Flow modulated with standing pilot suitable for heating potable water only - not approved for space heating purposes (intended for variable flow applications with steady cold water inlet temperatures) (28 pages)
Polypropylene heating canister replacement wh27 model only electric tankless water heater (11 pages)
Summary of Contents for Bosch TRONIC 5000T ES30M
Page 1
Installation Manual Electric Water Heaters TRONIC 5000T ES30M | ES40M | ES50M | ES40T | ES50T | ES40LB | ES50LB WARNING: The information in these instructions must be followed exactly. Improper installation, adjustment, service or maintenance can cause property damage, personal injury or death. WARNING: Installation and service must be performed by a qualifi...
Page 2
Installation Manual Bosch Tronic 5000T Electric Water Heaters - BTC 724001301 A (10.2021)
11.1 Draining Heater 11.2 Test the TPR Valve 11.3 Heating Elements 11.4 Anode Rod 11.5 Water Heater Sounds 11.6 Sediment Build-Up 11.7 Leakage Checkpoints 12 Troubleshooting 13 Water Heater Components Bosch Tronic 5000T Electric Water Heaters- BTC 724001301 A (10.2021)
Flammable vapors may be drawn to this water heater from other areas of the structure by air currents. Bosch Tronic 5000T Electric Water Heaters - BTC 724001301 A (10.2021)
Page 5
Contact a licensed plumber or the local plumbing authority for further information. Applicable local codes govern installation. Bosch Tronic 5000T Electric Water Heaters- BTC 724001301 A (10.2021)
Local codes and requirements in your area may require that the water heater be installed in such way that the bottom thermostat is elevated at least 18 inches from the fl oor. Bosch Tronic 5000T Electric Water Heaters - BTC 724001301 A (10.2021)
The illustration above shows the temperature adjustment dial used for setting the water temperature. Refer to the Operating Instructions in this manual for detailed instructions on how to adjust the thermostat(s). Bosch Tronic 5000T Electric Water Heaters- BTC 724001301 A (10.2021)
Using chlorinated fresh water is acceptable if the level of chloride concentration is less than 5ppg (mg/L). Do not connect the appliance to directly heat swimming pool or spa water. Bosch Tronic 5000T Electric Water Heaters- BTC 724001301 A (10.2021)
0 inches minimum clearance to combustible walls. The heater should be located so that all electrical controls, heating elements, drain valve and water connections are accessible. Adequate clearance must be provided for the access panel. 1 0 | Bosch Tronic 5000T Electric Water Heaters - BTC 724001301 A (10.2021)
Excessive length, over 30 feet, or use of more than four elbows can cause restriction and reduce the discharge capacity of the valve. | 11 Bosch Tronic 5000T Electric Water Heaters- BTC 724001301 A (10.2021)
Must be capable of withstanding 250°F ( 121°C) without distortion. Must be installed to allow complete drainage of both the temperature and pressure relief valve and discharge line. Figure 4 1 2 | Bosch Tronic 5000T Electric Water Heaters - BTC 724001301 A (10.2021)
If you wish to reuse the existing aluminium wire, have the connection at the water heater made by a qualifi ed electrician. | 13 Bosch Tronic 5000T Electric Water Heaters- BTC 724001301 A (10.2021)
W iring connections may loosen in shipment. Check all connections for tightness. 1 4 | Bosch Tronic 5000T Electric Water Heaters - BTC 724001301 A (10.2021)
. Once the switch opens, it must be manually reset and the cause of the over temperature condition must be corrected.To reset the high limit, follow the written instructions shown on page 13. | 15 Bosch Tronic 5000T Electric Water Heaters- BTC 724001301 A (10.2021)
Page 16
Installation Manual SHUT-OFF VALVE COLD TEMPERATURE-PRESSURE RELIEF VALVE DISCHARGE PIPE (DO NOT CAP OR PLUG) 6" AIR GAP SUITABLE OPEN DRAIN Figure 6 Installation Example 1 6 | Bosch Tronic 5000T Electric Water Heaters - BTC 724001301 A (10.2021)
fl ow. There should be no Cover smoking or open fl ame near the faucet at the time it is open. Figure 7 Type 59T Thermostat and Protective Cover | 17 Bosch Tronic 5000T Electric Water Heaters- BTC 724001301 A (10.2021)
Failure of the tank or heating elements due to accumulated deposits does not fall within the scope of the warranty. 1 8 | Bosch Tronic 5000T Electric Water Heaters - BTC 724001301 A (10.2021)
Monthly in hard water areas (hardness 7 grains – 120 mg/L or above) With this operation, sediment build-up and scale is removed. If not, large scale stones will form and aff ect your water heater effi ciency. | 19 Bosch Tronic 5000T Electric Water Heaters- BTC 724001301 A (10.2021)
Adjustment" section and then remove fi tting. Put pipe dope or Tefl on tape on the threads and replace. Then follow "Filling the Water Heater" instructions in the "Installation Instructions" section. 2 0 | Bosch Tronic 5000T Electric Water Heaters - BTC 724001301 A (10.2021)
The thermostat is set too high. this manual. Table 6 I f further assistance is needed, our technical support team is available Monday to Friday via: Email: www.boschheatingcooling.com/contact Phone: 1-866-642-3198 | 21 Bosch Tronic 5000T Electric Water Heaters- BTC 724001301 A (10.2021)
Installation Manual 13 Water Heater Components Figure 12 2 2 | Bosch Tronic 5000T Electric Water Heaters - BTC 724001301 A (10.2021)
Page 23
Installation Manual | 23 Bosch Tronic 5000T Electric Water Heaters- BTC 724001301 A (10.2021)
Page 24
United States and Canada Bosch Thermotechnology Corp. 65 Grove St. Watertown, MA 02472 Tel: 866-642-3198 www.bosch-thermotechnology.us BTC 724001301 A / 10.2021 Bosch Thermotechnology Corp. reserves the right to make changes without notice due to continuing engineering and technological advances.