Sealey SA90.V2 Instructions

Thank you for purchasing a Sealey product. Manufactured to a high standard, this product will, if used according to these
instructions and maintained properly, give you years of trouble free performance.
IMPORTANT: PLEASE READ THESE INSTRUCTIONS CAREFULLY. NOTE THE SAFE OPERATIONAL REQUIREMENTS, WARNINGS & CAUTIONS. USE THE PRODUCT
CORRECTLY AND WITH CARE FOR THE PURPOSE FOR WHICH IT IS INTENDED. FAILURE TO DO SO MAY CAUSE DAMAGE AND/OR PERSONAL INJURY AND WILL
INVALIDATE THE WARRANTY. KEEP THESE INSTRUCTIONS SAFE FOR FUTURE USE.
Refer to Instruction Wear Eye
Manual Protection
1. SAFETY
 Familiarise yourself with this products application and limitations, as well as the specific potential hazards peculiar to the air hose reel.
 WARNING! Disconnect the air hose reel from the air supply before changing accessories, servicing or performing any maintenance.
 Maintain air hose reel in good condition (use an authorised service agent). WARNING! only a qualified technician should open the unit,
as a high tension spring is enclosed which if allowed to unwind in an uncontrolled manner may cause serious personal injury.
 Replace or repair damaged parts. Use genuine parts only. Unauthorised parts may be dangerous and will invalidate the warranty.
 Locate and fix the air hose reel in an adequate working area for its function. DO NOT fix the hose in direct sun light, or in areas of extreme hot
or cold. Ensure there is adequate lighting in order to see the hose operation clearly.
 WARNING! ensure correct air pressure is maintained and not exceeded.
 Keep extended air hose away from heat, oil and sharp edges. Check hose for wear before each use, and ensure all connections are secure.
 Keep the unwound air hose at a safe distance from the working area, and free from wet, damp, oily surfaces. Protect from sharp edges
and instruments, sources of heat and dangerous substances.
 WARNING! Always wear approved eye or face protection when operating the air hose reel.
 Maintain correct balance and footing. Ensure the floor is not slippery and wear non slip shoes.
 Remove ill fitting clothing. Remove ties, watches, rings, and other loose jewellery, and contain and/ or tie back long hair.
 Keep children and unauthorised persons away from the working area.
 DO NOT operate the air hose reel if any parts are damaged or missing as this may cause failure or possible personal injury.
 DO NOT use the air hose reel for any purpose other than for which it is designed.
 DO NOT pull the hose from the air supply abruptly.
 DO NOT operate the air hose reel when you are tired, under the influence of alcohol, drugs or intoxicating medication.
 DO NOT direct air from the air hose at yourself or others.
 When not in use ensure the air supply is turned off and tools disconnected. Disconnect from the air supply and retract the hose into case.
 WARNING! DO NOT open the unit. The hose must only be replaced by a qualified technician. Contact your local authorised service agent.
2. INTRODUCTION
Robust metal case for heavy-duty applications. TPU (Thermoplastic Polyurethane) Hose can be extended and retracted by simple pull and release
mechanism. Supplied with swivel mounting bracket for fixing to wall or ceiling.
3. SPECIFICATION
Model No: . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . SA90.V2
Hose Length: . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .12mtr
Hose Size (ID/OD): . . . . . . . . . . . . . . . . . . . . . . . . . . . . Ø8/12mm
Maximum Pressure: . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 280psi
Hose Type: . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .TPU
Inlet-Outlet:. . . . . . . . . . . . . . . . . . . . . . . . . . . . . Ø8mm - 1/4"BSP
© Jack Sealey Limited
INSTRUCTIONS FOR:
RETRACTING AIR HOSE REEL
SA90.V2
MODEL:
Original Language Version
SA90.V2 Issue: 2 (L) - 23/02/17