Suzuki Aerio Owner's Manual
  1. Manuals
  2. Brands
  3. Suzuki Manuals
  4. Automobile
  5. Aerio
  6. Owner's manual

Suzuki Aerio Owner's Manual

Hide thumbs
Table of Contents

Advertisement

Quick Links

ENGLISH
SERVICE STATION INFORMATION
Fuel recommendation:
See page 1-1
Engine oil recommendation:
Engine oil with "Starburst" symbol
For further details, see "Engine Oil and Filter" in the
"INSPECTION AND MAINTENANCE" section.
Suzuki Red: Magenta 100%, Yellow 100%
Suzuki Blue: Cyan 100%, Magenta 70%
Brake and clutch fluid:
DOT3
Automatic transaxle fluid:
An equivalent of DEXRON ® -III.
Tire cold pressure:
See the "Tire Information Label" located on the
driver's door lock pillar.
Made from 100% recycled paper,
except for cover.
Printed in Japan
10.0 mm
OWNER'S MANUAL
Keep With Vehicle At All Times.
Contains Important Information
On Safety, Operation & Maintenance.
2007
Part No. 99011-54G27-03E
June, 2006

Advertisement

Table of Contents
loading

Related Manuals for Suzuki Aerio

Summary of Contents for Suzuki Aerio

  • Page 1 Keep With Vehicle At All Times. Contains Important Information Made from 100% recycled paper, On Safety, Operation & Maintenance. except for cover. Part No. 99011-54G27-03E June, 2006 Printed in Japan Suzuki Red: Magenta 100%, Yellow 100% Suzuki Blue: Cyan 100%, Magenta 70%...
  • Page 2 This owner’s manual applies to the AERIO series: 54G588 NOTE: The illustrated model is one of the AERIO series. © COPYRIGHT SUZUKI MOTOR CORPORATION 2006 54G27-03E...
  • Page 3 INTRODUCTION Thank you for choosing SUZUKI and welcome to our growing family. Your choice was a wise one; SUZUKI products are a great value that will give you years of driving pleasure. This Owner’s Manual was prepared to help you have a safe, enjoyable, and trouble-free experience with your SUZUKI. In it you will learn about the vehicle’s operation, its safety features and maintenance requirements.

  • Page 4: Service Station

    SERVICE STATION GUIDE 1. Fuel (see section 1) 2. Engine hood (see section 5) 3. Tire changing tools (see section 5) 4. Engine oil dipstick <Yellow> (see section 9) 5. Automatic transaxle fluid dipstick (RHD) <Red> (see section 9) 6. Engine coolant (see section 9) 7.

  • Page 5: Table Of Contents

    TABLE OF CONTENTS FUEL RECOMMENDATION California Proposition 65 Warning BEFORE DRIVING WARNING STEERING COLUMN CONTROLS Engine exhaust, some of its constitu- ents, and certain product compo- INSTRUMENT PANEL nents contain or emit chemicals known to the State of California to OTHER CONTROLS AND EQUIPMENT cause cancer and birth defects or other reproductive harm.

  • Page 6: Location Of Warning Messages

    Do not remove the messages for any reason. If a label comes off or the messages become difficult to be read, have it corrected by your SUZUKI dealer. 1. Air bag warning labels (on both sun visors) 2. Passenger seat belt warning label 3.
  • Page 7 United States or Canada, The Owner of the dealership is in the very make the same or similar changes to you may wish to contact the Suzuki Cus- best position to assist you as he or she is vehicles previously built or sold.

  • Page 8: Warning

    NOTE: problems. Consult your SUZUKI Indicates special information to make dealer or qualified service technician maintenance easier or instructions clearer. for advice on installing such mobile communication equipment. 54G27-03E...
  • Page 9 LEAK DETECTION PUMP NOTE: Your vehicle has a pump to regularly check the vehicle’s evaporative emission control system for leaks. This check is performed approximately five hours after the engine is turned off. During this leak check, you may hear a sound coming from the vehicle for several minutes.
  • Page 10 MEMO 54G27-03E...

  • Page 11: Fuel Recommendation

    FUEL RECOMMENDATION FUEL RECOMMENDATION Fuel Recommendation ............1-1 65D394 54G27-03E...
  • Page 12 (wood alcohol) may be suitable for use in NOTE: 60A004 your vehicle if they contain cosolvents and To help clean the air, SUZUKI recom- Your vehicle requires regular unleaded corrosion inhibitors. Do NOT USE fuels mends you use the oxygenated fuels.

  • Page 13: Before Driving

    BEFORE DRIVING BEFORE DRIVING Keys ..................2-1 Door Locks ................2-1 Windows ................2-8 Mirrors .................. 2-10 Seat Adjustment ..............2-11 Head Restraints ..............2-12 Seat Belts and Child Restraint Systems ......2-13 Supplemental Restraint System (air bags) ....... 2-32 60G404 54G27-03E...

  • Page 14: Keys: 8

    Keys: 8 Door Locks: 3, 5, 8 BEFORE DRIVING Keys Door Locks To unlock a front door from outside the vehicle, insert the key and turn the top of the key toward the front of the vehicle. WARNING EXAMPLE Always lock all doors when driving. EXAMPLE Locking the doors helps to prevent UNLOCK...
  • Page 15 Door Locks: 3, 5, 8 BEFORE DRIVING Power Door Locking System To unlock all the doors simultaneously, Front passenger’s side insert the key in a front door lock and turn (if equipped) the top of the key toward the front of the You can lock and unlock all the doors vehicle twice.
  • Page 16 • If you lose one of the transmitters, ask The “PANIC” button function will not acti- ton on the transmitter. your SUZUKI dealer as soon as possible vate when the key is in the ignition switch. • To unlock the driver’s door, push the for a replacement and to have the lost “UNLOCK”...
  • Page 17 Door Locks: 3, 5, 8 BEFORE DRIVING Replacement of the transmitter battery If the transmitter becomes unreliable, WARNING replace the battery. Swallowing a lithium battery may cause serious internal injury. Do not allow anyone to swallow a lithium battery. Keep lithium batteries away from children and pets.
  • Page 18 • To purchase new transmitters, see your been programmed. SUZUKI dealer. 7) If you want to program an additional • Before you begin programming, have all transmitter, repeat the procedure from of your transmitters available.
  • Page 19 Door Locks: 3, 5, 8 BEFORE DRIVING To change the old transmitter codes in 1. For USA Child Lock System (rear side doors) your vehicle’s memory This device complies with Part 15 of the If you have lost one of the transmitters, you FCC Rules.
  • Page 20 Door Locks: 3, 5, 8 BEFORE DRIVING Trunk Lid located to the outboard side of the driver’s Internal Trunk Release seat. To lock the lid, lower the lid and press EXAMPLE down on it. The lid is locked automatically. WARNING Always make sure that the trunk lid is closed and latched securely.

  • Page 21: Windows

    Windows: 3, 8 BEFORE DRIVING Windows Passenger’s door EXAMPLE CLOSE Power Window Controls Driver’s side OPEN 81A009 52D162 To open a window, push the top part of the The passenger’s door only has a switch to switch and to close a window lift up the top operate the passenger’s window (3).
  • Page 22 Windows: 3, 8 BEFORE DRIVING WARNING EXAMPLE (Continued) • To avoid injuring an occupant by window entrapment, be sure no part of the occupant’s body such as hands or head is in the path of the electric windows when closing them.

  • Page 23: Mirrors

    Windows: 3, 8 Mirrors: 3, 8 BEFORE DRIVING Mirrors Outside Rearview Mirrors WARNING Inside Rearview Mirror • Always adjust the mirror with the selector set to the day position. • Only use the night position if it is necessary to reduce glare from the headlights of vehicles behind you.

  • Page 24: Seat Adjustment: 3

    Mirrors: 3, 8 Seat Adjustment: 3 BEFORE DRIVING Power Mirror Control (if equipped) Seat Adjustment Adjusting Seat Position Front seat WARNING Never attempt to adjust the driver’s seat or seatback while driving. The seat or seatback could move unex- pectedly, causing loss of control. Make sure that the driver’s seat and seatback properly...

  • Page 25: Head Restraints

    Seat Adjustment: 3 BEFORE DRIVING Adjusting Seatbacks Head Restraints Front seat 54G471 If the driver’s seat is equipped with a seat 75F123 54G472 height adjuster lever on the outboard side Head restraints are designed to help of the seat, raise or lower the seat by pull- To adjust the seatback angle of front seats, reduce the risk of neck injuries in case of ing up or down the adjuster lever.

  • Page 26: Seat Belts And Child Restraint Systems

    Seat Adjustment: 3 Head Restraints: 3 BEFORE DRIVING Seat Belts and Child Restraint EXAMPLE Systems EXAMPLE Above the pelvis 54G017 65D606 To raise the head restraint, pull upward on Rear Front the restraint until it clicks. To lower the WARNING 54G322 restraint, push down on the restraint while •...
  • Page 27 Head Restraints: 3 Seat Belts and Child Restraint Systems: 3 BEFORE DRIVING WARNING (Continued) • Do not wear your seat belt over hard or breakable objects in your pockets or on your clothing. If an as low as possible accident occurs, objects such as across the hips Across the pelvis glasses, pens, etc.
  • Page 28 Seat Belts and Child Restraint Systems: 3 BEFORE DRIVING Lap-Shoulder Belt Safety reminder WARNING Emergency Locking Retractor (ELR) Sit up straight and (Continued) The seat belt has an emergency locking fully back • Infants and small children should retractor (ELR), which is designed to lock never be transported unless they the seat belt only during a sudden stop or are properly restrained.
  • Page 29 Seat Belts and Child Restraint Systems: 3 BEFORE DRIVING by pulling the shoulder portion of the belt All Seat Belts Except Rear Center upward through the latch plate. The length of the diagonal shoulder strap adjusts itself to allow freedom of movement. 60A039 60A036 To unfasten the belt, push the red...
  • Page 30 Seat Belts and Child Restraint Systems: 3 BEFORE DRIVING Rear Center Seat Belt Fastening Unfastening 54G357 54G358 54G356 The rear center seat belt is a “Lap-shoul- Before fastening the rear center belt, make To unfasten the belt, push the red sure the detachable connector (1) is “PRESS”...
  • Page 31 Seat Belts and Child Restraint Systems: 3 BEFORE DRIVING Unlatching and Latching Latching To latch the connector: Detachable Connector 1) Pull the belt out from the holder. Unlatching 54G645 WARNING 54G367 54G365 To minimize risk of severe injury or 2) Insert the connector latch plate (C) into death in the event of a crash, always To unlatch the connector: the connector (D) so as to align the tri-...
  • Page 32 Seat Belts and Child Restraint Systems: 3 BEFORE DRIVING Stowing Rear Center Lap-Shoulder Seat Belt Reminder When the driver and front passenger don’t buckle their seat belts, the driver’s seat belt Belt Driver’s seat belt reminder light reminder light in the instrument cluster and Be sure to stow the belt after the belt is the front passenger’s seat belt reminder retracted completely.
  • Page 33 Seat Belts and Child Restraint Systems: 3 BEFORE DRIVING Flow chart Driver’s seat belt reminder If the driver’s seat belt remains unbuckled Ignition Switch “ON” with the ignition key in the “ON” position, the driver’s seat belt reminder works as fol- lows: Seat belt is Seat belt is...
  • Page 34 Seat Belts and Child Restraint Systems: 3 BEFORE DRIVING Front passenger’s seat belt reminder Shoulder Anchor Height Adjuster Seat Belt Hanger (if equipped) The front passenger’s seat belt reminder (if equipped) will activate only when there is a passen- EXAMPLE ger sitting in the front seat.
  • Page 35 Seat Belts and Child Restraint Systems: 3 BEFORE DRIVING Seat Belt Inspection Child Restraint Systems WARNING EXAMPLE Be sure to inspect all seat belt assemblies after any collision. Any seat belt assembly which was in use during a collision (other than a very minor one) should be replaced, even if damage to the assembly is not obvious.
  • Page 36 Seat Belts and Child Restraint Systems: 3 BEFORE DRIVING Infant restraint - rear seat only SUZUKI highly recommends that you use a child restraint system to restrain infants EXAMPLE and small children. Many different types of child restraint systems are available; make...
  • Page 37 Seat Belts and Child Restraint Systems: 3 BEFORE DRIVING Installation with Lap-Shoulder Seat WARNING Belts (child restraint with no top strap) Children could be endangered in a crash if their child restraints are not EXAMPLE properly secured in the vehicle. When installing a child restraint sys- tem, be sure to follow the instruc- tions below.
  • Page 38 Seat Belts and Child Restraint Systems: 3 BEFORE DRIVING EXAMPLE EXAMPLE EXAMPLE 83E035 83E032 83E036 1) Pull all of the remaining webbing out of 2) Allow the extra webbing to retract, and 3) Make sure that the retractor has con- the retractor.
  • Page 39 Seat Belts and Child Restraint Systems: 3 BEFORE DRIVING To revert from ALR to ELR Installation with the LATCH System EXAMPLE EXAMPLE Move to check Rigid lower connecting Flexible lower connecting bar type strap type 65D234 65D267 65D337 When you unbuckle the seat belt and allow EXAMPLE it to retract to a certain length, the retractor will automatically revert back to the normal...
  • Page 40 Seat Belts and Child Restraint Systems: 3 BEFORE DRIVING Anchors and Tethers for Children.) The If your LATCH restraint has flexible lower anchors are located where the rear of the connecting straps, these general instruc- EXAMPLE seat cushion meets the bottom of the seat- tions apply: back.
  • Page 41 Seat Belts and Child Restraint Systems: 3 BEFORE DRIVING owner’s manual. Attach the top tether If your LATCH restraint has rigid lower con- strap, if applicable. necting bars, these general instructions EXAMPLE apply: 1) If possible, fold the seatback rearward EXAMPLE for easier installation.
  • Page 42 Seat Belts and Child Restraint Systems: 3 BEFORE DRIVING are partially hooked to the anchors. Installation-Child Restraint with Top Use your hands to confirm the position. Strap EXAMPLE EXAMPLE EXAMPLE 54G337 3) When routing the top strap, be sure to pass it between the head restraint and the rear seatback as shown.
  • Page 43 SUZUKI dealer for a seat belt belt buckle. If the front passenger extender. Seat belt extenders are available sensing system does not sense your...
  • Page 44 This section of the owner’s manual The driver and all passengers must be • When unfastening the seat belt, describes your SUZUKI’s SEAT BELT properly restrained by wearing seat belts unlatch the latch plate of the seat PRETENSIONER SYSTEM.

  • Page 45: Supplemental Restraint System (Air Bags)

    Your vehicle has advanced front air bags 90 seconds before performing any electri- and side air bags for the driver and right cal service work on your SUZUKI. Do not front passenger. touch pretensioner system components or wiring. The wires are wrapped with yellow...
  • Page 46 Seat Belts and Child Restraint Systems: 3 BEFORE DRIVING Your vehicle is equipped with a Supple- mental Restraint System consisting of the following components in addition to a lap- shoulder belt at each front seating position. 1. Driver’s air bag 2.
  • Page 47 Seat Belts and Child Restraint Systems: 3 BEFORE DRIVING Frontal collision range Front air bags will not inflate 54G442 60G032 65D236 Side air bags are located in the part of the Side collision range Front air bags will probably not inflate front seatbacks closest to the doors.
  • Page 48 Remember, since air bags deploy only one not work properly. Have the air bag system time during an accident, seat belts are 54G027 inspected by an authorized SUZUKI dealer needed to restrain occupants from further as soon as possible. Side air bag will probably not inflate movements during the accident.
  • Page 49 30 kg (65 lbs) or less. The front air tion. Have the air bag system inspected by bag should be turned off in the following NOTE: an authorized SUZUKI dealer as soon as situations: The front passenger’s side air bag is not possible.
  • Page 50 Whenever possible, SUZUKI recom- • A smaller person, such as a child who mends you install child restraints in the has outgrown child restraints or a very rear seat.
  • Page 51 Have the proper position. system inspected by an authorized • A rear seat occupant is pushing or SUZUKI dealer as soon as possible. pulling on the seatback or is push- ing up the seat cushion using their WARNING feet.
  • Page 52 Supplemental Restraint System (advanced air bags): 3, 9, 12 BEFORE DRIVING How the System Works the air bag may irritate bare skin, such as the facial area against a front air bag. Also, In a frontal collision, the crash sensors will detect rapid deceleration and send a signal upon inflation, a loud noise will occur and some powder and smoke will be released.
  • Page 53 SUZUKI dealer as soon as possible. and the driver or front passenger. If it is necessary to modify the advanced These objects may interfere with air...
  • Page 54 Supplemental Restraint System (advanced air bags): 3, 9, 12 BEFORE DRIVING MEMO 2-41 54G27-03E...

  • Page 55: Steering Column Controls

    STEERING COLUMN CONTROLS STEERING COLUMN CONTROLS Ignition Switch ..............3-1 Lighting/Turn Signal Control Lever ........3-3 Windshield Wiper and Washer Lever ........ 3-4 Rear Window Wiper/Washer Switch (if equipped) ... 3-5 Tilt Steering Lock Lever ............. 3-6 Cruise Control (if equipped) ..........3-6 Remote Audio Controls (if equipped) .......

  • Page 56: Ignition Switch: 8

    Ignition Switch: 8 STEERING COLUMN CONTROLS Ignition Switch Manual transaxle Push Turn to “LOCK” 65D611 60A055 60B041 • Manual transaxle vehicles WARNING The ignition switch has the following four You must push in the key to turn it to the positions: “LOCK”...
  • Page 57 SUZUKI dealer. one of the other positions. If you have trou- • Do not leave the ignition switch in ble turning the key to unlock the steering, the “ON” position if the engine is...

  • Page 58: Lighting/Turn Signal Control Lever: 8

    Lighting/Turn Signal Control Lever: 8 STEERING COLUMN CONTROLS Lighting/Turn Signal Control Daytime Running Light (D.R.L.) Sys- Lever The headlights light, but are dimmer than HIGH This control lever is located on the out- the low beam, when the following three board side of the steering column.

  • Page 59: Windshield Wiper And Washer Lever: 8

    Lighting/Turn Signal Control Lever: 8 Windshield Wiper and Washer Lever: 8 STEERING COLUMN CONTROLS Turn Signal Operation Windshield Wiper and Washer With the ignition switch in the “ON” posi- EXAMPLE Lever tion, move the lever up or down to activate the right or left turn signals.

  • Page 60: Rear Window Wiper/Washer Switch (If Equipped)

    Windshield Wiper and Washer Lever: 8 Rear Window Wiper/Washer Switch: 8 STEERING COLUMN CONTROLS Windshield Washer Rear Window Wiper/Washer CAUTION Switch (if equipped) EXAMPLE To help prevent damage to wind- shield wiper and washer system EXAMPLE components, you should take the fol- lowing precautions: •...

  • Page 61: Tilt Steering Lock Lever: 6

    Rear Window Wiper/Washer Switch: 8 Tilt Steering Lock Lever: 6 Cruise Control: 7, 8 STEERING COLUMN CONTROLS Tilt Steering Lock Lever Cruise Control (if equipped) CAUTION Clear ice or snow from the rear win- EXAMPLE dow and rear wiper blade before LOCK using the rear wiper.
  • Page 62 Cruise Control: 7, 8 STEERING COLUMN CONTROLS the lever. The new speed will be main- tained. To reset the cruise control to a faster speed, use either of the following proce- dures: • Move the control lever up in the “RES/ ACC”...

  • Page 63: Remote Audio Controls (If Equipped)

    Cruise Control: 7, 8 Remote Audio Controls: Horn: 6 STEERING COLUMN CONTROLS Cruise control operation will also be can- Remote Audio Controls Horn celled any time the vehicle speed falls (if equipped) below 40 km/h (25 mph). To “Resume” a Previously Set Speed After canceling cruise control operation without turning off the “CRUISE ON-OFF”...
  • Page 64 STEERING COLUMN CONTROLS MEMO 54G27-03E...

  • Page 65: Instrument Panel

    INSTRUMENT PANEL INSTRUMENT PANEL Instrument Panel ..............4-1 Instrument Cluster .............. 4-2 Warning and Indicator Lights ..........4-3 A/T Selector Position Indicator (if equipped) ....4-7 Speedometer/Odometer/Trip meter ........4-7 Brightness Control .............. 4-8 Tachometer ................4-9 Fuel Gauge ................4-9 Temperature Gauge ............

  • Page 66: Instrument Panel

    Instrument Panel: 3, 8 INSTRUMENT PANEL Instrument Panel EXAMPLE 1. Instrument cluster 2. Ignition switch 3. Lighting switch/Turn signal and dim- mer switch 4. Windshield wiper and washer switch/ Rear window wiper and washer 11 17 5 switch (if equipped) 5.

  • Page 67: Instrument Cluster: 8

    Instrument Cluster: 8 INSTRUMENT PANEL Instrument Cluster 1. Speedometer 2. Odometer/Trip meter 3. Odometer/Trip meter selector knob 4. Meter illumination control knob 5. Tachometer 6. Fuel gauge 7. Temperature gauge 8. Warning and indicator lights EXAMPLE 54G523 54G27-03E...

  • Page 68: Warning And Indicator Lights

    If one of these happens, have the system the vehicle’s brake system. If this happens, cle operation. inspected by your SUZUKI dealer. If the you should: ABS becomes inoperative, the brake sys- 1) Pull off the road and stop carefully.
  • Page 69 If there is For details about the seat belt reminder, enough oil, the lubrication system should refer to “Seat Belts and Child Restraint be inspected by your SUZUKI dealer Systems” in the “BEFORE DRIVING” sec- before you drive the vehicle again. tion.
  • Page 70 If the “AIR BAG” light does not blink when the ignition switch is turned to essary. Bring the vehicle to your SUZUKI NOTE: dealer to have the emission control system the “ON” position or stays on or...
  • Page 71 Warning and Indicator Lights: 8 INSTRUMENT PANEL Open Door Warning Light “CRUISE” Indicator Light Turn Signal Indicators (if equipped) 54G391 50G055 52D113 This light remains on until all doors are When you turn on the left or right turn sig- completely closed.

  • Page 72: A/T Selector Position Indicator (If Equipped)

    Warning and Indicator Lights: 8 A/T Selector Position Indicator: 8 Speedometer/Odometer/Trip meter: 8 INSTRUMENT PANEL Daytime Running Light (D.R.L.) Indi- A/T Selector Position Speedometer/Odometer/Trip cator Light (if equipped) Indicator (if equipped) meter EXAMPLE 60B245 With the D.R.L. system, the headlights light, but are dimmer than the low beam, when the following three conditions are all met.

  • Page 73: Brightness Control

    Speedometer/Odometer/Trip meter: 8 Meter Illumination Control: INSTRUMENT PANEL Brightness Control CAUTION Keep track of your odometer reading EXAMPLE and check the maintenance schedule regularly required services. Increased wear or damage to certain parts can result from failure to per- form required services at the proper mileage intervals.

  • Page 74: Tachometer

    Tachometer: Fuel Gauge: INSTRUMENT PANEL Tachometer Fuel Gauge If the low fuel warning light (1) comes on, fill the fuel tank immediately. EXAMPLE NOTE: The activation point of the low fuel warning light (1) varies depending on road condi- tions (for example, slope or curve) and driving conditions because of fuel moving in the tank.

  • Page 75: Temperature Gauge: 8

    Temperature Gauge: 8 Hazard Warning Switch: 8 Rear Window Defroster Switch: INSTRUMENT PANEL Temperature Gauge Hazard Warning Switch Rear Window Defroster Switch (if equipped) 54G458 54G510 When the ignition switch is in the “ON” Push in the hazard warning switch to acti- 54G610 position, this gauge indicates the engine vate the hazard warning lights.

  • Page 76: Outside Rearview Mirrors Defroster Switch (If Equipped)

    Outside Rearview Mirrors Defroster Switch: Fog Light Switch: 8 Cigarette Lighter and Ashtray: 3, 8 INSTRUMENT PANEL Outside Rearview Mirrors Fog Light Switch (if equipped) Cigarette Lighter and Ashtray Defroster Switch (if equipped) (if equipped) 54G448 The front fog light comes on when the fog 54G447 54G460 light switch is pushed in with the lighting...

  • Page 77: Information Display

    Cigarette Lighter and Ashtray: 3, 8 Information Display: INSTRUMENT PANEL Information Display CAUTION WARNING To avoid damage to the cigarette Make sure tobacco is fully extin- lighter socket, do not use it as an guished before closing the ashtrays. accessory power source.
  • Page 78 Information Display: INSTRUMENT PANEL Clock and Thermometer the same level that was set the last time Front Passenger’s Seat Belt that the lighting switch was in the second Reminder Light or third position. Clock (1) To set the clock, push the “ILLUMI” knob (a) and continue holding.

  • Page 79: Glove Box: 3

    Information Display: Glove Box: 3 INSTRUMENT PANEL Systems” in the “BEFORE DRIVING” sec- “PASS AIRBAG OFF” Indicator Glove Box tion. WARNING It is absolutely essential that the driver and passengers wear their seat belts at all times. Persons who are not wearing seat belts have a much greater risk of injury if an accident occurs.

  • Page 80: Heating And Air Conditioning System: 4

    Heating and Air Conditioning System: 4 INSTRUMENT PANEL Heating and Air Conditioning Air Outlet System There are various types of heating and air conditioning system as follows: • Heating System • Manual Heating and Air Conditioning System • Automatic Heating and Air Conditioning System (Climate Control) 54G476 1.

  • Page 81: Heating System

    Heating and Air Conditioning System: 4 INSTRUMENT PANEL Side outlet Heating System Description of Controls 65D493 FRESH AIR When this mode is selected, the indicator light (a) will come on and outside air is used. Close Open RECIRCULATED AIR 54G462 When this mode is selected, the indicator light (b) will come on, outside air is shut out When “Open”, air comes out regardless of...
  • Page 82 Heating and Air Conditioning System: 4 INSTRUMENT PANEL Air flow selector (3) Bi-level (d) Heater & defrost (f) 54G169 54G163 Temperature-controlled air comes out of Temperature-controlled air comes out of the floor outlets and cooler air comes out the floor outlets, the windshield defroster of the center and side outlets.
  • Page 83 Heating and Air Conditioning System: 4 INSTRUMENT PANEL have the system inspected by an autho- heating and change to the normal heating rized SUZUKI dealer. method as soon as possible. System Operating Instructions Head cooled/Feet warmed heating Select “BI-LEVEL” and “FRESH AIR”, the...

  • Page 84: Manual Heating And Air Conditioning System

    Heating and Air Conditioning System: 4 INSTRUMENT PANEL Manual Heating and Air Blower speed selector/Air intake selec- Air flow selector (3) tor (2) Conditioning System This is used to turn on the blower and to select blower speed by turning the selec- Description of Controls tor.
  • Page 85 If the indicator light (i) blinks, there is a problem in the heating system and/or air conditioning system. You should have the system inspected authorized SUZUKI dealer. System Operating Instructions 54G169 54G163 Natural ventilation Temperature-controlled air comes out of Temperature-controlled air comes out of Select “VENTILATION”...
  • Page 86 Heating and Air Conditioning System: 4 INSTRUMENT PANEL air in the vehicle can become contami- Normal cooling Dehumidifying nated and the windows can become misty. Turn on the “A/C” switch, set the air flow Turn on the “A/C” switch, set the air flow Therefore, use this method only for quick selector to “VENTILATION”, the tempera- selector to a desired air flow selector posi-...

  • Page 87: Automatic Heating And Air Conditioning System (Climate Control)

    Heating and Air Conditioning System: 4 INSTRUMENT PANEL Maintenance Automatic Heating and Air If you do not use the air conditioner for a Conditioning System long period, such as during winter, it may (Climate Control) not give the best performance when you start using it again.
  • Page 88 Heating and Air Conditioning System: 4 INSTRUMENT PANEL Temperature selector/Air conditioning Blower speed selector/Air intake selec- switch (1) tor (2) EXAMPLE 65D493 FRESH AIR When this mode is selected, the indicator light (a) will come on and outside air is used.
  • Page 89 Heating and Air Conditioning System: 4 INSTRUMENT PANEL Air flow selector (3) Bi-level (d) Heater & defrost (f) 54G169 54G163 Temperature-controlled air comes out of Temperature-controlled air comes out of the floor outlets and cooler air comes out the floor outlets, the windshield defroster of the center and side outlets.
  • Page 90 (2) and the air The air conditioning switch (1) is to be SUZUKI dealer. flow selector (3) are in the “AUTO” posi- selected manually according to your taste. tion, turn either the selector (2) or (3) to...

  • Page 91: Audio Systems

    Audio Systems: INSTRUMENT PANEL Maintenance Audio Systems If you do not use the air conditioner for a There are two types of audio system as long period, such as during winter, it may shown below: not give the best performance when you start using it again.
  • Page 92 Please bring the unit to an authorized SUZUKI dealer or a MITSUBISHI ser- vice Department. 52D275 To remove the compact disc from its stor- age case, press down on the center of the case and lift the disc out, holding it care- fully by the edges.
  • Page 93 Audio Systems: INSTRUMENT PANEL Never touch the surface. prevent the system from operating prop- erly. 52D348 52D347 Never stick labels on the surface of the 52D351 To remove fingermarks and dust, use a compact disc or mark the surface with a soft cloth, and wipe in a straight line from pencil or pen.
  • Page 94 Audio Systems: INSTRUMENT PANEL Basic Operations (1) Power on/off knob Volume control knob (2) Tone/balance/fader control knob Type 1 AM/FM CD PLAYER Turning power on/off Press the power on/off knob (1). The unit starts in the function mode it was in when the power was turned off last.
  • Page 95 Audio Systems: INSTRUMENT PANEL Adjusting bass/treble/balance/fader Volume control knob (1) TREBLE 1) Press the tone/balance/fader control Tone/balance/fader control knob (2) knob (2). Each time it is pressed, sound adjust- ment is changed as follows: Bass adjustment 54G545 FADER 54G542 Treble adjustment Volume Fader adjustment Balance adjustment...
  • Page 96 Audio Systems: INSTRUMENT PANEL Listening to the Radio Display Type 1 AM/FM CD PLAYER 54G596 (1) Band switch button (FM/AM) (2) Seek up button (3) Seek down button (4) Manual tuning knob (5) Preset buttons (1 to 6) (6) Auto store button (A/S) (7) Scan button (SCAN) (A) Band (B) Preset channel number...
  • Page 97 Audio Systems: INSTRUMENT PANEL Selecting the reception band Six stations in total are automatically Radio Reception Press the band switch button (1). stored to the preset buttons (5) in sequen- • Radio reception can be affected by envi- Each time the button is pressed, the recep- tial order, starting from the lower frequen- ronment, atmospheric conditions, or tion band is switched as follows:...
  • Page 98 Audio Systems: INSTRUMENT PANEL Radio Antenna Listening to a CD CAUTION The radio antenna wire is printed inside the rear window. • Never insert your finger or hand into the CD insertion slot. Never CAUTION insert foreign objects. • Never insert a CD with glue coming •...
  • Page 99 Audio Systems: INSTRUMENT PANEL About MP3/WMA Playback order MP3/WMA files are played back in order from (1) to (5) as shown in the illustration. Vacant folders are skipped. • Applicable file systems are ISO9660 : Folder : MP3/WMA file (level 1 and level 2), Joliet and Romeo. •...
  • Page 100 Audio Systems: INSTRUMENT PANEL ID3 Tag Joliet Playable WMA files This identifies the data including the track This is a proposed logical format for CD- • Applicable sampling frequencies are 32, name, artist name and album name ROMs by Microsoft, and maximum number 44.1 and 48 kHz.
  • Page 101 Audio Systems: INSTRUMENT PANEL Type 1 Display AM/FM CD PLAYER (Built in CD Player) (B) (C) 54G599 (1) CD insertion slot (2) CD eject button (3) CD/AUX button (4) Track up button/Fast forward button (5) Track down button/Rewind button (6) Repeat button (RPT) (7) Random button (RDM) (10) (8) Scan button (SCAN)
  • Page 102 Audio Systems: INSTRUMENT PANEL Loading a CD Selecting a track The repeat indicator “D-RPT” (B) lights, Insert a CD in the CD insertion slot (1). • Press the track up button (4) to listen to and tracks in the current folder are played When a CD is loaded, play starts and the the next track.
  • Page 103 Audio Systems: INSTRUMENT PANEL Scan play Selecting the display MP3/WMA Pressing the scan button (8) plays back Press the display/page button (10). CD-DA the initial 10-sec part of the next music Each time the button is pressed, the dis- Press the display/page button (10). track and then the initial 10-sec part of play is switched as follows: Each time the button is pressed, the dis-...
  • Page 104 Audio Systems: INSTRUMENT PANEL Type 2 Display AM/FM 6-CD PLAYER (Built-in CD Changer) 54G603 (10) (1) Load button (LOAD) (2) Disc select buttons (1 to 6) (3) CD insertion slot (4) CD eject button (5) CD/AUX button (6) Track up button/Fast forward button (12) (7) Track down button/Rewind button (8) Repeat button (RPT)/Disc repeat play...
  • Page 105 Audio Systems: INSTRUMENT PANEL NOTE: Ejecting one CD About Single CDs (8 cm CDs) CAUTION 1) Select the CD you want to remove with • Since the unit is not compatible with a the disc select buttons (2). You can load a CD only while the load single CD, do not load it into the unit.
  • Page 106 Audio Systems: INSTRUMENT PANEL The back up eject mechanism: Selecting a track When all the tracks on a disc being cur- This function allows you to eject the CD • Press the track up button (6) to listen to rently played finish playing, the beginning loaded in the unit with the unit turned off the next track.
  • Page 107 Audio Systems: INSTRUMENT PANEL Scan play Selecting the display MP3/WMA Scan is begun by pressing the scan button Press the display/page button (12). CD-DA (9) during playback. (Only the contents of Each time the button is pressed, the dis- Press the display/page button (12). the disc being played are scanned.) play is switched as follows: Each time the button is pressed, the dis-...
  • Page 108 Audio Systems: INSTRUMENT PANEL Remote Audio Controls To change the radio station: • Pulling up switch (4) advances to the (if equipped) next preset station. • Pulling up and holding switch (4) for 2 seconds searches for a station at a higher frequency.
  • Page 109 Audio Systems: INSTRUMENT PANEL Anti-Theft Function (1) Disc select buttons (1 to 4) (2) Power on/off knob (3) CD/AUX button Type 1 AM/FM CD PLAYER (4) Track up button/Fast forward button Setting the Anti-Theft Function 1) Turn off the power by pressing the power on/off knob (2).
  • Page 110 Audio Systems: INSTRUMENT PANEL How to input the code number Cancel Your Established PIN (for example “0364”) Setting This operation is to be done when you want to cancel the anti-theft code or change your code number. 1) Turn off the power by pressing the power on/off knob (2).
  • Page 111 Audio Systems: INSTRUMENT PANEL Confirming Your Personal Identifi- When a Wrong Code Number is NOTE: • Note that the unit does not accept any cation Number (PIN) Input operation while “OFF” is displayed. If When the main power source is uncon- “ACC OFF”...
  • Page 112 INSTRUMENT PANEL Troubleshooting Applicable to every device Phenomenon Cause Remedy Power is not turned on. Fuse is blown. Contact your authorized SUZUKI dealer. (No sound is produced) Connections are not properly made. Contact your authorized SUZUKI dealer. Radio Phenomenon Cause Remedy Too much noises.
  • Page 113 Audio Systems: INSTRUMENT PANEL Error Display An error message may not be displayed quickly depending on the degree of scratches or dirt on the CD. If sound is not output for a while after a CD is inserted, there may be scratches or dirt on the CD. Eject it, and insert another CD. Error code Mode Description...
  • Page 114 INSTRUMENT PANEL MEMO 4-49 54G27-03E...

  • Page 115: Other Controls And Equipment

    OTHER CONTROLS AND EQUIPMENT OTHER CONTROLS AND EQUIPMENT Parking Brake Lever ............5-1 Pedals ................... 5-1 Gearshift Lever ..............5-2 Fuel Filler Cap ..............5-3 Folding Rear Seats .............. 5-4 Armrest (if equipped) ............5-6 Sun Visor ................5-6 Interior Light Switch ............5-6 Spot Light ................

  • Page 116: Parking Brake Lever: 6

    52D122 inspected immediately by an autho- 52D131 (1) To set rized SUZUKI dealer. (2) To release Automatic transaxle (3) To release WARNING The parking brake lever is located between the seats.

  • Page 117: Gearshift Lever: 10

    This pedal controls the speed of the age. engine. Depressing the accelerator pedal increases power output and speed. Brake Pedal (2) Your SUZUKI vehicle is equipped with front 60B095 disc brakes and rear drum brakes. Depressing the brake pedal applies both 4-speed automatic transaxle sets of brakes.

  • Page 118: Fuel Filler Cap: 5

    Gearshift Lever: 10 Fuel Filler Cap: 5 OTHER CONTROLS AND EQUIPMENT Your vehicle is equipped with either a man- Fuel Filler Cap ual transaxle or automatic transaxle. The gearshift lever for each transaxle type is EXAMPLE shown in the illustrations. For details on how to use the transaxle, refer to the “Using the Transaxle”...

  • Page 119: Folding Rear Seats: 3

    WARNING If you need to replace the fuel cap, use a genuine SUZUKI cap or its equivalent. Use of an improper cap can result in a malfunction of the fuel system or emission control system. It...
  • Page 120 Folding Rear Seats: 3 OTHER CONTROLS AND EQUIPMENT CAUTION When you move a seatback, make sure the belt webbing is hooked in the belt hangers so the seat belts are not caught by the seatback, seat hinge, or seat latch. This helps pre- vent damage to the belt system.

  • Page 121: Armrest (If Equipped)

    Folding Rear Seats: 3 OTHER CONTROLS AND EQUIPMENT Armrest (if equipped) Sun Visor Interior Light Switch EXAMPLE 54G464 79J161 52D071 From the stowed (fully up) position, lower The sun visors can be pulled down to block The interior light switch has three posi- the armrest as far as it will go.

  • Page 122: Spot Light

    Folding Rear Seats: 3 OTHER CONTROLS AND EQUIPMENT Spot Light Assist Grips (if equipped) EXAMPLE 54G051 NOTE: 65D022 54G249 The number of doors involved in the light- Push the switch to turn on the light and Assist grips are provided for passenger ing operation of the interior light depends push it again to turn off the light.

  • Page 123: Coat Hooks (If Equipped)

    Folding Rear Seats: 3 OTHER CONTROLS AND EQUIPMENT Coat Hooks (if equipped) Eyeglasses Holder Engine Hood (if equipped) 54G303 54G485 You can hang clothing on the coat hooks. To open the engine hood: 86G067 These hooks are not designed for large or 1) Pull the hood release handle located on To use the eyeglasses holder, open the heavy items.

  • Page 124: Cup Holder And Storage Area (If Equipped)

    Folding Rear Seats: 3 Armrest: 3 OTHER CONTROLS AND EQUIPMENT Cup Holder and Storage Area EXAMPLE (if equipped) EXAMPLE 54G497 3) Continue to lift up the hood until it is high enough to support with the prop 54G466 rod. Cup holders are provided in the center To close the engine hood: console.

  • Page 125: Accessory Socket (If Equipped)

    Sun Visor: 5 Interior Light Switch: 7 OTHER CONTROLS AND EQUIPMENT (if equipped) Accessory Socket CAUTION (if equipped) Use of inappropriate electrical acces- sories can cause damage to your vehicle’s electrical system. Make sure that any electrical accessories you use are designed to plug into this type of socket.

  • Page 126: Frame Hooks

    Spot Light: 7 Assist Grips: 3 Coat Hooks: OTHER CONTROLS AND EQUIPMENT Frame Hooks Rear (type A) Frame hooks (1) are provided on the front and rear of the vehicle for use in emer- EXAMPLE Front (type A) gency situations. EXAMPLE For type A model, remove the cover to access the front hook (1).

  • Page 127: Tire Changing Tools

    Eyeglasses Holder: Engine Hood: 5 OTHER CONTROLS AND EQUIPMENT Tire Changing Tools CAUTION EXAMPLE Do not use the right hand frame hook, or the towing rope will bear against the front bumper, possibly damaging it. The hook (2) is provided for sea shipping purposes only.

  • Page 128: Front Seat Back Pocket (If Equipped)

    Cup Holder and Storage Area: 3 OTHER CONTROLS AND EQUIPMENT Front Seat Back Pocket Trunk Light WARNING (if equipped) The jack should be used only to EXAMPLE change wheels. It is important to read EXAMPLE jacking instructions “EMERGENCY SERVICE” section of this manual before attempting to use the jack.

  • Page 129: Operating Your Vehicle

    OPERATING YOUR VEHICLE OPERATING YOUR VEHICLE Exhaust Gas Warning ............6-1 Daily Inspection Checklist ..........6-1 Starting the Engine ............. 6-2 Engine Block Heater (if equipped) ........6-3 Using the Transaxle ............6-4 Braking ................. 6-7 Break-In ................6-9 Catalytic Converter ............. 6-9 Improving Fuel Economy ...........

  • Page 130: Exhaust Gas Warning

    Exhaust Gas Warning: NO Daily Inspection Checklist: NO OPERATING YOUR VEHICLE Exhaust Gas Warning Daily Inspection Checklist WARNING Before Driving (Continued) 1) Make sure that windows, mirrors, lights • Do not park with the engine run- and reflectors are clean and unob- ning for a long period of time, even structed.

  • Page 131: Starting The Engine: 1

    (or Park for vehicles with an auto- If you are unable to start the engine using it can fly up unexpectedly during matic transaxle) before attempting to this procedure, consult your SUZUKI driving, obstructing your view and start the engine. dealer.

  • Page 132: Engine Block Heater (If Equipped)

    Engine Block Heater: 1 OPERATING YOUR VEHICLE Engine Block Heater NOTE: 3) Close the engine hood securely before Activate the heater at least four hours starting the engine. (if equipped) before you start the engine. However, as the heating time varies depending on the ambient temperature and other factors, adjust the time by observing the engine cranking condition.

  • Page 133: Using The Transaxle: 10

    Using the Transaxle: 10 OPERATING YOUR VEHICLE Using the Transaxle 4-speed 3-speed 4-Speed Automatic Transaxle EXAMPLE 52D186 54G069 To return the transaxle to the 4-speed The gearshift lever has a lock mechanism mode, push in the overdrive off switch to help prevent accidental shifting into or 54G606 again.
  • Page 134 Using the Transaxle: 10 OPERATING YOUR VEHICLE D (Drive) WARNING Use this position for all normal driving. CAUTION Always depress the brake pedal With the selector in “D” range, you can get Be sure to take the following precau- an automatic downshift by pressing the before shifting from “P”...
  • Page 135 Using the Transaxle: 10 OPERATING YOUR VEHICLE Emergency shifting out of “P” (Park) Manual Transaxle If you are unable to shift the transaxle out WARNING of Park in the normal manner, see “If You EXAMPLE • Reduce your speed and downshift Can Not Shift Automatic Transaxle Gear- to a lower gear before going down shift Lever Out of “P”...

  • Page 136: Braking: 6

    Braking: 6 OPERATING YOUR VEHICLE Braking WARNING WARNING If water gets into the brake drums, Even without reserve power in the brake performance may become poor brake system, you can still stop the and unpredictable. vehicle by pressing the brake pedal After driving through water or wash- harder than normally required.
  • Page 137 If both warning conditions will safely allow. lights come on, drive carefully, avoid- ing hard braking as much as possi- ble, and ask your SUZUKI dealer to inspect the ABS system immediately. 54G27-03E...

  • Page 138: Break-In: 6

    Braking: 6 Break-In: 6 Catalytic Converter: NO OPERATING YOUR VEHICLE How the ABS Works Break-In Catalytic Converter A computer continuously monitors wheel speed. computer compares CAUTION changes in wheel speed when braking. If the wheels slow suddenly, indicating a The future performance and reliabil- skidding situation, computer...

  • Page 139: Improving Fuel Economy

    Catalytic Converter: NO Improving Fuel Economy: NO OPERATING YOUR VEHICLE Improving Fuel Economy CAUTION The following instructions will help you improve fuel economy. To minimize the possibility of catalyst or other vehicle damage: Avoid excessive idling • Maintain the engine in the proper If you are to wait for more than a minute operating condition.
  • Page 140 Improving Fuel Economy: NO OPERATING YOUR VEHICLE EXAMPLE 60A183S Keep the air cleaner clean A dirty air cleaner will cause the fuel injec- tion system to supply too much fuel to the engine for the amount of air being sup- plied.

  • Page 141: Driving Tips

    DRIVING TIPS DRIVING TIPS Highway Driving ..............7-1 Driving on Hills ..............7-1 Driving on Slippery Roads ..........7-2 60G409 54G27-03E...
  • Page 142 Highway Driving: NO Driving on Hills: NO DRIVING TIPS Highway Driving Driving on Hills When driving at highway speeds, pay attention to the following: • Stopping distance progressively increases with vehicle speed. Apply the brakes far enough ahead of the stopping point to allow for the extra stopping dis- 52D078S tance.
  • Page 143 Driving on Hills: NO Driving on Slippery Roads: NO DRIVING TIPS Driving on Slippery Roads If Your Vehicle Gets Stuck WARNING If your vehicle gets stuck in snow, mud or sand, follow the directions below: Try not to hold the brake pedal down 1) Shift the transaxle back and forth too long or too often while going between a forward range (or first gear...
  • Page 144 • Do not use tires other than those • Even when driving through shallow or and tighten them. specified by SUZUKI. Never use dif- still waters, drive carefully since the If your vehicle is equipped with full ferent sizes or types of tires on the...
  • Page 145 Driving on Slippery Roads: NO DRIVING TIPS WARNING (Continued) • Never use oversized tires or special shocks and springs to raise (jack up) your vehicle. This will change its handling characteristics. Over- sized tires may also rub against the fender over bumps, causing vehicle damage or tire failure.
  • Page 146 DRIVING TIPS MEMO 54G27-03E...

  • Page 147: Vehicle Loading And Towing

    VEHICLE LOADING AND TOWING VEHICLE LOADING AND TOWING Vehicle Loading ..............8-1 Trailer Towing ..............8-2 Towing Your Vehicle (recreational towing) ...... 8-2 54G215 54G27-03E...
  • Page 148 Vehicle Loading: 11 VEHICLE LOADING AND TOWING Vehicle Loading Vehicle Capacity Weight – Maximum per- missible load weight a vehicle can carry WARNING including the weight of all the occupants, Never overload your vehicle. The accessories and cargo. gross vehicle weight (sum of the weights of the loaded vehicle, driver The weight of any accessories already and passengers) must never exceed...
  • Page 149 Trailer Towing: 5, 11, 13 Towing Your Vehicle (recreational towing): 13 VEHICLE LOADING AND TOWING Trailer Towing Towing Your Vehicle TOWING INSTRUCTION TABLE (recreational towing) DRIVE TRAN- TOWING Your vehicle may be towed behind another TRAIN SAXLE METHOD vehicle (such as a motorhome), provided A/T (AUTO) your vehicle is 2 wheel drive (2WD) and you use the proper towing method speci-...
  • Page 150 Towing Your Vehicle (recreational towing): 13 VEHICLE LOADING AND TOWING A: 2WD VEHICLES WITH MANUAL TRANSAXLE OR AUTOMATIC TRAN- TOWING METHOD A SAXLE FROM THE FRONT: 1) Secure the front wheels on a towing FRONT WHEELS ON A DOLLY dolly according to the instructions pro- AND REAR WHEELS ON THE GROUND vided by the dolly manufacturer.
  • Page 151 Towing Your Vehicle (recreational towing): 13 VEHICLE LOADING AND TOWING B: 2WD VEHICLES WITH MANUAL TRANSAXLE TOWING METHOD B 1) Shift the manual transaxle lever into FROM THE FRONT: neutral. FOUR WHEELS ON THE GROUND 2) Turn the ignition key to the “ACC” posi- tion to unlock the steering wheel.
  • Page 152 VEHICLE LOADING AND TOWING MEMO 54G27-03E...

  • Page 153: Inspection And Maintenance

    INSPECTION AND MAINTENANCE INSPECTION AND MAINTENANCE Maintenance Schedule ............9-2 Periodic Maintenance Schedule ........9-3 Maintenance Recommended under Severe Driving Conditions ................9-7 Engine Oil and Filter ............9-11 Gear Oil ................9-14 Automatic Transaxle Fluid ..........9-16 Engine Coolant ..............9-17 Windshield Washer Fluid ...........
  • Page 154 • Do not get under your vehicle if it is electrical service work on your supported only with the portable SUZUKI. Do not touch air bag sys- jack provided in your vehicle. tem components or wires. The (Continued)

  • Page 155: Maintenance Schedule

    SUZUKI recommends that mainte- nance on items marked with an aster- performed your authorized SUZUKI dealer or a quali- fied service technician. If you are qualified, you may perform mainte- nance on the unmarked items by referring to the instructions in this section.

  • Page 156: Periodic Maintenance Schedule

    Periodic Maintenance Schedule: 1, 2, 3, 4, 5, 6, 9, 10 INSPECTION AND MAINTENANCE Periodic Maintenance Schedule R: Replace or change I : Inspect and correct, replace or lubricate if necessary miles (x 1000) 22.5 37.5 52.5 67.5 Interval: This interval should be judged by odometer km (x 1000) 12.5 37.5...
  • Page 157 SUZUKI, however, urges that all recommended maintenance services be performed at the indicated inter- vals and the maintenance recorded.

  • Page 158: Maintenance Recommended Under Severe Driving Conditions

    Maintenance Recommended under Severe Driving Condi- tions: 1, 2, 3, 4, 5, 6, 9, 10 INSPECTION AND MAINTENANCE R: Replace or change I : Inspect and correct, replace or lubricate if necessary miles (x 1000) 22.5 37.5 52.5 67.5 Interval: This interval should be judged by odometer km (x 1000) 12.5 37.5...
  • Page 159 Maintenance Recommended under Severe Driving Condi- tions: 1, 2, 3, 4, 5, 6, 9, 10 INSPECTION AND MAINTENANCE R: Replace or change I : Inspect and correct, replace or lubricate if necessary miles (x 1000) 82.5 97.5 112.5 127.5 142.5 Interval: This interval should be judged by odometer km (x 1000) 137.5...

  • Page 160: Engine Oil And Filter

    Engine Oil and Filter: 1, 2 INSPECTION AND MAINTENANCE Maintenance Recommended under Severe Driving Conditions Follow this schedule if your car is mainly operated under one or more of the following conditions: • When most trips are less than 6 kilometers (4 miles) •...
  • Page 161 Engine Oil and Filter: 1, 2 INSPECTION AND MAINTENANCE R: Replace or change I : Inspect and correct, replace or lubricate if necessary miles (x 1000) Interval: This interval should be judged by odometer km (x 1000) reading or months, whichever comes first. months ENGINE &...
  • Page 162 Engine Oil and Filter: 1, 2 INSPECTION AND MAINTENANCE R: Replace or change I : Inspect and correct, replace or lubricate if necessary miles (x 1000) Interval: This interval should be judged by odometer km (x 1000) reading or months, whichever comes first. months CHASSIS AND BODY 1.

  • Page 163: Gear Oil

    Engine Oil and Filter: 1, 2 Gear Oil: 6, 10 INSPECTION AND MAINTENANCE R: Replace or change I : Inspect and correct, replace or lubricate if necessary miles (x 1000) Interval: This interval should be judged by odometer km (x 1000) reading or months, whichever comes first.
  • Page 164 Gear Oil: 6, 10 INSPECTION AND MAINTENANCE Engine Oil and Filter Oil Level Check FULL EXAMPLE Engine oil dipstick Specified Oil 10W-30 5W-30 Temperature EXAMPLE “Starburst” 52D084 The handle of the engine oil dipstick is col- 80G064 ored yellow for easy identification. 52D083 It is important to keep the engine oil at the Pull out the oil dipstick, wipe oil off with a...

  • Page 165: Automatic Transaxle Fluid: 10

    Automatic Transaxle Fluid: 10 INSPECTION AND MAINTENANCE Refilling Changing Engine Oil and Filter WARNING EXAMPLE EXAMPLE New and used oil and solvent can be hazardous. Children and pets may be harmed by swallowing new or used oil or solvent. Repeated, prolonged Open Close contact with used engine oil may...

  • Page 166: Engine Coolant

    (2) 3/4 turn ommended that you use a genuine ter counterclockwise and remove it. SUZUKI replacement filter. If you use 5) Tighten the filter 3/4 turn from the point 2) Using a clean rag, wipe off the mount- an after-market filter, make sure it is...
  • Page 167 If you find any leaks or are not sure that the filter has been properly tightened, have vehicle inspected your 54G096 SUZUKI dealer. API GRADE Manual transaxle/ GL-4 Transfer oil (AWD A/T) Rear differential oil GL-5 (Hypoid...

  • Page 168: Windshield Washer Fluid: 3

    Since special procedures, materials and Oil Filler Plug tools are required to change the automatic Manual transaxle transaxle oil, it is recommended that you 21 Nm trust this job to your authorized SUZUKI Transfer (15.2 lb-ft) dealer. (2.1 kg-m) Rear differential...

  • Page 169: Air Cleaner

    Windshield Washer Fluid: 3 Air Cleaner: 1, 2 INSPECTION AND MAINTENANCE Automatic Transaxle Fluid 5) With your foot on the brake pedal, move the gearshift lever through each Specified Fluid gear, pausing for about three seconds in each range. Then move it back to the Use an automatic transaxle fluid equiva- ®...

  • Page 170: Spark Plugs

    • Gives proper protection against freezing transaxle oil, it is recommended that you and boiling. FULL trust this job to your authorized SUZUKI • Gives proper protection against corro- dealer. sion and rust. Failure to use the proper coolant can dam- age your cooling system.

  • Page 171: Brakes: 6

    Brakes: 6 INSPECTION AND MAINTENANCE Engine Coolant Replacement CAUTION CAUTION Open Close (Continued) • The mixture you use should con- • Do not add extra inhibitors or addi- tain 50% concentration of anti- tives. They may not be compatible freeze. with your cooling system.
  • Page 172 Brakes: 6 INSPECTION AND MAINTENANCE Windshield Washer Fluid (or opposite side) 65D614 60A212 3) Loosen the drain plug attached to the 65D108 WARNING lower part of the radiator and drain the engine coolant into a suitable container. It is hazardous to remove the radiator 4) Reinstall the reservoir and fill it with cap when the engine coolant temper- engine coolant to the “FULL”...

  • Page 173: Steering Wheel: 6

    Brakes: 6 Steering Wheel: 6 INSPECTION AND MAINTENANCE Check that there is washer fluid in the tank Air Cleaner by looking at the washer fluid level gauge CAUTION which is attached to the cap of the washer The air cleaner element should be fluid tank.

  • Page 174: Clutch Pedal: 6

    “SPECIFICATIONS” section at the the release lever, end of this book. If you wish to use a 2) remove the bolt, and brand of spark plug other than the 3) pull the ignition coil out. specified plugs, consult your SUZUKI dealer. 9-21 54G27-03E...
  • Page 175 Should the light come on, immedi- Check that the fluid level is between the cal attention. Wash thoroughly after ately ask your SUZUKI dealer to “MAX” and “MIN” lines. If the brake fluid handling. Solution can be poisonous inspect the brake system.
  • Page 176 With disc brakes, the fluid level can be inspected by your SUZUKI dealer. WARNING expected to gradually fall as the brake If you experience any of the following pads wear. problems with your vehicle’s brake...
  • Page 177 ® saxle fluid equivalent to ATF DEXRON inspected and/or adjusted by your SUZUKI wrong, an inspection must be performed ® (Esso JWS 2326) or DEXRON -III. Do not dealer.
  • Page 178 E. Uniform Tire Quality Grading (UTQG) depressed, have the clutch inspected by Tire manufacturers are required to your SUZUKI dealer. If the clutch fluid level grade tires based on three perfor- is near the “MIN” line, fill it up to the “MAX”...
  • Page 179 (Ratings are listed WARNING below.) Your SUZUKI is equipped with tires which are all the same type and size. Letter Rating Speed Rating This is important to ensure proper 99 mph steering and handling of the vehicle.
  • Page 180 Tires: 6 INSPECTION AND MAINTENANCE 5) If the air pressure is too low, fill the tire Recommended Cold Tire Inflation with air at a service station until it Pressures reaches the recommended pressure. 6) Make sure all tires have the same air 210 kPa pressure (unless the owner’s manual Front Tires...
  • Page 181 SUZUKI Motor Corpora- WARNING tion as standard or optional equip- Your SUZUKI is equipped with tires ment your vehicle. which are all the same type and size. information regarding the specified This is important to ensure proper...
  • Page 182 WARNING system, which applies to vehicles sold in est, are AA, A, B and C. Those grades rep- the U.S. Consult your SUZUKI dealer or The temperature grade for this tire is tire retailer for help in choosing the correct resent the tire’s ability to stop on wet...
  • Page 183 Tires: 6 INSPECTION AND MAINTENANCE schedule. After rotation, adjust front and Compact Spare Tire (if equipped) rear tire pressures to the specification WARNING listed on your vehicle’s Tire and Loading The compact spare tire and wheel are Information Label. intended for temporary emergency use only.

  • Page 184: Battery: 9

    SUZUKI recommends mounting radial securely seated on the hub. snow tires on all four wheels. Snow tires must be the same size as the standard tires. Also be sure to use the tires of the same type and brand on all four wheels of your vehicle.

  • Page 185: Fuses: 7

    Fuses: 7 INSPECTION AND MAINTENANCE GLOSSARY OF TIRE TERMINOL- vehicle capacity weight (total load capac- Vehicle Normal Load on the Tire – the load ity), and production options weight. on an individual tire that is determined by distributing to each axle its share of the Accessory Weight –...
  • Page 186 Fuses: 7 INSPECTION AND MAINTENANCE Label. The cargo load capacity can be chase, or that you or the dealer install after determined as described below. purchase, must be subtracted from the WARNING total load capacity to determine how much Cargo Load Capacity – Maximum weight Never overload your vehicle.
  • Page 187 Headlight Aiming: Bulb Replacement: 7 INSPECTION AND MAINTENANCE Steps for Determining Correct Load capacity is 950 lbs. If you were to drive than the original tires, or failure to keep the Limit your vehicle with one passenger, and the tires inflated to recommended tire pres- 1) Locate the statement “The combined total combined weight of you and your pas- sure, may reduce the GVWR or GAWR...
  • Page 188 Bulb Replacement: 7 INSPECTION AND MAINTENANCE Battery Fuses WARNING Your vehicle has three types of fuses, as described below: To avoid harm to yourself or damage EXAMPLE to your vehicle or battery, follow the Main Fuse – The main fuse takes current jump starting instructions in the directly from the battery.
  • Page 189 Bulb Replacement: 7 INSPECTION AND MAINTENANCE Fuses in the Engine Compartment an individual fuse, use a genuine SUZUKI Fuses under the Dash Board replacement. (2) (6) (10) (1) (3) (11) USE THE DESIGNATED FUSES AND RELAYS ONLY. BLOWN 54G119 60A243...

  • Page 190: Headlight Aiming

    Bulb Replacement: 7 INSPECTION AND MAINTENANCE Headlight Aiming Since special procedures are required, we recommend you take your vehicle to your SUZUKI dealer for headlight alignment. BLOWN 54G256 65D046 (1) Fuse puller WARNING The fuses are also located under the Always be sure to replace a blown driver’s side of the dashboard.

  • Page 191: Bulb Replacement: 7

    CAUTION Frequent replacement of a bulb indi- cates the need for an inspection of the electrical system. This should be carried out by your SUZUKI dealer. NOTE: 54G121 If it is difficult to replace headlight bulbs or Open the engine hood. Remove the cou- parking light bulbs due to under-hood com- ponents trust this job to your dealer.

  • Page 192: Wiper Blades: 3

    Wiper Blades: 3 INSPECTION AND MAINTENANCE Other General Lights Bulb Front parking light (1) Front turn signal light (2) Bulb holder EXAMPLE EXAMPLE 54G124 54G125 (3) Removal 54G123 (4) Installation Rear combination light (1) Removal (tail, stop, turn signal, etc.) (2) Installation There are two types of bulb, “Full glass type”...
  • Page 193 Wiper Blades: 3 INSPECTION AND MAINTENANCE Rear combination light on trunk lid Spot light (if equipped) High-mount stop light (if equipped) (reverse, license) View A View A 65D089 54G305 Trunk room light Front/Rear side marker light 54G306 54G300 60G149 9-40 54G27-03E...
  • Page 194 NOTE: Some wiper blades may be different from the ones described here depending on vehicle specifications. If so, consult your SUZUKI dealer for proper replacement method. 9-41 54G27-03E...

  • Page 195: Air Conditioning System: 4

    Wiper Blades: 3 Air Conditioning System: 4 INSPECTION AND MAINTENANCE 52D102 60A260 52D124 2) Squeeze lock lever (1) towards wiper 3) Pull the locked end of the wiper blade (3) Retainer arm (2) and remove the wiper frame firmly to unlock the blade and slide the from the arm as shown.
  • Page 196 INSPECTION AND MAINTENANCE Installation Air Conditioning System If you do not use the air conditioner for a long period, such as during winter, it may not give the best performance when you start using it again. To help maintain opti- mum performance and durability of your air conditioner, it needs to be run periodically.

  • Page 197: Emergency Service

    EMERGENCY SERVICE EMERGENCY SERVICE Jacking Instructions ............10-1 Jump Starting Instructions ..........10-4 Towing a Disabled Vehicle ..........10-5 If the Starter Does Not Operate .......... 10-6 If the Engine is Flooded ............10-6 If the Engine Overheats ............10-6 If You Can Not Shift Automatic Transaxle Gearshift Lever Out of “P”...

  • Page 198: Jacking Instructions: 5

    Jacking Instructions: 5 EMERGENCY SERVICE Jacking Instructions 75F062 54G253 1) Place the vehicle on level, hard ground. 6) Position the jack vertically and raise the 54G420 2) Set the parking brake firmly and shift jack by turning the jack handle clock- into “P”...
  • Page 199 Jacking Instructions: 5 EMERGENCY SERVICE For vehicle not equipped with lower Rear wheel WARNING body trim • Use the jack only to change wheels. Front wheel • Never jack up the vehicle on an inclined surface. • Never raise the vehicle with the jack in a location other than between the frame bosses near the wheel to be changed.
  • Page 200 Jacking Instructions: 5 EMERGENCY SERVICE For vehicle equipped with lower body Rear wheel trim View A Front wheel View A View A 54G643 54G261 (1) Lower body trim View A (1) Lower body trim (2) Flange (2) Boss 54G260 (3) Rib (1) Lower body trim WARNING (2) Boss...

  • Page 201: Jump Starting Instructions: 7

    60A269 rized SUZUKI dealer. • To avoid harm to yourself or dam- 1) Use only a 12 volt battery to jump start age to your vehicle or battery, fol- your vehicle.

  • Page 202: Towing A Disabled Vehicle: 6

    Jump Starting Instructions: 7 Towing a Disabled Vehicle: 6 EMERGENCY SERVICE 2) Turn off all vehicle accessories, except Towing a Disabled Vehicle those necessary for safety reasons (for WARNING example, headlights or hazard lights). Emergency Towing Never connect the jumper cable If your vehicle is disabled, it may be towed directly to the negative (–) terminal of by a tow truck using one of the following...

  • Page 203: If The Starter Does Not Operate

    – Both High Engine Coolant Tempera- SUZUKI dealer. ture Warning Light and Low Engine Coolant Temperature Light have gone off. – Low Engine Coolant Temperature Light is lit in blue, and High Engine Coolant Temperature Warning Light has gone off.
  • Page 204 If the Engine Overheats: 2, 9 EMERGENCY SERVICE If the temperature indication does not WARNING return to the normal condition: If you see or hear escaping steam, 1) Turn off the engine and check that the water pump belt and pulleys are not stop the vehicle in a safe place and damaged or slipping.

  • Page 205: If You Can Not Shift Automatic Transaxle Gearshift Lever Out Of "P" (Park)

    If You Can Not Shift Automatic Transaxle Gearshift Lever Out of “P” (PARK): 2, 9 EMERGENCY SERVICE If You Can Not Shift 2) If the engine is running, stop the engine. Automatic Transaxle 3) Make sure the key is in the “ON” or Gearshift Lever Out of “P”...
  • Page 206 EMERGENCY SERVICE MEMO 10-9 54G27-03E...

  • Page 207: Appearance Care

    APPEARANCE CARE APPEARANCE CARE Corrosion Prevention ............11-1 Vehicle Cleaning ..............11-3 60G412 54G27-03E...
  • Page 208 Corrosion Prevention: APPEARANCE CARE Corrosion Prevention vehicle which are not well ventilated to If you frequently drive on salted roads, your permit quick drying. vehicle should be washed at least once a It is important to take good care of your month during the winter.
  • Page 209 Corrosion Prevention: APPEARANCE CARE Keep passenger and cargo compart- reaching the surface. Your SUZUKI dealer ments clean WARNING can help you select the right cover for your Moisture, dirt or mud can accumulate vehicle. Do not apply additional undercoating under the floor mats and may cause corro- or rust preventive coating on or sion.
  • Page 210 Vehicle Cleaning: APPEARANCE CARE Vehicle Cleaning Cleaning Interior Seat belts Clean seat belts with a mild soap and Vinyl upholstery water. Do not use bleach or dye on the Prepare a solution of soap or mild deter- belts. They may weaken the fabric in the gent mixed with warm water.
  • Page 211 Vehicle Cleaning: APPEARANCE CARE Washing 2) Rinse the body to loosen the dirt. 6) Check carefully for damage to painted Remove dirt and mud from the body surfaces. If there is any damage, WARNING exterior with running water. You may “touch-up”...
  • Page 212 Vehicle Cleaning: APPEARANCE CARE Waxing 60B211S After washing the vehicle, waxing and pol- ishing are recommended to further protect and beautify the paint. • Only use waxes and polishes of good quality. • When using waxes polishes, observe the precautions specified by the manufacturers.

  • Page 213: General Information

    GENERAL INFORMATION GENERAL INFORMATION Identification Numbers ............12-1 Safety Certification Label ........... 12-2 Emission Compliance Label (for U.S.A.) ......12-2 Warranties ................12-2 On-Board Vehicle Computers and Event Data Recorders ................12-3 Reporting Safety Defects ........... 12-4 54G072 54G27-03E...

  • Page 214: Identification Numbers

    Identification Numbers: 2, 5 GENERAL INFORMATION Identification Numbers The Vehicle Identification Number (VIN) Engine Serial Number may be found in the location shown in the Vehicle Identification Number above illustrations. This number is used to register the vehicle. It is also used to assist your dealer when ordering parts or refer- EXAMPLE (for some vehicles) ring to special service information.

  • Page 215: Safety Certification Label: 6

    For U.S.A. The following warranties are provided with your vehicle: • New Vehicle Limited Warranty • Limited Warranty For SUZUKI Parts or Accessories • Emission Components Defect Warranty • Emission Performance Warranty 52D059 This label contains important safety- 60A412 related information about your vehicle.

  • Page 216: On-Board Vehicle Computers And Event Data Recorders

    SUZUKI’s defense of litiga- tion through the discovery process, or Some information may be stored by as required by law.

  • Page 217: Reporting Safety Defects

    For vehicles registered for use and NHTSA cannot become involved in principally operated in Canada please individual problems between you, your contact Suzuki Canada Inc. at 1-905- dealer, or American Suzuki Motor 889-2677 extension 2254 or write to: Corp. Suzuki Canada Inc.
  • Page 218 GENERAL INFORMATION MEMO 12-5 54G27-03E...

  • Page 219: Fuses And Protected Circuits

    Fuses and Protected Circuits: 7 FUSES AND PROTECTED CIRCUITS FUSES AND PROTECTED CIRCUITS (6) (7) (9) (10) (11) 54G220 PROTECTED CIRCUIT COLOR/SIZE (AMPS) BLACK (80) All Electric Loads YELLOW (60) Ignition Switch YELLOW (60) Circuit Fuse Box, Relay Box YELLOW (60) ABS Controller ORANGE (30) Blower Fan Main Relay...
  • Page 220 Fuses and Protected Circuits: 7 FUSES AND PROTECTED CIRCUITS 54G221 PROTECTED CIRCUIT COLOR/SIZE (AMPS) (30) BLANK – In engine FUSE compartment (31) BLUE (15) Fog Light (32) BLUE (15) Horn 13-2 54G27-03E...
  • Page 221 Fuses and Protected Circuits: 7 FUSES AND PROTECTED CIRCUITS (12) (13) (14) (15) (16) (17) (18) (19) (20) (21) (33) (34) (22) (23) (24) (25) (26) (27)(28) (29) 54G222 FUSE NAME PROTECTED CIRCUIT COLOR/SIZE (AMPS) (12) RED (10) HEATER Air Conditioning, Mirror Heater Switch (13) BLANK –...
  • Page 222 Fuses and Protected Circuits: 7 FUSES AND PROTECTED CIRCUITS (12) (13) (14) (15) (16) (17) (18) (19) (20) (21) (33) (34) (22) (23) (24) (25) (26) (27)(28) (29) 54G222 FUSE NAME PROTECTED CIRCUIT COLOR/SIZE (AMPS) Generator, Ignition Coil, O Sensor Heater, Fuel (23) BLUE (15) Injection Controller, A/T Controller...

  • Page 223: Specifications

    Specifications: 1, 2, 5, 6, 7, 10, 11 SPECIFICATIONS SPECIFICATIONS NOTE: Specifications are subject to change without notice. 4WD: 4-wheel drive 2WD: 2-wheel drive ITEM: Dimensions UNIT: mm (in.) Overall length 4350 (171.3) Overall width without side mold 1690 (66.5) with side mold 1720 (67.7) Overall height...
  • Page 224 Specifications: 1, 2, 5, 6, 7, 10, 11 SPECIFICATIONS ITEM: Engine Type J23A (16 valve DOHC) Number of cylinders Bore 90.0 mm (3.54 in.) Stroke 90.0 mm (3.54 in.) Piston displacement 2290 cm (139.7 cu.in, 2290 cc) Compression ratio 9.3 : 1 ITEM: Electrical Ignition timing 3°...
  • Page 225 Specifications: 1, 2, 5, 6, 7, 10, 11 SPECIFICATIONS ITEM: Lights WATTAGE BULB No. Headlight 12V 60/55W Turn signal light Front 12V 21W 7440 Rear 12V 21W 7440 Side marker light 12V 3.8W Parking light 12V 5W – Tail/brake light 12V 5/21W –...
  • Page 226 Specifications: 1, 2, 5, 6, 7, 10, 11 SPECIFICATIONS ITEM: Wheel Tire size, front and rear P185/65R14 or P195/55R15 Tire pressure For the specified tire pressure, see the Tire Information Label located on the driver’s door lock pillar. ITEM: Steering IN 1.0 ±...

  • Page 227: Index

    INDEX INDEX Symbols “AIR BAG” Light ..............4-5 Basic Operations ..............4-29 “CRUISE” Indicator Light ...........4-6 Battery .................. 9-35 “O/D OFF” Indicator Light ..........4-6 Brake Fluid ................9-22 “PANIC” button function ............2-3 Brake Pedal ..............5-2 9-23 “PASS AIRBAG OFF” Indicator ..........4-14 Brake System Warning Light ..........
  • Page 228 INDEX Daytime Running Light (D.R.L.) Indicator Light ....4-7 Fuses in the Engine Compartment ........9-36 Daytime Running Light (D.R.L.) System ......3-3 Fuses under the Dash Board ..........9-36 Door Locks ................2-1 Driver’s Seat Belt Reminder Light ........4-4 Gasoline Containing MTBE ..........1-1 Driving on Hills ..............7-1 Gasoline/Ethanol blends ............
  • Page 229 INDEX Ignition Switch ..............3-1 Malfunction Indicator Light ..........4-5 Improving Fuel Economy ............6-10 Manual Heating and Air Conditioning System ....4-19 Information Display .............4-12 Manual Transaxle ..............6-6 Inside Rearview Mirror ............2-10 Mirrors .................. 2-10 Installation with Lap-Shoulder Seat Belts (child restraint with no top strap) ........2-24 National Highway Traffic Safety Administration Installation with the LATCH System ........2-26...
  • Page 230 INDEX Rear Window Defroster Switch ..........4-10 Sun Visor ................5-6 Rear Window Wiper/Washer Switch ........3-5 Supplemental Restraint System (air bags) ....... 2-32 Refill with Oil and Check for Leaks ........9-13 Refilling ................9-12 Tachometer ................4-9 Remote Audio Controls ..........3-8 4-43 Temperature Gauge ............
  • Page 231 INDEX Vehicle Loading ............8-1 9-32 Warning and Indicator Lights ..........4-3 Warranties ................12-2 Washing ................11-4 Waxing ..................11-5 Windows ................2-8 Windshield Washer .............3-5 Windshield Washer Fluid ............9-19 Windshield Wiper and Washer Lever ........3-4 Windshield Wipers ..............3-4 Wiper Blades ................9-41 15-5 54G27-03E...
  • Page 232 INDEX MEMO 15-6 54G27-03E...

This manual is also suitable for:

Aerio 20072007 aerio

Table of Contents