PIONEER CORPORATION 4-1, Meguro 1-chome, Meguro-ku, Tokyo 153-8654, Japan PIONEER ELECTRONICS (USA) INC. P.O. Box 1760, Long Beach, CA 90801-1760, U.S.A. PIONEER EUROPE NV Haven 1087, Keetberglaan 1, 9120 Melsele, Belgium PIONEER ELECTRONICS ASIACENTRE PTE. LTD. 253 Alexandra Road, #04-01, Singapore 159936 PIONEER CORPORATION 2002 T –...
Page 2
S-W110S-QL, S-W110S-K, S-W150S [ Important symbols for good services ] In this manual, the symbols shown-below indicate that adjustments, settings or cleaning should be made securely. When you find the procedures bearing any of the symbols, be sure to fulfill them: 1.
, a l w a y s c o n s u l t t h e c u r r e n t P I O N E E R Service Manual. A subscription to, or additional copies Also test with plug reversed of, PIONEER Service Manual may be obtained at a (Using AC adapter Earth nominal charge from PIONEER.
S-W110S-QL, S-W110S-K, S-W150S 2. EXPLODED VIEWS AND PARTS LIST NOTES: Parts marked by "NSP" are generally unavailable because they are not in our Master Spare Parts List. mark found on some component parts indicates the importance of the safety factor of the part.
Page 5
Polyethylene bag(4x11) 150-04011-210 Speaker Cord 043-20302-012 RCA Plug Cord 043-26302-511 Polyethylene bag(10x14) 150-10014-010 (2) CONTRAST TABLE S-W110S-QL, S-W110S-K and S-W150S are constructed the same except for the following: Part No. Mark Symbol and Description Remarks S-W110S-QL S-W110S-K S-W150S Carton Box...
Page 7
133-51103-430 POWER MTG. POST 133-51106-100 SCREW(3x14) 144-13014-400 SCREW(3x8) 144-53008-201 SCREW(3x16) 144-53016-202 (2) CONTRAST TABLE S-W110S-QL, S-W110S-K and S-W150S are constructed the same except for the following: Part No. Mark Symbol and Description Remarks S-W110S-QL S-W110S-K S-W150S Grille Cloth 166-00000-064 166-00000-061 166-00000-061 SPK.
S-W110S-QL, S-W110S-K, S-W150S 3. SCHEMATIC DIAGRAM 3.1 INPUT, FILTER, LED, POWER, POWER SW and AC BOARD ASSYS INPUT BOARD FILTER BOARD ASSY ASSY POWER SWITCH BOARD ASSY AC BOARD ASSY • NOTE FOR FUSE REPLACEMENT FOR CONTINUED PROTECTION AGAINST RISK OF FIRE.
Page 9
S-W110S-QL, S-W110S-K, S-W150S : AUDIO SIGNAL ROUTE LED BOARD ASSY POWER BOARD ASSY...
S-W110S-QL, S-W110S-K, S-W150S 4. PCB CONNECTION DIAGRAM 4.1 INPUT ASSY NOTE FOR PCB DIAGRAMS: 1. Part numbers in PCB diagrams match those in the schematic SIDE A diagrams. 2. A comparison between the main parts of PCB and schematic diagrams is shown below.
Page 11
S-W110S-QL, S-W110S-K, S-W150S 4.2 FILTER and LED ASSYS SIDE A LED BOARD ASSY FILTER BOARD ASSY CN503 CN101...
Page 12
S-W110S-QL, S-W110S-K, S-W150S 4.3 POWER ASSY SIDE A POWER BOARD ASSY CN103 WOOFER Q503 Q502 Q501 IC501...
Page 13
S-W110S-QL, S-W110S-K, S-W150S 4.4 POWER SW and AC ASSYS SIDE A POWER SW BOARD ASSY AC BOARD ASSY(S-W110S) AC BOARD ASSY(S-W150S)
LED BOARD ASSY POWER SW BOARD ASSY POWER BOARD ASSY AC BOARD ASSY CONTRAST OF PCB ASSEMBLIES FILTER BOARD ASSY S-W110S-QL, S-W110S-K and S-W150S are constructed the same except for the following : Part No. Mark Symbol and Description S-W110S-QL Remarks...
Page 15
S-W110S-QL, S-W110S-K, S-W150S PCB PARTS LIST FOR S-W110S-QL Mark No. Description Part No. Mark No. Description Part No. CN102, CN104 2P V-TYPE 025-20002-204 INPUT BOARD ASSY CN103 6P V-TYPE 025-20006-204 SWITCHES AND RELAYS SHIELD PLATE(A) 135-51100-105 SW101 2P RCA JACK V-PCB-TYPE...
S-W110S-QL, S-W110S-K, S-W150S Mark No. Description Part No. 6. ADJUSTMENT CN502 3P V-TYPE 025-20003-212 CN503 6P V-TYPE 025-20006-204 There is no information to be shown in this chapter. RL501 065-00112-003 032-10800-040 JUMPER WIRE(80mm) SOLDERING LUG 039-30012-000 POWER SW BOARD ASSY...
S-W110S-QL, S-W110S-K, S-W150S 7. GENERAL INFORMATION 7.1 DISASSEMBLY ¶ Turn the unit upside down. Bottom side SUB WOOFER, FILTER BOARD ASSY, LED BOARD ASSY, POWER SW BOARD ASSY ÷ The grille is inserted into the baffle. Detach by publling it toward you.
Page 18
S-W110S-QL, S-W110S-K, S-W150S INPUT BOARD ASSY, POWER BOARD ASSY, AC BOARD ASSY, ÷ Unfasting 12 screws, remove the rear panel. Bottom side Bottom side Screw × 12 POWER BOARD ASSY Bind Tie × 5 AC BOARD ASSY INPUT BOARD ASSY...
S-W110S-QL, S-W110S-K, S-W150S 8. PANEL FACILITIES AND SPECIFICATIONS PANEL FACILITIES LEVEL TURNOVER PHASE POWER ˚ ˚ FRONT PANEL ( Power Indicator Illuminates when the power is on. Power switch (POWER) When pressed, power is turned ON; when pressed again, power is turned OFF.
LINE LEVEL (RCA jack) ........200 mV/50 kΩ Turnover Frequency ..50 – 200 Hz (continuously variable) Outline Dimension S-W110S-QL/S-W110S-K..250 (W) x 480 (H) x 475 (D) mm S-W150S......280 (W) x 480 (H) x 495 (D) mm Weight (without package) S-W110S-QL/S-W110S-K..........