Toro Mower Safety; Sound Power Level - Toro 30604 Operator's Manual

Toro Mower Safety

The following list contains safety information specific to Toro
products or other safety information that you must know that
is not included in the CEN, ISO, or ANSI standards.
This product is capable of amputating hands and feet and
throwing objects. Always follow all safety instructions to
avoid serious injury or death.
Use of this product for purposes other than its intended use
could prove dangerous to user and bystanders.
WARNING
Engine exhaust contains carbon monoxide, which
is an odorless, deadly poison that can kill you.
Do not run engine indoors or in an enclosed area.
Operation
•
Before operating a machine with ROPS (roll over
protection system), be certain that the seat belts are
attached and the seat is latched to prevent the seat from
pivoting forward.
•
Know how to stop the machine and engine quickly.
•
Do not operate the machine while wearing tennis shoes
or sneakers.
•
Wearing safety shoes and long pants is advisable and
required by some local ordinances and insurance
regulations.
•
Keep hands, feet, and clothing away from moving parts
and the mower discharge area and underside of the
mower while the engine is running.
•
Fill fuel tank until level is 25 mm (1 inch) below the
bottom of the filler neck. Do not overfill.
•
Check the safety interlock switches daily for proper
operation. If a switch should fail, replace the switch
before operating the machine.
•
Check carefully for overhead clearances (i.e. branches,
doorways, electrical wires) before driving under any
objects and do not contact them.
•
Do not mow in reverse unless absolutely necessary.
•
Reduce speed when making sharp turns.
•
Avoid starting or stopping on a slope. If tires lose traction,
disengage the blades and proceed slowly straight down
the slope. Avoid raising the side cutting units on a slope.
•
Avoid turning on slopes. If you must turn, turn slowly
and gradually downhill, if possible.
•
When operating a machine with a ROPS, always use a
seat belt.
•
Be certain that the seat belt can be released quickly if the
machine is driven or rolls into a pond or water.
•
Watch for traffic when near or crossing roads. Always
yield the right-of-way.
•
This machine is not designed or equipped for on-road
use and is a "slow-moving vehicle". If you must cross
or travel on a public road, you should be aware of and
comply with local regulations, such as required lights,
slow moving vehicle signs, and reflectors.
•
Do not mow near drop-offs, ditches, or embankments.
The machine could suddenly turn over if a wheel goes
over the edge of a cliff or ditch, or if an edge caves in.
•
Do not mow on wet grass. Reduced traction could cause
sliding.
•
Use extra care with other attachments. These can change
the stability of the machine.
•
Turn off the blades when not mowing.
Maintenance and Storage
•
Do not touch equipment or attachment parts which may
be hot from operation. Allow to cool before attempting
to maintain, adjust, or service.
•
Never store the machine or fuel container inside where
there is an open flame, such as near a water heater or
furnace.
•
Keep nuts and bolts tight, especially the blade attachment
bolts. Keep equipment in good condition.
•
If the engine must be running to perform a maintenance
adjustment, keep hands, feet, clothing, and any parts of
the body away from the cutting units, attachments, and
any moving parts. Keep everyone away.
•
Check brake operation frequently. Adjust and service as
required.
•
Battery acid is poisonous and can cause burns. Avoid
contact with skin, eyes, and clothing. Protect your face,
eyes, and clothing when working with a battery.
•
Battery gases can explode. Keep cigarettes, sparks, and
flames away from the battery.
•
The engine must be shut off before checking the oil or
adding oil to the crankcase.
•
If major repairs are ever needed or if assistance is desired,
contact an Authorized Toro Distributor.
•
To make sure of optimum performance and continued
safety certification of the machine, use only genuine Toro
replacement parts and accessories. Replacement parts
and accessories made by other manufacturers could be
dangerous, and such use could void the product warranty.

Sound Power Level

This unit has a guaranteed sound power level of 104 dBA,
which includes an Uncertainty Value (K) of 1 dBA.
Sound power level was determined according to the
procedures outlined in ISO 11094.
6