COOLING UNIT ............................................................................................................................................. 22
REPLACEMENT PARTS LIST ....................................................................................................................... 24
SERVICE MANUAL
REFRIGERATOR-FREEZER
MODELS
SJ-2047-GY/WH/BE
SJ-2050-GY/BL/WH/GR/BE
SJ-2060-GY/WH/BE
In the interests of user-safety (Required by safety regulations in some
countries) the set should be restored to its original condition and only
parts identical to those specified should be used.
SJ-2060 SERVICE MANUAL S6010SE60APSW REFRIGERATOR-FREEZER MODELS SJ-2047-GY/WH/BE SJ-2050-GY/BL/WH/GR/BE SJ-2060-GY/WH/BE In the interests of user-safety (Required by safety regulations in some countries) the set should be restored to its original condition and only parts identical to those specified should be used.
SJ-2047 SJ-2050 SJ-2060 CAUTIONS AND INFORMATIONS In case of following troubles, the cause is not related with the failure of refrigerator. Please mention the correct way to the customer for the use of refrigerator when the repairing. 1. Some foods freezed in the refrigerator compartment. Do not place food directly in front of cold air outlet.
SJ-2047 SJ-2050 SJ-2060 DESIGNATION OF VARIOUS PARTS The names are the denominations used in the REPLACEMENT PARTS LIST. 1. Freezer light(Lamp) 2. Freezer fan 3. Freezer shelf(F shelf ass'y) 4. Ice cube maker 5. Ice cube box(Ice storage box) 6. Freezer temp. control knob 7.
SJ-2047 SJ-2050 SJ-2060 WIRING DIAGRAM Be sure to replace the electrical parts with specified ones for maintaining the safety and performance of the set. : GRAY : BROWN : ORANGE : YELLOW : RED CONNECTED IN TERMINAL BOX : PINK : BLUE CONNECTOR : BLACK...
Page 7
SJ-2047 SJ-2050 SJ-2060 CABINET ASS’Y F LAMP BOX ASS’Y LAMP SOCKET BR-1 F-LAMP(10W) E. V. COVER ASS’Y LEAD EV-COVER ASS’Y GY-1 F-FAN MOTOR OR-1 BR-2 F-THERMOSTAT DEF. THERMO. ASS’Y BL-1 BK-1 FUSE ASS’Y OR-3 (W-1) DEF. HEATER ASS’Y DOOR SWITCH (OR-1) 3 (PUSH CLOSE) BL-2...
SJ-2047 SJ-2050 SJ-2060 FUNCTIONS 1. ADJUSTABLE TEMPERATURE CONTROL (1) Temperature control of freezer Thermostat (senses freezer temperature) operates on ON/OFF switchover to control the compressor and cool air circulating fan (F-fan motor) , and allows the freezer temperature to keep at a suitable temperature. However adjust the freezer temp.
Page 9
SJ-2047 SJ-2050 SJ-2060 2. DEFROSTING (1) No defrosting operation is necessary (2) Where is melted frost brought No defrosting operation is necessary. 1. Melted frost is brought into the evaporating As this machine is so designed that a built-in pan at the bottom of the set and is evaporated evaporator cools air and a fan circulates cooled here by the heat of sub condenser.
Page 10
SJ-2047 SJ-2050 SJ-2060 (4) As a reference to determine the causes of trouble, malfunction and phenomena are described below. Refer to the following when repairing. 1. Disconnection of defrost heater As off-cycle defrosting is performed, the defrosting time is extremely prolonged. Each time defrosting is started, the freezer temperature rises and a portion of ice and stored foods are melted.
SJ-2047 SJ-2050 SJ-2060 ASSEMBLING PROCEDURES OF MAIN PARTS AND CAUTIONS CAUTION: DISCONNECT THE UNIT FROM THE POWER SUPPLY BEFORE ANY REPAIRING. 1. R-CONTROL COV. ASSEMBLY Damper thermo. RA sealer A R air guider A Defrost timer RA sealer D RA sealer C R fan thermo.
Page 12
SJ-2047 SJ-2050 SJ-2060 (2) Sticking of sealers to R air guider A. [Front side] [Back side] OVERLAP 15mm RA sealer A OVERLAP 15mm Dial sealer RA sealer D A sealer RA sealer A RA sealer B RA sealer C RA sealer A RA sealer A thermo.
Page 13
SJ-2047 SJ-2050 SJ-2060 2. R LAMP BOX ASSEMBLY R fan motor holder B R-fan motor Propeller fan 80 R fan motor holder A Lamp socket (with lead wires for R-fan motor) Fan clamp Lamp 15W Warning label R lamp box Figure A-5 (1) Fixing of Lamp and Lamp socket.
Page 14
SJ-2047 SJ-2050 SJ-2060 (2) Fixing of R-fan motor and Fan R fan motor holder B (2)-1 Set R-fan motor holder A to R lamp box by R fan motor holder A tapping screw. Propeller fan 80 R-fan motor (2)-2 Set R-fan motor to R fan motor holder A by machine screw.
Page 15
SJ-2047 SJ-2050 SJ-2060 3. E.V COVER ASSEMBLY Motor Fan motor U-sealer cushion handle Propeller Fan 100 Fan motor E.V cover sealer A holder B Fan clamp Defrost thermo. ass’y L-band C E.V cover Lead E.V-cover Fan motor ass’y holder A E.V cover sealer B E.V cover sealer C Fuse ass’y...
Page 16
SJ-2047 SJ-2050 SJ-2060 (2) Fixing of Fan motor and Fan (2)-1 Stick U-sealer handle to Fan motor holder A. Fan motor holder A 0 1mm U-sealer handle U-sealer handle SEC. C-C Figure A-13 (2)-2 Insert the terminals of Lead EV-cover ass'y to R-fan motor.
Page 17
SJ-2047 SJ-2050 SJ-2060 (3) Setting of Fan motor ass'y , Defrost thermo. ass'y and Fuse ass'y Tapping screw E.V cover E.V cover sealer C L-band C Lead E.V- Defrost cover ass’y thermo. ass’y Tapping more than more than Alminum screw 3.5mm 3.5mm tape...
Page 18
SJ-2047 SJ-2050 SJ-2060 (5) Setting of F-thermostat (5)-1 Form capillary tube of F-thermostat. R10mm R10mm Note • Bending radius of capillary tube should be R5mm to R10mm. 13mm 42mm 20mm Figure A-19 (5)-2 Insert terminal of Lead EV-cover ass'y. (front side) BROWN (back side) Figure A-20...
SJ-2047 SJ-2050 SJ-2060 MODIFICATION PROCEDURE OF THE DOOR OPEN SIDE It is possible to change the door to left side opening. To modify the door to left side opening, REFRIGERATOR HINGE KITS (for left side opening) SJ-L838LD (optional item )is necessary. These kits are used to change the refrigerator doors from right to left opening.
Page 20
SJ-2047 SJ-2050 SJ-2060 Replacing Handles and Door Parts 1. Remove Screw caps and Screws on each door handle, then remove the handles. Flatten the surface of the screw holes using the handle of a screwdriver, etc., then mount 3 units of F (Door hole covers) on each door.
Page 21
SJ-2047 SJ-2050 SJ-2060 Mounting the Door/Finishing 1. Apply Silicon grease H to the shaded portion of part A(Bottom hinge L) and attach it to the left side. 2. Insert Lower door and fit Center hinge vertically inverted. Remove washer if installed. Tighten the screws temporarily. 3.
SJ-2047 SJ-2050 SJ-2060 COOLING UNIT Mark: Refrigerant flow Mark: Brazing portion Hot pipe L Hot pipe Hot pipe R (Side condenser) (DP-condenser) (Side condenser) Evaporator Back condenser Suction pipe Sub. condenser Compressor Capillary tube Dryer Figure C-1. Cooling unit...
Page 23
SJ-2047 SJ-2050 SJ-2060 Dryer Capillary tube Charge pipe Hot pipe Evaporator Charge pipe Compressor Suction pipe S.P. connector Sub. condenser Back condenser Figure C-2. Location Suction pipe to Sub. condenser to S.P connector Back condenser Charge pipe L to Back condenser to Compressor’s process tube Pinch Point hot pipe...
SJ-2047 SJ-2050 SJ-2060 REPLACEMENT PARTS LIST(SJ-2047-GY/WH/BE) REF. NO. PART NO. DESCRIPTION Q'TY CODE 2047-GY 2047-WH 2047-BE ELECTRIC PARTS RTHM-A097CBEZ F-thermostat RSTT-A144CBE0 Starting relay QSWTDA035CBE0 Defrost timer PDMP-A048CBEZ Damper thermo FTHM-A028CBKZ Defrost thermo.assembly RMOTRA040CBE0 Fan motor QSOCAA074CBEZ Lamp socket RLMP-A012CBE0 Lamp...
Page 25
SJ-2047 SJ-2050 SJ-2060 REF. NO. PART NO. DESCRIPTION Q'TY CODE 2047-GY 2047-WH 2047-BE 2-65 PSEL-B209CBE0 U-sealer handle 2-66 PSHEMA132CBP0 Heater cover AL 2-67 LPLTMA570CBPZ Drain support AL 2-69 PSEL-B847CBEZ E.v cover sealer D 2-71 PSEL-A552CBE0 Dial sealer 2-72 PSEL-B841CBEZ Ra sealer A 2-73 PSEL-B842CBEZ Ra sealer B...
Page 26
SJ-2047 SJ-2050 SJ-2060 REF. NO. PART NO. DESCRIPTION Q'TY CODE 2047-GY 2047-WH 2047-BE ATTACHMENT PARTS UPOK-A166CBRA Bottle pocket UPOK-A168CBRA F door pocket UPOK-A165CBRA R door pocket UTNA-A282CBFB Egg tray FSRA-A193CBYZ Ice cube maker FSRA-A194CBKZ F shelf assembly 5-13 HGRL-A178CBFA Ventilating grille 5-13 HGRL-A178CBFC Ventilating grille...
Page 27
SJ-2047 SJ-2050 SJ-2060 REPLACEMENT PARTS LIST(SJ-2050-GY/BL/WH/GR/BE) REF. NO. PART NO. DESCRIPTION Q'TY CODE 2050-GY 2050-BL 2050-WH 2050-GR 2050-BE ELECTRIC PARTS RTHM-A097CBEZ F-thermostat RSTT-A144CBE0 Starting relay QSWTDA035CBE0 Defrost timer PDMP-A046CBEZ Damper thermo FTHM-A028CBKZ Defrost thermo.assembly RMOTRA040CBE0 Fan motor QSOCAA074CBEZ Lamp socket RLMP-A012CBE0 Lamp QACC-A121CBE0...
Page 28
SJ-2047 SJ-2050 SJ-2060 REF. NO. PART NO. DESCRIPTION Q'TY CODE 2050-GY 2050-BL 2050-WH 2050-GR 2050-BE 2-59 PCOV-A264CBEZ F lamp box cover 2-63 LHLD-A484CBFA Fan motor holder B 2-64 LHLD-A485CBFA Fan motor holder A 2-65 PSEL-B209CBE0 U-sealer handle 2-66 PSHEMA132CBP0 Heater cover AL 2-67 LPLTMA570CBPZ Drain support AL...
Page 29
SJ-2047 SJ-2050 SJ-2060 REF. NO. PART NO. DESCRIPTION Q'TY CODE 2050-GY 2050-BL 2050-WH 2050-GR 2050-BE 3-19 JHNDPA118CBFA Door handle RL 3-19 JHNDPA118CBFB Door handle RL 3-19 JHNDPA118CBFC Door handle RL 3-19 JHNDPA118CBFE Door handle RL 3-19 JHNDPA118CBFF Door handle RL 3-25 FBDGDA280CBYZ Badge assembly...
Page 30
SJ-2047 SJ-2050 SJ-2060 REF. NO. PART NO. DESCRIPTION Q'TY CODE 2050-GY 2050-BL 2050-WH 2050-GR 2050-BE MISCELLANEOUS 90-2 TLAB-A092CBR0 Lamp label 90-3 SPAKCI798YDEZ Packing case 90-5 TLAB-A614CBE0 Case label GY 90-5 TLAB-A615CBE0 Case label BE 90-5 TLAB-A616CBE0 Case label BL 90-5 TLAB-A617CBE0 Case label WH 90-5...
Page 31
SJ-2047 SJ-2050 SJ-2060 REPLACEMENT PARTS LIST(SJ-2060-GY/WH/BE) REF. NO. PART NO. DESCRIPTION Q'TY CODE 2060-GY 2060-WH 2060-BE ELECTRIC PARTS RTHM-A097CBEZ F-thermostat RSTT-A144CBE0 Starting relay QSWTDA035CBE0 Defrost timer PDMP-A046CBEZ Damper thermo FTHM-A028CBKZ Defrost thermo.assembly RMOTRA040CBE0 Fan motor QSOCAA074CBEZ Lamp socket RLMP-A012CBE0 Lamp QACC-A121CBE0 Source cord 1-10...
Page 32
SJ-2047 SJ-2050 SJ-2060 REF. NO. PART NO. DESCRIPTION Q'TY CODE 2060-GY 2060-WH 2060-BE 2-65 PSEL-B209CBE0 U-sealer handle 2-66 PSHEMA132CBP0 Heater cover AL 2-67 LPLTMA570CBPZ Drain support AL 2-69 PSEL-B847CBEZ E.v cover sealer D 2-71 PSEL-A552CBE0 Dial sealer 2-72 PSEL-B841CBEZ Ra sealer A 2-73 PSEL-B842CBEZ Ra sealer B...
Page 33
SJ-2047 SJ-2050 SJ-2060 REF. NO. PART NO. DESCRIPTION Q'TY CODE 2060-GY 2060-WH 2060-BE ATTACHMENT PARTS UPOK-A166CBRA Bottle pocket UPOK-A168CBRA F door pocket UPOK-A165CBRA R door pocket UTNA-A282CBFB Egg tray FSRA-A193CBYZ Ice cube maker FSRA-A194CBKZ F shelf assembly 5-13 HGRL-A178CBFA Ventilating grille 5-13 HGRL-A178CBFC Ventilating grille...