All rights reserved. No part of this publication may be reproduced, stored in a retrieval system or transmitted, in any form or by any means, electronic, mechanical, photocopying, or otherwise without the prior permission of Philips. Published by WO 0472 Service PaCE...
EN 2 LC4.6U AA Technical Specifications, Connections, and Chassis Overview 1. Technical Specifications, Connections, and Chassis Overview Index of this chapter: Connections 1.1 Technical Specifications 1.2 Connections Note: The following connector color abbreviations are used 1.3 Chassis Overview (acc. to DIN/IEC 757): Bk= Black, Bu= Blue, Gn= Green, Gy= Grey, Rd= Red, Wh= White, and Ye= Yellow.
Page 3
Technical Specifications, Connections, and Chassis Overview LC4.6U AA EN 3 AV3 VGA: Video 2fH RGB - In AV2 SVHS: Video 1fH Y/C - In - Ground Y - Ground C - Video Y / 75 ohm - Video C 0.3 V / 75 ohm E_06532_002.eps...
EN 4 LC4.6U AA Safety Instructions, Warnings, and Notes 2. Safety Instructions, Warnings, and Notes Index of this chapter: Service Default Mode (see chapter 5) with a colour bar 2.1 Safety Instructions signal and stereo sound (L: 3 kHz, R: 1 kHz unless stated 2.2 Warnings...
IC will be destroyed due to high (steam- )pressure inside the body. If the packaging was opened Philips CE is going to produce lead-free sets (PBF) from before usage, the IC has to be heated up for some hours 1.1.2005 onwards.
EN 6 LC4.6U AA Mechanical Instructions 4. Mechanical Instructions Index of this chapter: Notes: 4.1 Cable Dressing • Figures below can deviate slightly from the actual situation, 4.2 Service Positions due to the different set executions. 4.3 Assy/Panel Removal •...
Page 7
Mechanical Instructions LC4.6U AA EN 7 Assy/Panel Removal 3. Remove the two female screw locks (3) of the VGA connector. 4. Release the plastic cable clips (4) on the shielding and 4.3.1 Rear Cover disconnect all cables from the SSB.
Page 8
EN 8 LC4.6U AA Mechanical Instructions Set Re-assembly To re-assemble the whole set, execute all processes in reverse order. Notes: • While re-assembling, make sure that all cables are placed and connected in their original position. See figure "Wire dressing".
Service Modes, Error Codes, and Fault Finding LC4.6U AA EN 9 5. Service Modes, Error Codes, and Fault Finding Index of this chapter: How to enter 5.1 Test Points To enter SDM, use one of the following methods: 5.2 Service Modes •...
Page 10
EN 10 LC4.6U AA Service Modes, Error Codes, and Fault Finding If you turn the television set off by removing the mains (i.e., – YY= the sub software version number (updated with a unplugging the television) or by using the POWER button on...
Page 11
Service Modes, Error Codes, and Fault Finding LC4.6U AA EN 11 How to enter 2. Press the MENU button on the remote control transmitter. To enter CSM, press the following key sequence on the remote This brings up the normal user menu.
Page 12
5.4.1 Introduction 5.4.3 How To Connect ComPair (Computer Aided Repair) is a service tool for Philips This is described in the chassis fault finding database in Consumer Electronics products. ComPair is a further ComPair . development on the European DST (service remote control), which allows faster and more accurate diagnostics.
Service Modes, Error Codes, and Fault Finding LC4.6U AA EN 13 5.5.1 How To Read The Error Buffer Table 5-2 Error code overview You can read the error buffer in 3 ways: Error Device Error description Check item Diagram •...
Page 14
EN 14 LC4.6U AA Service Modes, Error Codes, and Fault Finding 5.7.1 NVM Editor 5.7.3 Tuner and IF In some cases, it can be handy if one directly can change the No Picture in RF mode NVM contents. This can be done with the “NVM Editor” in SAM 1.
Alignments LC4.6U EN 71 8. Alignments Index of this chapter: To store the data: Use the RC button MENU to switch to the 8.1 General Alignment Conditions main menu and then switch to STAND-BY mode. 8.2 Hardware Alignments 8.3 Software Alignments For the next alignments, supply the following test signals via a video generator to the RF input: Note: The Service Default Mode (SDM) and Service Alignment...
Page 72
NORMAL color temp. (all regions) 0.289 Equipment and setting 0.299 • E.g. Fluke 54200 or Philips PM5580. • 100% “8-step grey scale” pattern. Only the values for NORMAL are aligned with X, Y values. The Alignment Method delta values for COOL and WARM are given below.
Page 73
Alignments LC4.6U EN 73 HD Grey Scale Adjustment Equipment and setting • Quantum Data 802B. • HD input signal, Top half 100% color bar and bottom half Grey scale pattern,1920x1080i@60Hz YPbPr (Format= 1080i30, Pattern= HDBar100). • HD input at D-sub VGA connector. Alignment Method •...
Page 74
/17, /37 Bit (DEC) Option Description (LATAM) NTSC) (AP-PAL) (China) (Europe) (NAFTA) Remarks 7 (128) OP_PHILIPS_TUNER Philips Tuner available 6 (64) OP_FM_RADIO FM Radio available 5 (32) OP_LNA Low Noise Amplifier available 4 (16) OP_ATS Auto Tuning System 3 (8)
Circuit Descriptions, Abbreviation List, and IC Data Sheets LC4.6U EN 75 9. Circuit Descriptions, Abbreviation List, and IC Data Sheets Index of this chapter: Introduction 9.1 Introduction 9.2 Block Diagram The LC4.6 LCD TV is a global LCD TV for the year 2004. It is 9.3 Power Supply LCD the successor of the LC03 LCD TV and covers screens size 30 9.4 Input/Output...
Page 76
• Micro Controller. • Data Capture. A Philips UV13xx Tuner is used in the TV board. The SIF • Display. signals are decoded by the Hercules. Tuning is done via I The Hercules has one input for the internal CVBS signal and a 9.5.1...
Page 77
Circuit Descriptions, Abbreviation List, and IC Data Sheets LC4.6U EN 77 Video: Scaler Part (diagram A7 and A13) Audio Processing The Genesis GM1501 Scaler is a dual channel graphics and Hercules video processing IC for LCD monitors and televisions incorporating Picture in Picture, up to SXGA output resolutions. AUDIO-LSL 2x Stereo AUDIO-LSR...
Page 78
Monitor Controller. time in the linear region in between. Therefore, very little power • On-chip 80C51 micro-controller from Philips is lost to heat. If the transistors have a low 'on' resistance Semiconductors UOCIII (Hercules) series. (RDS(ON)), little voltage is dropped across them, further...
Page 79
Circuit Descriptions, Abbreviation List, and IC Data Sheets LC4.6U EN 79 The Micro Controller ranges in ROM from 128 kB with no TXT- Name Description Configuration decoder to 128 kB with a 10 page Teletext or with Closed 123 P2.5/ PWM4 (for future use) Caption.
Committee LATAM LATin AMerica C-FRONT Chrominance front input LC04 Philips chassis name for LCD TV 2004 Circuit Board Assembly (or PWB) project Constant Level: audio output to Liquid Crystal Display connect with an external amplifier Light Emitting Diode...
Page 81
Sound right SCART2 out SNDS-VL-OUT Surround sound left variable level out SNDS-VR-OUT Surround sound right variable level out SOPS Self Oscillating Power Supply S/PDIF Sony Philips Digital InterFace SRAM Static RAM STBY Stand-by SVHS Super Video Home System Sub Woofer / SoftWare...
EN 82 LC4.6U Circuit Descriptions, Abbreviation List, and IC Data Sheets 9.11 IC Data Sheets This section shows the internal block diagrams and pin layouts of ICs that are drawn as "black boxes" in the electrical diagrams (with the exception of "memory" and "logic" ICs). 9.11.1 Diagram A2, Type TDA12029H (IC7011) A “...
Revision List LC4.6U EN 93 11. Revision List Manual xxxx xxx xxxx.0 • First release. Manual xxxx xxx xxxx.1 • Update of manual including: – Text chapters are updated and minor corrections are made. – Blockdiagrams are added. – Schematics are updated and minor corrections are made.