Page 1
RX-7520VBK SERVICE MANUAL AUDIO/VIDEO CONTROL RECEIVER RX-7520VBK Area suffix C ------------------- Canada RX-7520V AUDIO/VIDEO CONTROL RECEIVER FM/AM TUNING FM/AM PRESET FM MODE COMPULINK Remote STANDBY MASTER VOLUME MEMORY STANDBY/ON INPUT SURROUND ON/OFF ANALOG/DIGITAL BASS BOOST ADJUST SETTING FM MODE DVD MULTI...
Page 2
RX-7520VBK 1. This design of this product contains special hardware and many circuits and components specially for safety purposes. For continued protection, no changes should be made to the original design unless authorized in writing by the manufacturer. Replacement parts must be identical to those used in the original circuits. Services should be performed by qualified personnel only.
Page 3
RX-7520VBK Importance administering point on the safety LVA1029-C9 B110 PW104 TA201 B109 B108 B106 Primary part PW105 PW102 TA202 B105 B107 B104 FC211 PW103 6.3A-125V B103 F 201 B102 PW101 B101 FC212 B192 B191 FC232 FC222 B159 Secondary parts F 203...
Page 4
RX-7520VBK Disassembly method Top cover Removing the top cover (See Fig.1) Remove the four screws A attaching the top cover on both sides of the body. Remove the three screws B on the back of the body. Remove the top cover from behind in the direction of Fig.1...
Page 5
RX-7520VBK Removing each board connected to the rear side of the audio board CN411 (See Fig.5 to 9) Prior to performing the following procedure, remove the top cover and the rear panel. Audio Cut off the tie band fixing the harness.
Page 6
RX-7520VBK Removing the audio board (See Fig.10) Relay board Prior to performing the following procedure, remove the top cover and the rear panel. power supply supply Disconnect the card wire from connector CN402 on board board the audio board. CN473...
Page 7
RX-7520VBK Removing the power transformer (See Fig.15) Prior to performing the following procedures, remove the top cover. Power Cut off the tie band fixing the harness. supply board board Unsolder the two harnesses connected to the power FW201 transformer. Solder...
Page 8
RX-7520VBK Removing the system control board / Operation switch panel Front panel assembly power switch board (See Fig.18 to 20) Prior to performing the following procedure, remove the top cover and the front panel assembly. Pull out the volume knob on the front side of the front panel and remove the nut attaching the system control board.
Page 9
RX-7520VBK Adjustment method Tuner section 1. Tuner range 87.5MHz~108.0MHz AM (MW) 530kHz~1710kHz Power amplifier section Adjustment of idling current Measurement location TP301 (Lch) , TP302 (Rch) Adjustment part VR301 (Lch) , VR302 (Rch) Attention This adjustment does not obtain a correct adjustment value immediately after the amplifier is used (state that an internal temperature has risen).
Page 10
RX-7520VBK Description of major ICs AK4527BVQP (IC601) : A/D,D/A converter 1.Pin layout Top View 2. Pin function (1/2) Symbol Function SDOS SDTO Source Select Pin (Note 1) "L" : Internal ADC output, "H" : DAUX input OSKS Control Mode Select Pin "L"...
Page 11
RX-7520VBK Pin function (2/2) AK4527 Symbol Function Connect to GND ICKS No internal bonding. Analog Input Format Select Pin, Digital Power Supply ADIF "H" : Full-differential input, "L" : Single-ended input Chip Address 1 Pin, Connect to GND CAD1 Chip Address 0 Pin, Connect to GND...
Page 13
RX-7520VBK 2.Pin Function M62446FP Pin No. Symbol Function OUT4 BASS BOOST control terminal OUT3 SURROUND control terminal VIDEO 2 control terminal OUT2 OUT1 VIDEO 1 control terminal Analog positive power supply terminal AVDD SW IN SUB Woofer volume signal input terminal A.GND...
Page 14
RX-7520VBK MN101C35DJW (IC701) : System controller 1. Pin layout 2. Pin function (1/2) Symbol Function Pin No. VOL.JOG IN_1 VOL.JOG IN_1 VOL.JOG IN_2 VOL.JOG IN_2 DATA (PLL) DATA (PLL) (PLL) (PLL) (PLL) (PLL) VIDEO S/C DVD VIDEO S/C DVD VIDEO S/C VCR...
Page 15
RX-7520VBK Pin function (2/2) MN101C35DJW Symbol Function Pin No. (DSP) CLK DSP READY READY (DSP) RESET RESET (DSP) RY S RELAY SURRUND RY C RELAY CENTER RELAY FRONT 1 RY L/R1 RY L/R2 RELAY FRONT 2 RY HP RELAY HEADPHONE...
Page 16
RX-7520VBK UPD784215AGC167 (IC671) : Dital signal controller 1.Pin layout 2.Pin function (1/2) Pin No. Symbol Function Non connect Power supply terminal Connecting the crystal oscillator for system main clock Connecting the crystal oscillator for system main clock Connect to GND...
Page 17
RX-7520VBK Pin function (2/2) UPD784215AGC167 Pin No. Symbol Function Interface I/O terminal with microcomputer MILP Interface I/O terminal with microcomputer MIACK Non connect Non connect Reset signal output of DSP DSPRST Non connect 54~63 Interface I/O terminal with microcomputer CODEC OUT...
Page 18
RX-7520VBK LA1838 (IC102) : FM AM IF amp. & Detector, FM MPX decoder 1. Block Diagram DECODER RF.AMP ANIT-BIRDIE MUTE BUFF STEREO P-DET AM IF PILOT 384KHz COMP S-METER AM/FM S-CLRVE S-METER IF-BUFF TUNING STEREO DRIVE DRIVE FM IF 2. Pin Function...
Page 23
RX-7520VBK TC7SET32FU (IC672) : Z-Input or gate IMX9-W (IC652, IC662, IC682) : Driver 1. Pin layout / Block diagram 1. Pin layout / Block diagram IN B IN A OUT Y TC74HCU08AF (IC611) : Inverter 1. Pin layout / Block diagram 2.The truth value table...
Page 24
RX-7520VBK W24L010AJ-12 (IC641) : SRAM 1. Pin layout 2. Block diaglam DECODER CORE ARRAY I/O1 CONTROL DATA I/O I/O8 3. Pin function Pin No. Symbol Function Pin No. Symbol Function No Connection I/O4 Data Input/Output Address Input I/O5 Data Input/Output...
Page 26
RX-7520VBK VICTOR COMPANY OF JAPAN, LIMITED AUDIO & COMMUNICATION BUSINESS DIVISION PERSONAL & MOBILE NETWORK BUSINESS UNIT. 10-1,1chome,Ohwatari-machi,Maebashi-city,371-8543,Japan (No.21097) 200204...
RX-7520VBK Block diagram MONITOR MONITOR DVD FRONT IC451 SELECTOR SELECTOR DVD IN MONITOR TUNER SELECTOR CENTER IC551 RF101 IC121 IC581 VCR REC IC501 IC552 IC582 DVD REAR/ VCR PLAY VCR REC SUB WOOFER AM/FM DET MW RF&OSC VCR P.B. SUB WOOFER...
Page 28
RX-7520VBK RX-7520VBK Standard schematic diagrams Power supply section Component video terminal section Power transformer board To sheet 5/8 G-3 FW501 D1501 PW311 11ES2-T4 PW101 J1501 QNN0391-001 CN251 QGA3901F2-03 C1530 1.5ML C1518 C1520 C1522 To sheet 6/8 G-2 F202 R1508 R1510...
RX-7520VBK PARTS LIST [ RX-7520VBK ] * All printed circuit boards and its assemblies are not available as service parts. Area suffix C -------------------------- Canada - Contents - 3- 3 Exploded view of general assembly and parts list (Block No.M1) 3- 5 Electrical parts list (Block No.01~05)
Page 43
RX-7520VBK Exploded view of general assembly and parts list Block No. Power trans board Speaker Power trans board board Component video board Power/Fuse board Relay board Main board Audio board power switch board Power supply board System control board...
Page 44
RX-7520VBK RX-7520VBK Parts list (General assembly) Parts list (General assembly) Block No. M1MM Block No. M1MM Item Parts number Parts name Q'ty Description Area Item Parts number Parts name Q'ty Description Area LV10457-018A FRONT PANEL QYSBSGY3008M SPECIAL SCREW 4 INPUT...
Page 45
RX-7520VBK Electrical parts list (Power amp board) Block No. 01 Item Remarks Parts number Parts name Area Item Parts number Parts name Remarks Area C 201 QFLC2AJ-104Z M CAPACITOR .10MF 5% 100V C 813 QFLC1HJ-103Z M CAPACITOR .010MF 5% 50V...
Page 46
RX-7520VBK Electrical parts list (Power amp board) Block No. 01 Item Parts number Parts name Remarks Area Item Remarks Parts number Parts name Area D 221 1SS133-T2 228ZIODE IM Q 311 KTC3200/GL/-T TRANSISTOR D 301 1SS133-T2 228ZIODE IM Q 312...
Page 47
RX-7520VBK Electrical parts list (Power amp board) Block No. 01 Item Parts number Parts name Remarks Area Item Parts number Parts name Remarks Area R 314 QRE141J-563Y C RESISTOR 56K 5% 1/4W R 804 QRE141J-563Y C RESISTOR 56K 5% 1/4W...
Page 48
RX-7520VBK Block No. 01 Electrical parts list (Power amp board) Item Parts number Parts name Remarks Area R 913 QRE141J-563Y C RESISTOR 56K 5% 1/4W R 915 QRJ146J-331X UNF C RESISTOR 330 5% 1/4W R 921 QRJ146J-100X UNF C RESISTOR...
Page 49
RX-7520VBK Electrical parts list (Main board) Block No. 02 Item Parts number Parts name Remarks Area Item Parts number Parts name Remarks Area C 400 QCBB1HK-223Y C CAPACITOR .022MF 10% 50V CN401 QGB2510K1-14 CONNECTOR C 419 QCBB1HK-223Y C CAPACITOR .022MF 10% 50V...
Page 50
RX-7520VBK Electrical parts list (Main board) Block No. 02 Item Remarks Parts number Parts name Area Item Parts number Parts name Remarks Area Q1304 KTC3199/GL/-T TRANSISTOR RY302 QSK0109-001 RELAY Q1305 2SD2395/EF/ TRANSISTOR RY303 QSK0109-001 RELAY Q1306 KTA1023/OY/-T TRANSISTOR RY304 QSK0109-001...
Page 51
RX-7520VBK Electrical parts list (System control & Audio board) Block No. 03 Item Remarks Parts number Parts name Area Item Parts number Parts name Remarks Area BK701 LV42093-001A FL HOLDER(L) C1429 QCB31HK-822Z C CAPACITOR 8200PF 10% 50V BK702 LV42092-001A FL HOLDER(R)
Page 52
RX-7520VBK Electrical parts list (System control & Audio board) Block No. 03 Item Remarks Parts number Parts name Area Item Parts number Parts name Remarks Area D1409 1SS355-X DIODE C.M Q1432 KRC104M-T D.TR.I.M D1410 1SS355-X DIODE C.M Q1433 KRC104M-T D.TR.I.M...
Page 53
RX-7520VBK Electrical parts list (System control & Audio board) Block No. 03 Item Parts number Parts name Remarks Area Item Remarks Parts number Parts name Area R 738 NRSA63J-102X MG RESISTOR R1420 NRSA63J-103X MG RESISTOR R 739 NRSA63J-122X MG RESISTOR...
Page 54
RX-7520VBK Electrical parts list (System control & Audio board) Block No. 03 Item Parts number Parts name Remarks Area R1502 NRSA63J-750X MG RESISTOR R1503 NRSA63J-750X MG RESISTOR R1504 NRSA63J-750X MG RESISTOR R1505 NRSA63J-750X MG RESISTOR R1506 NRSA63J-750X MG RESISTOR R1507...
Page 55
RX-7520VBK Electrical parts list (DSP board) Block No. 04 Item Parts number Parts name Remarks Area Item Parts number Parts name Remarks Area C 601 NCB31HK-102X C CAPACITOR C2512 NCF31CZ-104X C CAPACITOR C 602 NCB31HK-102X C CAPACITOR C2513 NCB31HK-122X C CAPACITOR...
Page 56
RX-7520VBK Electrical parts list (DSP board) Block No. 04 Item Remarks Parts number Parts name Area Item Parts number Parts name Remarks Area IC662 IMX9-W R 678 NRSA63J-822X MG RESISTOR IC671 UPD784215AGC167 IC(MICRO C ROM) R 679 NRSA63J-822X MG RESISTOR...
Page 57
RX-7520VBK Electrical parts list (DSP board) Block No. 04 Item Remarks Parts number Parts name Area R2566 NRSA63J-202X MG RESISTOR R2567 NRSA63J-103X MG RESISTOR R2568 NRSA63J-103X MG RESISTOR R2569 NRSA63J-122X MG RESISTOR R2570 NRSA63J-122X MG RESISTOR R2575 NRSA63J-102X MG RESISTOR...
Page 58
RX-7520VBK Electrical parts list (Tuner board) Block No. 05 Item Remarks Parts number Parts name Area Item Parts number Parts name Remarks Area AT101 QNB0014-001 ANT TERMINAL R 115 NRSA02J-104X MG RESISTOR BK 1 LV31618-001A SHIELD BKT R 119 NRSA02J-103X...
Page 60
RX-7520VBK Packing materials and accessories parts list Block No. Block No. A2~A8 3-20...
Page 61
POLY BAG Parts list (Accessories) Block No. M5MM Item Parts number Parts name Q'ty Description Area RM-SRX7520J REMOCON ------------- BATTERY LVT0852-002A INST.BOOK 1 ENG,FRE EWP503-001C ANT.WIRE QAL0204-001 AM LOOP ANT YU20333 SAFETY INST. BT-52006-1 WARRANTY CARD BT-20071B JVC CENTER LIST 3-21...