Page 1
Koninklijke Philips Electronics N.V. or their respective owners. TP Vision Netherlands B.V. reserves the right to change products at any time without being obliged to adjust earlier supplies accordingly. PHILIPS and the PHILIPS’ Shield Emblem are used under license from Koninklijke Philips Electronics N.V.
Page 2
Revision List EN 2 QV14.1E LA 1. Revision List Manual xxxx xxx xxxx.0 Manual xxxx xxx xxxx.2 • First release. Added CTN’s of 79xx series: • Chapter 2: Table 2-1 updated. • Chapter 4: added cable dressing. Manual xxxx xxx xxxx.1 •...
Page 4
Technical Specs, Diversity, and Connections EN 4 QV14.1E LA Connections Side Connectors Rear Connectors SERVICE AUDIO IN NETWORK SCART Bottom Rear Connectors AUDIO OUT ANTENNA SAT 1 SAT 2 HDMI HDMI OPTICAL 19570_007_140513.eps 14-05-13 Figure 2-1 Connection overview Note: The following connector colour abbreviations are used - Data (+) (acc.
Page 5
Technical Specs, Diversity, and Connections QV14.1E LA EN 5 - D0- Data channel Rd - Video Pr 0.7 V / 75 ohm 10 - CLK+ Data channel 11 - Shield 17 - Service 12 - CLK- Data channel - Ground...
Page 6
3.3.3 Spare Parts external damage. • Check the strain relief of the Mains/AC Power cord for For the latest spare part overview, consult your Philips Spare proper function. Part web portal. • Check the electrical DC resistance between the Mains/AC...
Page 7
Precautions, Notes, and Abbreviation List QV14.1E LA EN 7 The third digit in the serial number (example: Abbreviation List AG2B0335000001) indicates the number of the alternative B.O.M. (Bill Of Materials) that has been used for producing the 0/6/12 SCART switch control signal on A/V specific TV set.
Page 8
Precautions, Notes, and Abbreviation List EN 8 QV14.1E LA Directions For Use: owner's manual SDI), is a digitized video format used Digital Media Reader: card reader for broadcast grade video. DMSD Digital Multi Standard Decoding Uncompressed digital component or Digital Natural Motion digital composite signals can be used.
Page 9
SOPS Self Oscillating Power Supply Serial Peripheral Interface bus; a 4-wire synchronous serial data link standard S/PDIF Sony Philips Digital InterFace SRAM Static RAM Service Reference Protocol Small Signal Board Spread Spectrum Clocking, used to reduce the effects of EMI...
Page 10
Mechanical Instructions EN 10 QV14.1E LA 4. Mechanical Instructions Index of this chapter: Notes: 4.1 Cable Dressing • Figures below can deviate slightly from the actual situation, 4.2 Service Positions due to the different set executions. 4.3 Assy/Panel Removal •...
Page 11
Mechanical Instructions QV14.1E LA EN 11 19570_177_140728.eps 14-07-28 Figure 4-3 Cable dressing detail 48” and 55" 8109/8159/8209 series (55" shown) back to 2014-Oct-22 div. table...
Page 12
Mechanical Instructions EN 12 QV14.1E LA 19572_001_140907.eps 14-09-07 Figure 4-4 Cable dressing 49" 7909 series 19572_002_140907.eps 14-09-07 Figure 4-5 Cable dressing back cover 49" 7909 series back to 2014-Oct-22 div. table...
Page 13
Mechanical Instructions QV14.1E LA EN 13 19572_003_140907.eps 14-09-07 Figure 4-6 Cable dressing 55" 7909 series 19572_004_140907.eps 14-09-07 Figure 4-7 Cable dressing back cover 55" 7909 series back to 2014-Oct-22 div. table...
Page 14
Mechanical Instructions EN 14 QV14.1E LA 19570_010_140514.eps 14-05-15 Figure 4-8 Cable dressing 55" 8109/8159/8209 series 19570_011_140514.eps 14-07-10 Figure 4-9 Cable dressing back cover 55" 8109/8159/8209 series back to 2014-Oct-22 div. table...
Page 15
Mechanical Instructions QV14.1E LA EN 15 19570_012_140514.eps 14-07-10 Figure 4-10 Cable dressing 55" 8809 series 19570_013_140514.eps 14-07-11 Figure 4-11 Cable dressing back cover 55" 8809 series back to 2014-Oct-22 div. table...
Page 16
Mechanical Instructions EN 16 QV14.1E LA 19573_003_141015.eps 14-10-16 Figure 4-12 Cable dressing 55" 8909 curved series 19573_004_141015.eps 14-10-16 Figure 4-13 Cable dressing back cover 55" 8909 curved series back to 2014-Oct-22 div. table...
Page 17
Mechanical Instructions QV14.1E LA EN 17 19573_001_141008.eps 14-10-08 Figure 4-14 Cable dressing 55" 9109 series 19573_002_141015.eps 14-10-16 Figure 4-15 Cable dressing back cover 55" 9109 series back to 2014-Oct-22 div. table...
Page 18
Mechanical Instructions EN 18 QV14.1E LA 19570_190_140804.eps 14-08-05 Figure 4-16 Cable dressing 65" 9109 series 19570_191-140804.eps 14-08-07 Figure 4-17 Cable dressing back cover 65" 9109 series back to 2014-Oct-22 div. table...
Page 19
Mechanical Instructions QV14.1E LA EN 19 19570_192_140804.eps 14-08-07 Figure 4-18 Cable dressing 65" 9809 series 19570_193_140804.eps 14-08-07 Figure 4-19 Cable dressing back cover 65" 9809 series back to 2014-Oct-22 div. table...
Page 20
Mechanical Instructions EN 20 QV14.1E LA Service Positions care that these always support the cabinet and never only the display. For easy servicing of a TV-set, the set should be put face down Caution: Failure to follow these guidelines can seriously...
Page 21
Service Modes, Error Codes, and Fault Finding QV14.1E LA EN 21 5. Service Modes, Error Codes, and Fault Finding Index of this chapter: Every time the TV-set is switched “on/off” 0,5 hours is 5.1 Test Points added to this number.
Page 22
Service Modes, Error Codes, and Fault Finding EN 22 QV14.1E LA • Test settings. For development purposes only. When CSM is activated and there is an USB stick connected to • RF4CE pairing tables. Clear paired remote control. the TV-set, the software will dump the CSM content to the USB For re-pairing (coldboot of platform possibly needed) press stick.
Page 23
Service Modes, Error Codes, and Fault Finding QV14.1E LA EN 23 consumer upgradeable, it will also be published on the Internet. Example: AND1E-1.2.3.4 • 2.2 Standby software. Displays the build-in standby processor software version. Upgrading this software, embedded with the main software update.5.9 Software...
Page 24
Service Modes, Error Codes, and Fault Finding EN 24 QV14.1E LA Start-up The flowcharts on the following pages show the process from start-up. For each phase they show which supplies are active. 5.3.1 Transition Overview Mains Mains WakeUp - WakeUp requested...
Page 25
Service Modes, Error Codes, and Fault Finding QV14.1E LA EN 25 5.3.2 “Off” to “Semi Standby” (part 1) Stand by or AC~ Mains is applied Protection Standby Supply starts running. All standby supply voltages become available. st-by µP resets, resulting in a high impedant output stage of the I/O ports.
Page 26
Service Modes, Error Codes, and Fault Finding EN 26 QV14.1E LA 5.3.3 “Off” to “Semi Standby” (part 2) Wake up reason coldboot to Active mode? AUDIO-MUTEn is switched by MIPS code Startup screen cfg file later on in the startup process when audio...
Page 27
Service Modes, Error Codes, and Fault Finding QV14.1E LA EN 27 5.3.4 “Semi Standby” to “Active” Semi Standby The assumption here is that a fast toggle (<2s) can Wait until previous on-state is left more than 2 only happen during ON->SEMI ->ON.
Page 28
Service Modes, Error Codes, and Fault Finding EN 28 QV14.1E LA 5.3.5 “Active” to “Semi Standby” Active Mute all sound outputs according information in the FMS AUDIO Wait 100ms Switch off POK line detection algorithm (see CHS service) Switch Off LCD backlight...
Page 29
Service Modes, Error Codes, and Fault Finding QV14.1E LA EN 29 5.3.6 “Semi Standby” to “Standby” Semi Stand by If ambientlight functionality was used in semi-standby (lampadaire mode), switch off ambient light (see CHS ambilight) *) If this is not performed and the set is...
Page 30
Service Modes, Error Codes, and Fault Finding EN 30 QV14.1E LA Service Tools 5.5.2 How to Read the Error Buffer 5.4.1 ComPair Use one of the following methods: • On screen via the SAM (only when a picture is visible).
Page 31
Service Modes, Error Codes, and Fault Finding QV14.1E LA EN 31 Table 5-1 Error code overview Monitored Error/ Error Buffer/ Description Layer 1 Layer 2 Prot Blinking LED Device Defective Board FE-bus BL / EB Cypress bus BL / EB...
Page 32
Service Modes, Error Codes, and Fault Finding EN 32 QV14.1E LA • Related to supplies: presence of the +5V,+2V5, +1V5, - Select the correct database (open file “QFUX.X”, this will set +1V2 and +1V0 needs to be measured, no protection the ComPair interface in the appropriate mode).
Page 33
TV, the main software and the default software upgrade application can be upgraded with the “AUTORUN.UPG” from the “Philips” P4C/S website. This can also be done by the consumers themselves, but they will have to get their software from the commercial Philips website or via the Software Update Assistant in the user menu (see eUM).
Page 34
Alignments EN 34 QV14.1E LA 6. Alignments Index of this chapter: • LATAM models: an NTSC M TV-signal with a signal 6.1 General Alignment Conditions strength of at least 1 mV and a frequency of 61.25 MHz 6.2 Hardware Alignments (channel 3).
Page 35
Alignments QV14.1E LA EN 35 Table 6-2 White tone default settings 48PFS81x9 you can set all options very quickly. All options are controlled via eight option numbers. When the NVM is replaced, all options will require resetting. To White Tone...
Page 36
Alignments EN 36 QV14.1E LA Total Overview SAM modes Table 6-6 SAM mode overview Main Menu Sub-menu 1 Sub-menu 2 Sub-menu 3 Description Hardware Info A. SW version e.g. “AND1E_0.7.31.0E Display TV & Standby SW version and CTN serial number B.
Page 37
19570_182_140728.eps Introduction 14-07-28 The QV14.1E LA is a new platform launched in Europe in 2014. Figure 7-2 UHD100 This chassis contains the Marvell BQ-2. The major deltas versus its predecessor are DVB-TC; DVB-TC/T2, DVB-TC/S2 with also multimedia, 3D, AmbiLight, WiFi, Smart TV and Light Sensor functionality.
Page 41
Circuit Descriptions QV14.1E LA EN 41 7.2.3 Marvell Copper Layouts Refer to Chapter 9 for detailed Architecture and Connections: • 9.16 Architecture - FHD, 9.17 Connections - FHD, • 9.18 Architecture - UHD, 9.19 Connections - UHD Rogue, The following Figures show the layout of the different SSB’s •...
Page 42
Circuit Descriptions EN 42 QV14.1E LA COMMON INTERFACE POWER BACK-END HDMI to TTL ADV7619 CIMax 4k FPGA eMMC flash MV BG2-Q SOC1 HDMI 6:2 mux PQ FPGA MV Cypress Anaconda SERVICE Audio Class-D HDMI Rogue FRONT-END HDMI 2.0 TAS5760 Channel decoders HDMI 2.0...
Page 43
Circuit Descriptions QV14.1E LA EN 43 FRC Master N314 FRC Slave N314 19570_167_140721.eps 14-07-22 Figure 7-9 Bolt-on copper 6 layout back to 2014-Oct-22 div. table...
Page 44
QV14.1E LA Power Supply fuse with one with the correct specifications! This part is available in the regular market. Consult the Philips Service web portal for the order codes of the 7.3.1 Power Supply Unit boards. All power supplies are a black box for Service. When any of 7.3.2...
Page 46
Circuit Descriptions EN 46 QV14.1E LA +12V +3V3 +3V3 U010U DC/DC ENABLE+1V2-FPGA TPS5442 7DDA +1V2 +3V3 +3V3 +1V5-BE U021B DDR FPGA FPGA LX25 FPGA LX75 +2V5-BE 1&2 RT9187G (HDMI2,0) Boa (PQ, NR, LC) Anaconda+ +3V3 19570_174_140723.eps 14-07-23 Figure 7-14 Power Architecture UHD50 - Back end 7.3.3...
Page 47
Circuit Descriptions QV14.1E LA EN 47 7.3.4 Power Layout 19570_178_140728.eps 14-07-28 Figure 7-18 Power Top View 19570_178_140728.eps 14-07-28 Figure 7-19 Power Bottom View back to 2014-Oct-22 div. table...
Page 48
IC Data Sheets EN 48 QV14.1E LA 8. IC Data Sheets This chapter shows the internal block diagrams and pin electrical diagrams (with the exception of “memory” and “logic” configurations of ICs that are drawn as “black boxes” in the ICs).
Page 49
Block Diagrams QV14.1E LA EN 49 9. Block Diagrams Wiring Diagram 81x9 and 82x9 series 48" Wiring Diagram 48” 8xx9 series 48PFS8109 8PS316 8TC60 8TC61 8CA26 19570_001_140507.eps 14-05-15 back to 2014-Oct-22 div.table...
Page 50
Block Diagrams QV14.1E LA EN 50 Wiring Diagram 81x9 and 82x9 series 48" Backcover Wiring diagram 48" 8xx9 series (inside View Backcover) 48PFS8109 8AL01 8CA05 19570_002_140507.eps 14-05-07 back to 2014-Oct-22 div.table...
Page 51
Block Diagrams QV14.1E LA EN 51 Wiring Diagram 79xx series 49" Wiring diagram 49" 79xx series 8TC51 8CA26 PHILIPS 49PUS7909 19572_005_140907.eps 14-09-08 back to 2014-Oct-22 div.table...
Page 52
Block Diagrams QV14.1E LA EN 52 Wiring Diagram 79xx series 49" Backcover Wiring diagram 49" 79xx series - Backcover (inside view) 8AL02 8AL01 49PUS7909 Backcover 19572_006_140907.eps 14-09-08 back to 2014-Oct-22 div.table...
Page 53
Block Diagrams QV14.1E LA EN 53 Wiring Diagram 79xx series 55" Wiring diagram 55" 79xx series 8AL02 8PS90 8TC51 8AL01 8CA31 8CA26 PHILIPS 55PUS7909 19572_007_140907.eps 14-09-08 back to 2014-Oct-22 div.table...
Page 54
Block Diagrams QV14.1E LA EN 54 Wiring Diagram 79xx series 55" Backcover Wiring diagram 55" 79xx series - Backcover (X-ray view = view from outside!) 8AL01 55PUS7909 Backcover 19572_006_140907.eps 14-09-08 back to 2014-Oct-22 div.table...
Page 55
Block Diagrams QV14.1E LA EN 55 Wiring Diagram 81x9 and 82x9 series 55" Wiring diagram 55" 8xx9 series 55PFS8109 8PS316 8TC60 8TC61 8CA26 19570_003_140508.eps 14-05-15 back to 2014-Oct-22 div.table...
Page 56
Block Diagrams QV14.1E LA EN 56 Wiring Diagram 81x9 and 82x9 series 55" Backcover Wiring diagram 55" 8xx9 series (inside View Backcover) 55PFS8109 8AL01 19570_004_140508.eps 14-05-15 back to 2014-Oct-22 div.table...
Page 57
Block Diagrams QV14.1E LA EN 57 Wiring Diagram 88x9 series 55" (including Backcover in X-ray view) Wiring diagram 55" 88x9 series 1171 - Ambilight Module 1172 - Ambilight Module 1171 - Ambilight Module 8AL03 8AL04 8AL05 8AL02 8PS316 8FR91 8PS90...
Page 58
Block Diagrams QV14.1E LA EN 58 9.10 Wiring Diagram 89x9 series 55" curved Wiring diagram 55" 89xx curved series 1004 - TFT screen 1111 - SSB 8FR51 5210 - Speaker 1050 - PSU 8FR54 8FR56 Mandatory Attention: Live parts! position...
Page 59
Block Diagrams QV14.1E LA EN 59 9.11 Wiring Diagram 89x9 series 55" curved Backcover Wiring diagram 55" 89xx curved series 1170 - Am7ilight Module 7 LED 1171 - Am7ilight Module 8 LED 1170 - Am7ilight Module 7 LED 8AL03 8AL04...
Page 60
Block Diagrams QV14.1E LA EN 60 9.12 Wiring Diagram 91x9 series 55" - 65" Wiring diagram 55" - 65" 91x9 series 1004 - TFT screen 0661 - Deco back 65" only 8PS319 8PS316 1111 - SSB 8FR51 8FR54 8FR56 1113 - Ultra HD Module...
Page 61
Block Diagrams QV14.1E LA EN 61 9.13 Wiring Diagram 91x9 series 55" - 65" Backcover (in X-ray view) Wiring diagram 55" - 65" 91x9 series - Backcover (X-ray view = view from outside!) 0661 - Deco Back 1170 - AmbiLight module Top...
Page 62
Block Diagrams QV14.1E LA EN 62 9.14 Wiring Diagram 98x9 series 65" Wiring diagram 65" 98x9 series 1004 - TFT screen 8FR51 8FR54 1113 - Ultra HD Module 8FR56 1050 - PSU 1111 - SSB 8TC60 8TC61 8CA26 5211 - Speaker...
Page 63
Block Diagrams QV14.1E LA EN 63 9.15 Wiring Diagram 98x9 series 65" Backcover (inside view) Wiring diagram 65" 98x9 series (view inside backcover) 1172 - Ambilight Module 9 LED 1171 - Ambilight Module 7 LED 1172 - Ambilight Module 9 LED...
Page 70
Block Diagrams QV14.1E LA EN 70 9.22 Power supply lines - Connector and Front end Connector from PSU X090 +3V5-STANDBY +12V-AL SIP32429DN-GE4 or AOZ1360DIL U022U U003U U001U U004U +3V5-STANDBY WOLAN-ENABLE LDO + Over RT9193- switch current (2 sides AL) 33GB...
Page 90
Circuit Diagrams and PWB Layouts QV14.1E LA EN 90 10-1-20 B, ANALOG IO ANALOG IO CLOSE TO SCART CLOSE TO CYPRESS X266 F175C WHITE I052C F173C R162C C075C 2.2uF AV-YPBPR-LIN 6.3V F174C I053C R163C C076C 2.2uF AV-YPBPR-RIN 6.3V X268 I054C...
Page 91
Circuit Diagrams and PWB Layouts QV14.1E LA EN 91 10-1-21 B, CYPRESS VIDEO & AUDIO CYPRESS VIDEO & AUDIO U017C 88DE6010 TTL - I2S DVIDEO-D0 R121C TTL_D[0] DVIDEO-D1 R122C TTL_D[1] DVIDEO-D2 R123C TTL_D[2] DB001C DVIDEO-D3 R124C R137C TTL_D[3] I2SOUT_MCLK DVIDEO-D4...
Page 111
Circuit Diagrams and PWB Layouts QV14.1E LA EN 111 10-1-41 B, SCALER POWER SCALER POWER F004B F005B F007B 2014-02-21 BG2-QTV FHD 2K14 715RLPCB000000005 19570_060_140523.eps 14-05-23 back to 2014-Oct-22 div.table...
Page 112
Circuit Diagrams and PWB Layouts QV14.1E LA EN 112 10-1-42 B, LVDS OUTPUT LVDS OUTPUT X050 TYPE +3V3-NVT F203B X051 TYPE F202B NT-CTRL-DISP1 R319B NTTX-BO0N F168B NT-CTRL-DISP3 R135B I059B NTTX-BO0P F169B SDA-DISP R001B I056B NTTX-BO1N F170B SCL-DISP R044B I055B NTTX-BO1P...
Page 149
Circuit Diagrams and PWB Layouts QV14.1E LA EN 149 10-2-20 B, ANALOG IO ANALOG IO CLOSE TO SCART CLOSE TO CYPRESS X266 F175C WHITE I052C F173C R162C C075C 2.2uF AV-YPBPR-LIN 6.3V F174C I053C R163C C076C 2.2uF AV-YPBPR-RIN 6.3V X268 I054C...
Page 150
Circuit Diagrams and PWB Layouts QV14.1E LA EN 150 10-2-21 B, CYPRESS VIDEO & AUDIO CYPRESS VIDEO & AUDIO CYPRESS VIDEO & AUDIO U017C 88DE6010 U017C 88DE6010 TTL - I2S DVIDEO-D0 R121C TTL_D[0] TTL - I2S DVIDEO-D1 R122C DVIDEO-D0 R121C...
Page 185
Circuit Diagrams and PWB Layouts QV14.1E LA EN 185 10-2-56 B, SiI9679CNUC on HDMI1 for HDCP2.2 SiI9679CNUC on HDMI1 for HDCP2.2 L021H L013H I045H L018H F016H R009H I050H VDD5V-IN +1V0-C AVDD10 +5V-FE VDDH33 +3V3 L014H I046H +1V0-C FVDD10 L017H I049H...
Page 186
Circuit Diagrams and PWB Layouts QV14.1E LA EN 1 10-2-57 B, 715RLPCB0000000303 - LAYOUT TOP back to 2014- div.table...
Page 187
Circuit Diagrams and PWB Layouts QV14.1E LA EN 1 10-2-58 B, 715RLPCB0000000303 - LAYOUT BOTTOM back to 2014- div.table...
Page 188
Circuit Diagrams and PWB Layouts QV14.1E LA EN 188 10.3 715RLPCB0000000401 SSB 10-3-1 2014-04-18 MV_eco_UHD HDMI20 715RLPCB000000040 back to 2014-Oct-22 div.table...
Page 189
QV14.1E LA Circuit Diagrams and PWB Layouts HF, 715RLPCB0000000 - LAYOUT back to 2014- div.table...
Page 190
QV14.1E LA Circuit Diagrams and PWB Layouts HF, 715RLPCB0000000 - LAYOUT BOTTOM...