Page 1
ORDER NO. MD0704027CE DVD Home Theater Sound System SA-PT350E SA-PT350EB SA-PT350EG Colour (S).......Silver Type Specifications DIN Output Power: Dolby Digital Mode lGENERAL Power Supply: lTotal DIN Dolby Digital mode power: E/EG areas: AC 230 V, 50 Hz 280 W EB area:...
Page 2
Extremely long and narrow pictures may not be displayed. 0.7 Vp-p (75 Ω) output level: *5 MPEG4 data recorded with the Panasonic SD multi cameras 0.7 Vp-p (75 Ω) output level: or DVD video recorders. Pin jack (Y: green, P...
Page 3
SA-PT350E / SA-PT350EB / SA-PT350EG Refer to their respective original service manuals for *1, *2, *3, *4, *5, *6, *7.
SA-PT350E / SA-PT350EB / SA-PT350EG CONTENTS Page Page 1 Safety Precautions 10.8. Disassembly of USB P.C.B. 1.1. GENERAL GUIDELINES 10.9. Disassembly of Scart P.C.B. 1.2. Before Repair and Adjustment 10.10. Disassembly of Rear Panel 1.3. Protection Circuitry 10.11. Disassembly of DVD Mechanism Unit 1.4.
Page 5
SA-PT350E / SA-PT350EB / SA-PT350EG 18.4. DVD (Video) 21.5. SMPS & Wireless Adapter P.C.B. 18.5. DVD (HDMI) 21.6. AC-Inlet, Scart, Relay, Tray Loading P.C.B. 18.6. Audio 22 Basic Troubleshooting Guide 18.7. Audio Digital Amp 22.1. Basic Troubleshooting Guide for Traverse Unit (DVD 18.8.
SA-PT350E / SA-PT350EB / SA-PT350EG 1 Safety Precautions 1.1. GENERAL GUIDELINES 1. When servicing, observe the original lead dress. If a short circuit is found, replace all parts which have been overheated or damaged by the short circuit. 2. After servicing, see to it that all the protective devices such as insulation barriers, insulation papers shields are properly installed.
SA-PT350E / SA-PT350EB / SA-PT350EG The function of this circuitry is to prevent circuitry damage if, for example, the positive and negative speaker connection wires are “shorted”, or if speaker systems with an impedance less than the indicated rated impedance of the amplifier are used.
SA-PT350E / SA-PT350EB / SA-PT350EG 1.5. Caution for AC Cord (For United Kingdom) WARNING: DO NOT CONNECT EITHER WIRE TO THE EARTH TERMINAL WHICH IS MARKED WITH THE LETTER ("EB" area code model only) E, BY THE EARTH SYMBOL OR COLOURED GREEN OR For your safety, please read the following text carefully.
SA-PT350E / SA-PT350EB / SA-PT350EG 2 Prevention of Electro Static Discharge (ESD) to Electrostatically Sensitive (ES) Devices Some semiconductor (solid state) devices can be damaged easily by static electricity. Such components commonly are called Electrostatically Sensitive (ES) Devices. Examples of typical ES devices are integrated circuits and some field-effect transistors and semiconductor "chip"...
SA-PT350E / SA-PT350EB / SA-PT350EG 4 About Lead Free Solder (PbF) 4.1. Service caution based on legal restrictions 4.1.1. General description about Lead Free Solder (PbF) The lead free solder has been used in the mounting process of all electrical components on the printed circuit boards used for this equipment in considering the globally environmental conservation.
SA-PT350E / SA-PT350EB / SA-PT350EG 5 Handling Precautions for Traverse Unit The laser diode in the optical pickup unit may break down due to static electricity of clothes or human body. Special care must be taken avoid caution to electrostatic breakdown when servicing and handling the laser diode in the Traverse unit.
SA-PT350E / SA-PT350EB / SA-PT350EG 6 Accessories · Note: Refer to “Replacement Parts List” (Section 26) for the part number. AC cord (For EB area only) Remote control AC clamp filter *1 Antenna wire (For EB area only) Din adaptor...
SA-PT350E / SA-PT350EB / SA-PT350EG 7 Operation Procedures 7.1. Remote Control Key Buttons Operations Television operations Adjust the television volume Select the source DVD: DVD/CD Switch the main unit on or off EXT-IN: USB , AV , AUX, Change the television’s video input mode D-IN, MUSIC P.
SA-PT350E / SA-PT350EB / SA-PT350EG 7.2. Main Unit Key Buttons Operations /MEMORY Disc playback, Memorise the receiving radio stations Standby/on switch [ /I] Press to switch the unit from on to / TUNE MODE / FM MODE standby mode or vice versa. In standby...
SA-PT350E / SA-PT350EB / SA-PT350EG 7.3. Wireless Surround 7.3.1. Wireless System Key Buttons Operations The illustration shows the wireless system for SH-FX65. Unit on/off button [ Use this button to turn the wireless system on and off. AUTO OPERATION ON/OFF : The unit is on.
VIERA Link "HDAVI Control" is a convenient function that This function works only when "DVD/CD", "USB", "AUX " offers linked operation of this unit, and a Panasonic television or "D-IN " is selected as the source on the home theater (VIERA) under "HDAVI Control".
SA-PT350E / SA-PT350EB / SA-PT350EG 7.5. Music Port Connection and Operation The Music Port allows you to connect and enjoy music from To select "MUSIC P.". an external device (example: MP3 player) through your D-IN (Digital In) home theater system.
SA-PT350E / SA-PT350EB / SA-PT350EG 7.6. USB Connection and Operation The USB connectivity enables you to connect and play tracks or files from USB mass storage class devices. Typically, USB memory devices. (Bulk only transfer) Preparation Before connecting any USB mass storage device to the unit, ensure that the data stored therein has been backed It is not recommended to use a USB extension cable.
O/I page 24, Set "Video Output Mode" ( Picture Menu). VIERA Link ("HDAVI Control") If your Panasonic television is a VIERA Link compatible television, you can operate your television synchronising with home theater operations or vice versa (O/I page 36). Note Make the extra audio connection (O/I page 34) when you use "HDAVI...
Closing the session will also work. MPEG4 data recorded with the Panasonic SD multi cameras or DVD video recorders [conforming to SD VIDEO specifications (ASF standard)/MPEG4 (Simple Profile) video system/G.726 audio system].
Page 23
You can play MPEG4 data [conforming to SD VIDEO speci c fi ations (ASF standard)/MPEG4 (Simple Pro le) video system/G.726 audio system] recorded with Panasonic SD multi cameras or DVD video rec orders with this unit. The recording date may differ from that of the actual date.
SA-PT350E / SA-PT350EB / SA-PT350EG 8.2. Wireless Features 8.2.1. Function Overview Year 2007 PT models support wireless which includes FX65/FX66, wireless subwoofer and FX85 as described below:- 8.2.1.1. FX65/FX66 · The FX65/FX66 supports one-way wireless transmission only, that is, it will only transmit wireless audio signal to the rear surround speakers.
Page 27
SA-PT350E / SA-PT350EB / SA-PT350EG 8.2.2. Block Diagram · There are two types of transmitter cards, Type A and Type B, and two types of receiver modules, Type 1 and Type 2 for the wireless configuration. The block diagrams below describe the differences of each of the types.
Page 28
SA-PT350E / SA-PT350EB / SA-PT350EG 8.2.2.2. TX-TYPE B / RX-TYPE 2 Note: FX65/FX66 SIGNAL FLOW - FX85 S S IGNAL F F LOW - ONE WAY AND SIMULTANEOUS - FX65/FX66 + FX85 - FX65/FX66 TRANSMITTER NOT USED, NEED TO IDSET...
Page 29
SA-PT350E / SA-PT350EB / SA-PT350EG This button will send command to the main unit to play CD/DVD as well as the iPod. This function is therefore meaningful only if the second room selector is in Main Source (with the first room user in CD/DVD or iPod) and iPod.
Page 30
SA-PT350E / SA-PT350EB / SA-PT350EG 8.2.6. FX Configurations There are four types of configurations for the FX series. This is explained by the following illustrations below: Case 1: FX65/FX66 · This is the basic configuration of FX65/FX66 whereby it is only receiving wireless surround audio signal from the main set. This uses a Type A transmitter which is only able to send audio in one direction.
Page 31
SA-PT350E / SA-PT350EB / SA-PT350EG CH2/AB CH2/AB Case 3 B: FX65/FX66 + FX85 + Wireless Subwoofer (for PTX7, PT1050) · In this configuration, all audio source for the Type 1 subwoofer and Type 1 first room receiver (FX65/FX66) through streams AB via Ch 2 and Type 2 second room receiver (FX85) comes from transmitter B through streams CD via Ch 1.
Page 32
SA-PT350E / SA-PT350EB / SA-PT350EG 8.2.7. User Operation Flow START Is Tx card inserted? Insert Tx card POWER ON MAINSET Is there audio source playing? Play music Is music heard on CHECK FOR SPEAKER Is wireless link led wireless surround...
SA-PT350E / SA-PT350EB / SA-PT350EG 9 Self-Diagnosis and Special Mode Setting 9.1. Service Mode Summary Table The service modes can be activated by pressing various button combination on the main unit and remote control unit. Below is the summary for the various modes for checking:...
Page 34
SA-PT350E / SA-PT350EB / SA-PT350EG 9.2.1. Service Mode Table 1 Item Key Operation FL Display Mode Name Description Front Key Jitter check Jitter check. In STOP (no disc) mode, (Display 1) Jitter rate is measured and displayed. press [STOP] button on the...
Page 35
SA-PT350E / SA-PT350EB / SA-PT350EG 9.2.2. Service Mode Table 2 Key Operation Item FL Display Mode Name Description Front Key (Display 1) DVD laser DVD laser drive current measurement. In STOP (no disc) mode, drive current DVD laser drive current is measured...
Page 36
SA-PT350E / SA-PT350EB / SA-PT350EG 9.2.3. Service Mode Table 3 Item Key Operation FL Display Mode Name Description Front Key Micro-processor Micro-processor firmware version In STOP (no disc) (Display 1) firmware version display & EEPROM checksum display. mode, press [STOP] display &...
Page 37
SA-PT350E / SA-PT350EB / SA-PT350EG Product Region TV Broadcasting Model Series Country Region Signal System Region Display Code OSD Menu Language System (Default) (Default) English, Spanish, Canadian P, PC, PX USA, Canada, PX NTSC NTSC (*A) French Japan NTSC NTSC (*A)
Page 38
SA-PT350E / SA-PT350EB / SA-PT350EG 9.2.4. Service Mode Table 4 Item Key Operation FL Display Mode Name Description Front Key DVD Module P.C.B. firmware version In STOP (no disc) Module P.C.B. is displayed on the FL Display. mode, press [STOP]...
Page 39
SA-PT350E / SA-PT350EB / SA-PT350EG 9.2.5. Service Mode Table 5 Item Key Operation FL Display Mode Name Description Front Key Timer 1 check Timer 1 check In STOP (no disc) (Display 1) Laser operation timer is measured mode, press [STOP] separately for DVD laser and CD laser.
Page 40
SA-PT350E / SA-PT350EB / SA-PT350EG 9.2.6. Optical Pick-up Self-Diagnosis The optical pickup self-diagnosis function and tilt adjustment check function have been included in this unit. When repairing, use the following procedure for effective self-diagnosis and tilt adjustment. Be sure to use the self-diagnosis function before replacing the optical pickup when "NO DISC"...
SA-PT350E / SA-PT350EB / SA-PT350EG 9.3. Wireless Service Mode Summary Table The service modes can be activated by pressing various button combination on the player and remote control unit. Below is the summary of major checking: Player buttons Remote control unit buttons...
SA-PT350E / SA-PT350EB / SA-PT350EG 9.4. Service Mode Table (Wireless) By pressing various button combinations on the player and remote control unit, you can activate the various service modes for checking. 9.4.1. Service Mode Table 1 Item Key Operation FL Display...
Page 43
SA-PT350E / SA-PT350EB / SA-PT350EG 9.4.2. Service Mode Table 2 Item Key Operation FL Display Mode Name Description Front Key (Display 1) RF Channel RF Channel 1 Display* Main room is in AUX mode. Selection Display FL Display sequence: Display 1...
SA-PT350E / SA-PT350EB / SA-PT350EG 9.5. DVD Self Diagnostic Function-Error Code 9.5.1. Mechanism Error Code Table Error Diagnosis Contents Description of error Automatic FL Display Remarks Code H01 Tray loading error The tray opening and closing is Press [ STOP] on abnormal.
Page 45
SA-PT350E / SA-PT350EB / SA-PT350EG 9.5.2. DVD Module Error Code Table Error Diagnosis Contents Description of error Automatic FL Display Remarks Code U702 HDMI/DVI I2C The communication error of I2C Press [ STOP] on communication error when connecting it with HDMI/ main unit for next error.
Page 46
SA-PT350E / SA-PT350EB / SA-PT350EG 9.5.3. Power Supply Error Code Table Error Diagnosis Contents Description of error Automatic FL Display Remarks Code F61 The abnormalities In normal operation, when DCDET2 Press [ STOP] on in an output or power goes to "L" (Low) (Not during POWER main unit for next error.
SA-PT350E / SA-PT350EB / SA-PT350EG 9.5.5. USB Error Code Table Error Diagnosis Contents Description of error Automatic FL Display Remarks Code F650 USB device: Devices Devices other than the mass storage Press [ STOP] on other than mass class are connected.
SA-PT350E / SA-PT350EB / SA-PT350EG 9.7. Service Precautions 9.7.1. Recovery after the DVD player is repaired · When the FLASH ROM IC or DVD Module P.C.B. is replaced, carry out the recovery processing to optimize the drive. Playback the recovery disk to process the recovery automatically.
SA-PT350E / SA-PT350EB / SA-PT350EG 10 Assembling and Disassembling “ATTENTION SERVICER” Be careful when disassembling and servicing. Some chassis components may have sharp edges. Special Note: 1. This section describes the disassembly procedures for all the major printed circuit boards and main components.
SA-PT350E / SA-PT350EB / SA-PT350EG 10.3. Disassembly of Top Cabinet Step 1 Remove 4 screws. Step 2 Remove 3 screws at the rear panel Step 3 Lift up and remove the top cabinet in the direction of arrows. Step 2 Insert the gear jig into the tray open/ close hole.
SA-PT350E / SA-PT350EB / SA-PT350EG Special Note : Avoid placing the set in a position that might cause damage to the jacks when removing the front panel. Note : You can return the tray by turning the gear jig clockwise.
SA-PT350E / SA-PT350EB / SA-PT350EG Step 2 Detach FFC cable from the connector (CN2008) on 10.11. Disassembly of DVD Main P.C.B. Mechanism Unit Step 3 Remove Scart P.C.B. · Follow (Step 1) to (Step 3) of Item 10.3. · Follow (Step 1) to (Step 4) of Item 10.4.
SA-PT350E / SA-PT350EB / SA-PT350EG CN2010) on Main P.C.B. Step 7 Remove 1 screw from DVD Module P.C.B. Caution : Do not use strong or excessive force to avoid damage to FFC cables. 10.13. Disassembly of DVD Module Step 8 Remove 2 screws from the rear panel.
SA-PT350E / SA-PT350EB / SA-PT350EG Step 1 Desolder pins of the regulator IC (IC2903) on the back side of Main P.C.B. Step 3 Remove 4 screws from Main P.C.B. Step 2 Remove 1 screw from the regulator IC (IC2903). Step 3 Remove the regulator IC (IC2903) from the heatsink extrussion.
SA-PT350E / SA-PT350EB / SA-PT350EG Step 3 Remove 8 screws. Step 4 Release the tab of the rear panel in the direction of arrow. · Disassembly of D-Amp P.C.B. Step 3 Remove the wire clamper to detach FFC cable from the connector (CN5801) on SMPS P.C.B.
SA-PT350E / SA-PT350EB / SA-PT350EG 10.18. Replacement of Digital Amp IC Note : For replacement of IC5300, repeat the (Step 1) to (Step 4). Refer to the diagrams of D-Amp P.C.B. (Item 10.17) for (IC5000) location of the parts. · Follow (Step 1) to (Step 3) of Item 10.3.
SA-PT350E / SA-PT350EB / SA-PT350EG arrow. Step 8 Remove SMPS & AC-Inlet P.C.B. Note : Refer to the diagrams of SMPS P.C.B. (Item 10.19) for location of the parts. 10.21. Replacement of Regulator Diode (D5801/D5802) · Follow (Step 1) to (Step 3) of Item 10.3.
SA-PT350E / SA-PT350EB / SA-PT350EG Note : Refer to the diagrams of SMPS P.C.B. (Item 10.19) for location of the part. Note : Refer to the diagrams of SMPS P.C.B. (Item 10.19) for location of the parts. 10.22. Replacement of Regulator Diode (D5803) ·...
SA-PT350E / SA-PT350EB / SA-PT350EG 11 Assembly and Disassembly of DVD Mechanism Unit 11.1. Disassembly Procedure Step 4 Remove the traverse unit. 11.1.1. Disassembly of Traverse Unit (with Middle Chassis) Step 1 Slide the lever (A) in the arrow direction (to the opposite side) till it stops.
Page 63
SA-PT350E / SA-PT350EB / SA-PT350EG l(Assembly of the tray unit) Step 2 Raise the mecha chassis vertically. Step 1 Insert a part of the tray into the unit sliding over the Step 3 Slide the lever in the arrow direction till it stops and pull groove on the mecha chassis.
Page 64
SA-PT350E / SA-PT350EB / SA-PT350EG Step 4 Remove the belt. Step 5 Unlock the tab and remove the pulley gear. 11.1.3. Disassembly of Loading Section Step 6 Remove the relay gear. Step 1 Spread the tabs at the both sides and push out the drive arm.
Page 65
SA-PT350E / SA-PT350EB / SA-PT350EG Step 9 Pull the lever (B) at the bottom side in the direction of arrow and remove the change lever. 11.1.5. Disassembly of Traverse Unit Step 1 Spread the tabs to push in the pin in the direction of arrows.
Page 66
SA-PT350E / SA-PT350EB / SA-PT350EG Step 3 Remove the middle chassis. Step 4 Remove the traverse unit.
SA-PT350E / SA-PT350EB / SA-PT350EG 12 Service Position 12.1. Checking & Repairing Scart P.C.B. Step 1 Remove the top cabinet to service Scart P.C.B. 12.3. Checking & Repairing Main P.C.B. Step 1 Remove the top cabinet. Step 2 Remove the DVD lid.
SA-PT350E / SA-PT350EB / SA-PT350EG 12.4. Checking & Repairing D-Amp P.C.B. · Follow (Step 1) to (Step 16) of Item 12.3. Step 1 Turn over D-Amp P.C.B vertically and place it according to the diagram shown below. Step 16 Connect FFC cable at the connectors (CN2001, CN2003, CN2007, CN2008, CN2010 &...
SA-PT350E / SA-PT350EB / SA-PT350EG 12.6. Checking & Repairing SMPS P.C.B. · Follow (Step 1) to (Step 16) of Item 12.3. Step 1 Turn over SMPS P.C.B vertically and place it according to the diagram shown below.
SA-PT350E / SA-PT350EB / SA-PT350EG 13 Measurements and Adjustments 13.1. Service Tools and Equipment Application Name Number Tilt adjustment DVD test disc DVDT-S20 [SPG] TORX screw driver (T6) Available on sales route. (T6) or RFKZ0185 [SPG] Others Grease RFKXPG641 [SPG]...
SA-PT350E / SA-PT350EB / SA-PT350EG 15 Voltage and Waveform Chart 15.1. DVD Module P.C.B. IC3901 Ref No. MODE CD PLAY Ref No. IC3901 MODE CD PLAY IC3901 Ref No. MODE CD PLAY IC3901 Ref No. MODE CD PLAY IC3901 Ref No.
Page 75
SA-PT350E / SA-PT350EB / SA-PT350EG IC8421 Ref No. MODE CD PLAY IC8421 Ref No. MODE CD PLAY IC8601 IC8606 IC8611 Ref No. MODE CD PLAY IC8651 Ref No. MODE CD PLAY IC8651 Ref No. MODE CD PLAY IC8651 Ref No.
SA-PT350E / SA-PT350EB / SA-PT350EG 15.2. Main P.C.B. IC2001 Ref No. MODE CD PLAY STANDBY Ref No. IC2001 MODE CD PLAY STANDBY Ref No. IC2001 MODE CD PLAY STANDBY Ref No. IC2001 MODE CD PLAY STANDBY IC2001 Ref No. MODE...
SA-PT350E / SA-PT350EB / SA-PT350EG 18 Block Diagram 18.1. System Control T2900 SWITCHING FL6901 TRANSFORMER IC2001 C2CBYY000418 CN6902 CN2007 FL DISPLAY SYSTEM CONTROL FP2900 CN6902 CN2007 +18V S901 PLAY Q2900 CS901 CN2015 TRAY CLOSE FX EN PSAVE IC6901 CONTROL S902...
SA-PT350E / SA-PT350EB / SA-PT350EG 18.2. DVD (Servo) : CD HEAD SIGNAL LINE : DVD RF SIGNAL LINE : TRACKING ERROR SIGNAL LINE : DVD HEAD SIGNAL LINE : MOTOR DRIVE SIGNAL LINE : FOCUS ERROR SIGNAL LINE IC8001 IC8251...
SA-PT350E / SA-PT350EB / SA-PT350EG 18.3. DVD (Audio) : DVD RF SIGNAL LINE : DVD AUDIO SIGNAL LINE : MAIN SIGNAL LINE : USB SIGNAL LINE IC8421 IC8001 C0FBBK000050 MN2DS0018MP AUDIO DAC DV5.0 LSI OPTICAL PIC-UP UNIT FP8531 FP8101 CN2001...
Page 88
SA-PT350E / SA-PT350EB / SA-PT350EG 18.4. DVD (Video) : DVD VIDEO SIGNAL LINE IC8001 IC2801 MN2DS0018MP C9ZB00000461 DV5.0 LSI VIDEO BUFFER IC2802 C1AB00001731 VIDEO BUFFER BIAS Q8331 Y/PY/G FP8101 CN2001 CY IN 12 MHz DAC1 OUT BUFFER CY OUT JK2001...
Page 89
SA-PT350E / SA-PT350EB / SA-PT350EG 18.5. DVD (HDMI) : DVD AUDIO SIGNAL LINE : DVD VIDEO SIGNAL LINE : MAIN SIGNAL LINE IC8001 MN2DS0018MP DV5.0 LSI HDMI TRANSMITTER IC3901 MN864702A HDMI CONNECTOR P3901 EXDT15 DVOUT0 EXT SWING D+3.3V EXDT7 DVOUT1...
Page 90
SA-PT350E / SA-PT350EB / SA-PT350EG 18.6. Audio :MAIN SIGNAL LINE :FM SIGNAL LINE :AUX, MUSIC PORT SIGNAL LINE Q1009 Q1100 FROM MUTING CN1001 CN2008 MUTING SCART MUTE SYSTEM CONTROL CONTROL IC2101 C1AB00002735 Q2201 AUDIO SIGNAL PROCESSOR FROM MUTING HP MUTE...
Page 91
D-TYPE FLIP-FLOP Q5641 FAN LOCK CN5501 FAN LOCK DETECT Q1 2 Q5640, Q5642, Q5644 FAN DC OUT CN5501 X5500 FAN MOTOR FAN DC DRIVE FAN GND CN5501 TO SYSTEM CONTROL DC DET CN2009 CN5050 SA-PT350E/EB/EG AUDIO DIGITAL AMP BLOCK DIAGRAM...
Page 93
SA-PT350E / SA-PT350EB / SA-PT350EG : CD Head signal line 19 Schematic Diagram Notes : DVD Head signal line · This schematic diagram may be modified at any time with the development of new technology. : Main signal line Notes: S901: Play switch.
Page 95
SA-PT350E / SA-PT350EB / SA-PT350EG 20 Schematic Diagram 20.1. DVD Module (DV5/HDMI) Circuit SCHEMATIC DIAGRAM - 1 : DVD RF SIGNAL LINE : CD HEAD SIGNAL LINE : DVD AUDIO SIGNAL LINE : FOCUS ERROR SIGNAL LINE DVD MODULE (DV5) CIRCUIT...
Page 96
SA-PT350E / SA-PT350EB / SA-PT350EG SCHEMATIC DIAGRAM - 2 DVD MODULE (DV5) CIRCUIT : +B SIGNAL LINE : DVD AUDIO SIGNAL LINE : DVD VIDEO SIGNAL LINE : MAIN SIGNAL LINE : USB SIGNAL LINE FP8101 ADAC-CLK ADAC-CLK VGND Y_PY_G...
Page 97
SA-PT350E / SA-PT350EB / SA-PT350EG SCHEMATIC DIAGRAM - 3 DVD MODULE (DV5) CIRCUIT : +B SIGNAL LINE : MOTOR DRIVE SIGNAL LINE : DVD RF SIGNAL LINE : DVD AUDIO SIGNAL LINE TO DVD MODULE (DV5) SECTION (1/4) IC9001 C0JBAZ001251...
Page 98
SA-PT350E / SA-PT350EB / SA-PT350EG SCHEMATIC DIAGRAM - 4 : CD HEAD SIGNAL LINE : MOTOR DRIVE SIGNAL LINE : DVD RF SIGNAL LINE DVD MODULE (DV5) CIRCUIT : +B SIGNAL LINE : DVD HEAD SIGNAL LINE : TRACKING ERROR SIGNAL LINE...
Page 99
SA-PT350E / SA-PT350EB / SA-PT350EG SCHEMATIC DIAGRAM - 5 DVD MODULE(HDMI) CIRCUIT : +B SIGNAL LINE : DVD AUDIO SIGNAL LINE : DVD VIDEO SIGNAL LINE : MAIN SIGNAL LINE LB3907 J0JHC0000045 C3904 4V330 LB3902 J0JHC0000045 C3902 C3910 C3914 C3924...
Page 100
SA-PT350E / SA-PT350EB / SA-PT350EG 20.2. Main & Panel Circuit SCHEMATIC DIAGRAM - 6 :-B SIGNAL LINE MAIN CIRCUIT :+B SIGNAL LINE :MAIN SIGNAL LINE :FM SIGNAL LINE :DVD VIDEO SIGNAL LINE R2752 C2703 C2754 D2752 10V33 B0ACCK000005 R2758 100P...
Page 101
SA-PT350E / SA-PT350EB / SA-PT350EG SCHEMATIC DIAGRAM - 7 :-B SIGNAL LINE MAIN CIRCUIT :+B SIGNAL LINE :MAIN SIGNAL LINE :AUX / MUSIC PORT SIGNAL LINE CN2020 HP-RCH R2041 4.7K HP_RCH AGND R2021 AGND W2526 W2536 HP-LCH HP_LCH R2008 VREF...
Page 102
SA-PT350E / SA-PT350EB / SA-PT350EG SCHEMATIC DIAGRAM - 8 :-B SIGNAL LINE MAIN CIRCUIT :+B SIGNAL LINE :MAIN SIGNAL LINE :FM SIGNAL LINE :DVD VIDEO SIGNAL LINE :AUX / MUSIC PORT SIGNAL LINE R2299 TO MAIN CN2010 SECTION (1/4) 2CH_SEL...
Page 103
SA-PT350E / SA-PT350EB / SA-PT350EG SCHEMATIC DIAGRAM - 9 :-B SIGNAL LINE MAIN CIRCUIT :+B SIGNAL LINE :MAIN SIGNAL LINE :DVD VIDEO SIGNAL LINE :AUX / MUSIC PORT SIGNAL LINE :FM SIGNAL LINE Q2909 Q2922 Q2919 VGND B1GBCFJN0033 B1GBCFJJ0051 B1ABCF000176...
Page 104
SA-PT350E / SA-PT350EB / SA-PT350EG SCHEMATIC DIAGRAM - 10 PANEL CIRCUIT :+B SIGNAL LINE :-B SIGNAL LINE :MUSIC PORT SIGNAL LINE FL6901 L6905 W6115 JK6802 A2BD00000170 J0JBC0000019 DGND FL DISPLAY R6968 C6933 R6949 L6907 J0JBC0000019 R6948 R6971 L6906 R6965 W6130...
Page 105
SA-PT350E / SA-PT350EB / SA-PT350EG 20.3. D-Amp & SMPS Circuit SCHEMATIC DIAGRAM - 11 D-AMP CIRCUIT :+B SIGNAL LINE :-B SIGNAL LINE :MAIN SIGNAL LINE FAN_DC IC5300 C1AA00000755 AUDIO DIGITAL POWER AMP IN+_C TO D-AMP SECTION (2/2) FAN_GND IC5500 R5304...
Page 106
SA-PT350E / SA-PT350EB / SA-PT350EG SCHEMATIC DIAGRAM - 12 D-AMP CIRCUIT :+B SIGNAL LINE :-B SIGNAL LINE :MAIN SIGNAL LINE C5445 C5450 IC5000 C1AA00000755 ZJ5400 AUDIO DIGITAL POWER AMP FR_+ C5030 C5008 C5009 C5007 C5024 C5025 C5001 C5002 R5000 C5006...
Page 107
SA-PT350E / SA-PT350EB / SA-PT350EG SCHEMATIC DIAGRAM - 13 SMPS CIRCUIT :+B SIGNAL LINE :-B SIGNAL LINE Q5861 - Q5862 B1ABCF000176 TRANSFORMER TEMP DETECT DCDET CN5801 +30V_SENSE +30V_SENSE FAN_18V D5801 +30V_SENSE B0HBSM000043 D-AMP CIRCUIT C5832 (H5500) -30V_SENSE IN SCHEMATIC -30V_SENSE...
Page 109
SA-PT350E / SA-PT350EB / SA-PT350EG 20.4. Scart Circuit SCHEMATIC DIAGRAM - 15 SCART CIRCUIT :+B SIGNAL LINE : MAIN SIGNAL LINE : DVD VIDEO SIGNAL LINE :FM SIGNAL LINE Q1003 Q1004 2SD0601AHL UNR211H00L REGULATOR SWITCH FUNC_SW L1001 D1002 J0JBC0000015 B0BC01200019...
Page 119
SA-PT350E / SA-PT350EB / SA-PT350EG 22 Basic Troubleshooting Guide 22.1. Basic Troubleshooting Guide for Traverse Unit (DVD Module P.C.B) Problems Checking Points Checking Components 1) Distorted picture or a) Check SDRAM address, IC8051 abnormal sound is head data bus, CLK and other...
Page 120
SA-PT350E / SA-PT350EB / SA-PT350EG 22.2. Basic Troubleshooting Guide for HDMI AV output Problems Checking Points Checking Components 1) TV does not have any 1) Check setting of the set *This year HDMI always ON. No need check Setup display. Set FL display in Setup Menu whether the Menu.
Page 121
SA-PT350E / SA-PT350EB / SA-PT350EG Problems Checking Points Checking Components 2) When switching the 1) Supply for Up-Con LB3902 video output mode from (IC3901) 480P to 720p/1080i, TV - Pin 9, 124 2) GND for Up-Con display becomes blank - Pin 7, 125...
Page 122
JK2001 (VOUT/CBOUT/CROUT/CYOUT) IC2801 SC-PT350W SIMPLIFIED BLOCK VIDEO IC CB/CR/Y COMPOSITE (C/Y/CR/CB/PY) IC1101 SCART SCART IC TERMINAL JK1001 (DVD_MUTE/DVD_STAT/ VMUTE IC2802 IC1102 DVD_CMD/DVD_CLK) FL6901 FL_IC_IN P1~P17 Swicth IC Swicth IC FL_IC_CLK IC6901 (RGB_H) YC_H FL Driver IC FL_IC_STB (VIDEO_ IC2004 IC2003 MUTE/ G1~G10 RDS IC...
Page 123
SC-PT350W POWER BLOCK D+5V A+5V LIMITER -13V REGULATOR DVD_ADAC+5V DVD_2R7 REGULATOR IC2903 +18V SW+5V REGULATOR DC-DC C - + C - + CONVERTER RF+5V IC2900 IC2901 C - + C - + C - + DC-DC C - + CONVERTER TU+9V REGULATOR F+/F-...
Page 125
SA-PT350E / SA-PT350EB / SA-PT350EG 24 Terminal Function of ICs 24.1. IC2001 (C2CBYY000418): Terminal Name Function System Control IC 55 VMUTE_MAIN No connection 56 POS_SW Position Sensor Terminal Name Function 57 NC No Connection 58 NC No Connection 1 TRAY_CLOSE...
Page 130
SA-PT350E / SA-PT350EB / SA-PT350EG 26 Replacement Parts List · Important safety notice: Components identified by mark have special characteristics important for safety purpose. Furthermore, special parts which have purposes of fire-retardant (resistors), high-quality sound (capacitors), low-noise (resistors), etc. are used.
Page 131
SA-PT350E / SA-PT350EB / SA-PT350EG 26.1. Component Parts List Ref. Part No. Part Name & Description Remarks RGQ0395-K1 TRAY Ref. Part No. Part Name & Description Remarks RME0350 CHANGE LEVER SPRING RME0351 LOCK LEVER SPRING CABINET AND CHASSIS RME0353 TRAY SLIDER SPRING...
Page 132
SA-PT350E / SA-PT350EB / SA-PT350EG Ref. Part No. Part Name & Description Remarks Ref. Part No. Part Name & Description Remarks IC8251 C0GBG0000048 IC MOTOR DRIVE Q5722 B1ABCF000176 TRANSISTOR IC8421 C0FBBK000050 IC AUDIO DAC Q5802 B1ABCF000176 TRANSISTOR IC8601 C0EBA0000029 IC RESET...
Page 133
SA-PT350E / SA-PT350EB / SA-PT350EG Ref. Part No. Part Name & Description Remarks Ref. Part No. Part Name & Description Remarks D5644 B0ACCK000005 DIODE CN2003 K1MN17AA0004 17P CONNECTOR D5645 B0ACCK000005 DIODE CN2004 K1YZ11000002 11P CABLE HOLDER D5701 B0FBAR000041 DIODE CN2006...
Page 134
SA-PT350E / SA-PT350EB / SA-PT350EG Ref. Part No. Part Name & Description Remarks Ref. Part No. Part Name & Description Remarks L5201 G0B9R5K00003 LINE CHOKE COIL LB9002 J0JHC0000034 CHIP FERRITE BEAD L5300 G0A150L00003 LINE CHOKE COIL L5301 G0B9R5K00003 LINE CHOKE COIL...
Page 135
SA-PT350E / SA-PT350EB / SA-PT350EG Ref. Part No. Part Name & Description Remarks Ref. Part No. Part Name & Description Remarks R2022 ERJ3GEYJ221V 220 1/16W RPGX1722 PACKING CASE [M]EG R2023 ERJ3GEYJ221V 220 1/16W RPGX1723 PACKING CASE [M]EB R2024 ERJ3GEYJ102V 1K 1/16W...
Page 136
SA-PT350E / SA-PT350EB / SA-PT350EG Ref. Part No. Part Name & Description Remarks Ref. Part No. Part Name & Description Remarks R2191 ERJ3GEYJ562V 5.6K 1/16W R2528 ERJ3GEYJ273V 27K 1/16W R2192 ERJ3GEYJ332V 3.3K 1/16W R2600 ERJ3GEYJ392V 3.9K 1/16W R2196 ERJ3GEYJ222V 2.2K 1/16W...
Page 137
SA-PT350E / SA-PT350EB / SA-PT350EG Ref. Part No. Part Name & Description Remarks Ref. Part No. Part Name & Description Remarks R2927 ERX2SJ1R5E 1.5 1/32W R5023 ERJ3GEYJ122V 1.2K 1/16W R2929 ERJ3GEYJ151V 150 1/16W R5030 ERJ3GEYJ562V 5.6K 1/16W R2930 ERJ3GEYJ472V 4.7K 1/16W...
Page 138
SA-PT350E / SA-PT350EB / SA-PT350EG Ref. Part No. Part Name & Description Remarks Ref. Part No. Part Name & Description Remarks R5803 ERJ3GEYJ561V 560 1/16W R8231 ERJ2GEJ223X 22K 1/32W R5804 ERJ6RBD433V 43K 1/10W R8232 ERJ2GEJ752X 7.5K 1/32W R5805 ERJ3RBD222V 2.2K 1/16W...
Page 139
SA-PT350E / SA-PT350EB / SA-PT350EG Ref. Part No. Part Name & Description Remarks Ref. Part No. Part Name & Description Remarks R9017 ERJ2GE0R00X 0 1/32W K8003 ERJ2GE0R00X CHIP RESISTOR [M]E R9022 ERJ2GE0R00X 0 1/32W K8007 ERJ2GE0R00X CHIP RESISTOR [M]EB/E R9023...
Page 140
SA-PT350E / SA-PT350EB / SA-PT350EG Ref. Part No. Part Name & Description Remarks Ref. Part No. Part Name & Description Remarks W2642 ERJ6GEY0R00V CHIP RESISTOR C1021 ECEA0JKS101B 100 6.3V W2643 ERJ6GEY0R00V CHIP RESISTOR C1022 ECEA0JKS101B 100 6.3V W2647 ERJ6GEY0R00V CHIP RESISTOR...
Page 141
SA-PT350E / SA-PT350EB / SA-PT350EG Ref. Part No. Part Name & Description Remarks Ref. Part No. Part Name & Description Remarks C2203 ECJ1VB1A105K 1 10V C2604 ECEA1HKA100B 10 50V C2204 ECJ1VB1C273K 0.027 16V C2605 ECJ1VB1H222K 2200P 50V C2206 ECJ1VB1H152K 1500P 50V...
Page 142
SA-PT350E / SA-PT350EB / SA-PT350EG Ref. Part No. Part Name & Description Remarks Ref. Part No. Part Name & Description Remarks C2932 ECEA1CKA101B 100 16V C5020 ECJ1VB1H104K 0.1 50V C2933 ECA0JM101B 100 6.3V C5021 ECJ1VB1H104K 0.1 50V C2937 ECJ1VB1H103K 0.01 50V...
Page 143
SA-PT350E / SA-PT350EB / SA-PT350EG Ref. Part No. Part Name & Description Remarks Ref. Part No. Part Name & Description Remarks C5522 ECJ1VB1H104K 0.1 50V C6801 ECJ1VB1H104K 0.1 50V C5523 ECJ1VB1H104K 0.1 50V C6805 ECJ1VC1H101K 100P 50V C5524 ECJ1VB1H104K 0.1 50V...
Page 144
SA-PT350E / SA-PT350EB / SA-PT350EG Ref. Part No. Part Name & Description Remarks Ref. Part No. Part Name & Description Remarks C8252 ECJ0EF1C104Z 0.1 16V C8572 ECJ0EF1C104Z 0.1 16V C8253 ECJ0EF1C104Z 0.1 16V C8601 ECJ0EF1C104Z 0.1 16V C8255 F2G1C220A037 22 16V...