329/98
Summary of Contents for Philips AZ329/98
- Page 1 Revision list ..................8 © Copyright 2012 Philips Consumer Electronics B.V. Eindhoven, The Netherlands All rights reserved. No part of this publication may be reproduced, stored in a retrieval system or transmitted, in any form or by any means, electronic, mechanical, photocopying, or otherwise without the prior permission of Philips.
-
Page 2: Technical Specifications
AZ127 Europe AZ320 Europe AZ328 Europe AZ329 APAC Prepared: Cheeked: ( R&D Engineer) (R&D Chief engineer) Approved: Approved: Approved: (PHILIPS_ODM) (PHILIPS DEV-Q) (PHILIPS QAD) 2012-07-18 2012-10-24 AZ127/320/328/329 2012-11-11 Tang Bing NAME BU HAV Consumer Lifestyle, Philips © 2012-11-16 CHECK DATE... - Page 3 Connector type Audio-in (3.5mm) 3.5mm 3 pole socket x1 ACCESSORIES Audio cable 3.5mm x 60mm ⑴ ⑵ Table of contents DOCUMENT HISTORY .........................5 2012-07-18 2012-10-24 AZ127/320/328/329 2012-11-11 Tang Bing NAME BU HAV Consumer Lifestyle, Philips © 2012-11-16 CHECK DATE...
-
Page 4: Table Of Contents
CD..........................15 TAPE (Jiansheng JS-21VB8885-SGS) ...............16 USB/SD CARD: .......................17 Audio Signal Processing(TBC) ................17 MECHANICAL ........................18 2012-07-18 2012-10-24 AZ127/320/328/329 2012-11-11 Tang Bing NAME BU HAV Consumer Lifestyle, Philips © 2012-11-16 CHECK DATE... -
Page 5: Document History
2012-07-18 Tang bing First Draft 2012-10-24 Tang bing Add USB and SD card information 2012-11-11 Lv Yanhui Slide switch function, ESD specification, Tape function. 2012-07-18 2012-10-24 AZ127/320/328/329 2012-11-11 Tang Bing NAME BU HAV Consumer Lifestyle, Philips © 2012-11-16 CHECK DATE... -
Page 6: Introduction
Sheet 190 will be part of the Philips official documentation from stage 2 onwards. All changes to sheet 190 have to be submitted via Change Proposals. Changes have to be marked in bold and/ or colours in the document for easy recognition in at least the update right after the change. -
Page 7: General Information And Requirement
Stroke Version Region Europe Europe Europe APAC MP3 Link √ √ √ √ (3.5mm audio jack) USB port √ √ √ SD card √ 2012-07-18 2012-10-24 AZ127/320/328/329 2012-11-11 Tang Bing NAME BU HAV Consumer Lifestyle, Philips © 2012-11-16 CHECK DATE... - Page 8 4. Mode 5. Next 6. Preview 7. Album+ 8. Album- 9. DBB (push button) Knob control on the set are: 1. Volume 2. FM tuning 2012-07-18 2012-10-24 AZ127/320/328/329 2012-11-11 Tang Bing NAME BU HAV Consumer Lifestyle, Philips © 2012-11-16 CHECK DATE...
-
Page 9: Mechanical General Information
>8-10 >8-10 Normal recallable functions function changes allowed. >10-15 >10-15 Control recallable functions function changes allowed. >15 >18 No loss of stored data allowed. 2012-07-18 2012-10-24 AZ127/320/328/329 2012-11-11 Tang Bing NAME BU HAV Consumer Lifestyle, Philips © 2012-11-16 CHECK DATE... -
Page 10: Environmental Condition
2 according to BLC V&MA PQR handbook V2.1 (2006-10-02) Lifetime: 7 years Tested According to: General Test Instruction UAN-D 1591 Measured According to: UAN_L 1059 unless otherwise stated 2012-07-18 2012-10-24 AZ127/320/328/329 2012-11-11 Tang Bing NAME BU HAV Consumer Lifestyle, Philips © 2012-11-16 CHECK DATE... -
Page 11: Technical Specifications
Reference: IEC61000-4-5 and for USA: 3135 019 8029 Reliability evaluation. Requirements: • Apparatus should fulfil the leakage current requirements of IEC60065 point 9.1.1 (UAN-D1631) • Defects or permanent deviations are not allowed. 2012-07-18 2012-10-24 AZ127/320/328/329 2012-11-11 Tang Bing NAME BU HAV Consumer Lifestyle, Philips © 2012-11-16 CHECK DATE... - Page 12 Power consumption at nominal AC input: 1. iPod mode at 1/8 P-rated output power ≤ 2. Low Power Standby Mode (fulfill ERP2013) : ≤ 0.5 W 2012-07-18 2012-10-24 AZ127/320/328/329 2012-11-11 Tang Bing NAME BU HAV Consumer Lifestyle, Philips © 2012-11-16 CHECK DATE...
-
Page 13: Technical Description
Electrical Parameters are to be measured at Speaker Terminals across rated impedance Load(4ohm) with Rated Input Signal in CD Mode setting in DBB/Loudness Off and Pre-eq at Flat unless specified otherwise. 2012-07-18 2012-10-24 AZ127/320/328/329 2012-11-11 Tang Bing NAME BU HAV Consumer Lifestyle, Philips © 2012-11-16 CHECK DATE... -
Page 14: Tuner
116 dBf FM 107.0Mhz Lim. 108 dBf Units mV/m Limited(d Normal(d Remark Susceptibility to unwanted signals(CPU,SMPS,AMP,DSP …): -15dB -20dB Refer to self pollution curve REMARKS: 2012-07-18 2012-10-24 AZ127/320/328/329 2012-11-11 Tang Bing NAME BU HAV Consumer Lifestyle, Philips © 2012-11-16 CHECK DATE... - Page 15 < 1 % < 3 % Channel difference 2 dB 3 dB Frequency accuracy +/-0.5 % De-emphasis 15μs / 50μs Switchable via Subcode information 2012-07-18 2012-10-24 AZ127/320/328/329 2012-11-11 Tang Bing NAME BU HAV Consumer Lifestyle, Philips © 2012-11-16 CHECK DATE...
-
Page 16: Tape (Jiansheng Js-21Vb8885-Sgs)
10dB (6dB for the range of (PB) IEC I IEC II 250Hz to 4kHz) > 36dB for IEC I * > 36dB for IEC II ** 250nWb/m 2012-07-18 2012-10-24 AZ127/320/328/329 2012-11-11 Tang Bing NAME BU HAV Consumer Lifestyle, Philips © 2012-11-16 CHECK DATE... -
Page 17: Usb/Sd Card
Amplification Reserve for Tape = 1dB ±2dB For details, please see specification SH-190 of ECO-MTF-PA-SD (3140 117 14890). USB/SD CARD: Same as CD(TBC) Audio Signal Processing(TBC) 2012-07-18 2012-10-24 AZ127/320/328/329 2012-11-11 Tang Bing NAME BU HAV Consumer Lifestyle, Philips © 2012-11-16 CHECK DATE... -
Page 18: Mechanical
Jump Forward (inner to outermost title) < 40 dBA Jump Backwards (outer to innermost title) < 40 dBA Layer Jump (layer 0 to layer 1) < 40 dBA 2012-07-18 2012-10-24 AZ127/320/328/329 2012-11-11 Tang Bing NAME BU HAV Consumer Lifestyle, Philips © 2012-11-16 CHECK DATE... - Page 19 MEASUREMENT SETUP Tuner FM Bandpass LF Voltmeter 250Hz-15kHz e.g. PM2534 e.g. 7122 707 48001 RF Generator e.g. PM5326 S/N and distortion meter e.g. Sound Technology ST1700B Use a bandpass filter to eliminate hum (50Hz, 100Hz) and disturbance from the pilottone (19kHz, 38kHz). Use Audio Signal Disc SBC429 4822 397 30184 (replaces test disc 3)
- Page 20 SERVICE AIDS WARNING All ICs and many other semi-conductors are susceptible to electrostatic discharges (ESD). Careless handling during repair can reduce life drastically. When repairing, make sure that you are connected with the same potential as the mass of the set via a wrist wrap with resistance. Keep components and tools also at this potential.
- Page 21 2 - 1 INSTRUCTIONS ON CD PLAYABILITY Customer complaint "CD related problem" Set remains closed! check playability playability ok ? For flap loaders (= access to CD drive possible) "fast" lens cleaning cleaning method is recommended check playability playability ok ? Play a CD for at least 10 minutes check playability...
- Page 22 2 - 2 INSTRUCTIONS ON CD PLAYABILITY PLAYABILITY CHECK LIQUID LENS CLEANING Before touching the lens it is advised to clean the surface of the lens by blowing clean air over it. For sets which are compatible with CD-RW discs This to avoid that little particles make scratches on use CD-RW Printed Audio Disc ....7104 099 96611 the lens.
- Page 23 Disassembly Disagrams: A:Disassemble the bottom cabinet A3 Plug out the Cable 2 pin, You can remote the bottom Cabinet Remote the bottom cabinet B:Disassemble the Front & Top Cabinet B1:Plug out the cable 4 pin B2:Dismount the 2 screws,You Can Remote the Front Cabinet C:Disassemble the Main PCBA C1:Plug out the Cabinet from the connector...
- Page 24 BLOCK DIAGRAM FM ANT Line in & USB & SD TUNER FM RF IF AMP (CD/Line in & USB &SD) IC101 TA2003 For Auto Power off Control Q401 B772 B50K AUDIO AMP FUNCTION Mechanical SWITCH CONTROL LCD Display IC401 Vol Control Panel control OFF/TAPE-FM-CD/USB CD8227...
- Page 25 Switch Adaptor...
- Page 26 CD & USB & SD Circuit View 3V3SD 3V3SD SEV_3V3 103P 2200uF/16V 104P 10uF 0.1uF 104P R8 0R CD+5V 474P 3V3SD M33V_PAD MUTE34 3.9K VREF_16 KEY2 CD DOOR KEY1 CD_RX 103P CD_TX MUTE34 HOST_EN 103P LIMIT 4.7K MUTE 1N4148 472P 470R SA5888 IC503...
- Page 27 Power & Radio Circuit View AUX IN TO CD PART AUX IN C108 222P CDMUTE 333P C111 CD5V MOTOR 820R LEAF R116 S.W. C109 CN16 222P CSC7323 HEAD 470U/16V 220uF SPEAKER R108 CDMUTE 222P 9014 8050 CN19 R102 820R AUX_SW R106 AUXMUTE CD8227...
- Page 28 Main PCB Layout View...
- Page 29 Radio & BBS & Power PCB Layout Top Side View Radio & BBS & Power PCB Layout Bottom Side View...
- Page 30 LCD PCB Layout Side View Bottom Line & MP3 & USB & SD PCB Layout Side View Bottom...
-
Page 31: Exploded View Diagram
Exploded View Diagram...