Page 1
Internal Use Only OLED TV SERVICE MANUAL CHASSIS : ED64B MODEL : OLED55/65B6* OLED55/65B6*-Z CAUTION BEFORE SERVICING THE CHASSIS, READ THE SAFETY PRECAUTIONS IN THIS MANUAL. P/NO : MFL69570101 (1604-REV00)
Page 41
TROUBLE SHOOTING GUIDE LGE Internal Use Only Copyright ⓒ 2016 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 42
Circuit noise, mechanical noise F. Exterior error Exterior defect First of all, Check whether there is SVC Bulletin in GSCS System for these model. LGE Internal Use Only Copyright ⓒ 2016 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 43
Always check & record S/W Version and White Replace Main Board Re-enter White Balance value Balance value before replacing the Main Board LGE Internal Use Only Copyright ⓒ 2016 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 44
Power Normal replace Board ( 13V or 24V) voltage? No audio MAIN B/D Replace Power Board and repair parts LGE Internal Use Only Copyright ⓒ 2016 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 45
2. Install Booster S/W Upgrade Normal Contact with signal distributor or broadcaster (Cable or Air) Picture? Normal Picture? Replace Main B/D Close Close LGE Internal Use Only Copyright ⓒ 2016 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 46
Request repair for external device/cable Check external External device HDMI device and Replace Main/T-con B/D /Cable error cable normal LGE Internal Use Only Copyright ⓒ 2016 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 47
(Check normal operation of Main /T-con External Input, Component, normal? RGB and HDMI/DVI by connecting Jig, pattern Generator ,Set-top Box etc. LGE Internal Use Only Copyright ⓒ 2016 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 48
Measure voltage of each output of Power B/D Normal? ※ Normal Replace Main B/D voltage? Close Normal Check ST-BY 3.5V voltage? ☞A9 Replace Power B/D Replace Power LGE Internal Use Only Copyright ⓒ 2016 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 49
Power off by S/W Download "POWER_OFF_BY_UNKNOWN" Power off by unknown status except listed case Abnormal "POWER_OFF_BY_CPU_ABN" Power off by CPU Abnormal LGE Internal Use Only Copyright ⓒ 2016 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 50
Speaker off Board Cancel OFF Replace Power Board and repair parts Check Replace MAIN Board Disconnection Speaker disconnection Replace Speaker LGE Internal Use Only Copyright ⓒ 2016 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 51
Connect and check Normal External Input other external audio? signal error) device Check and fix external device Check and fix external device LGE Internal Use Only Copyright ⓒ 2016 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 52
(Power B/D don’t have problem) If R/C operate, Normal Close Explain the customer operating? cause is interference from light in room. Replace R/C LGE Internal Use Only Copyright ⓒ 2016 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 53
Down load the Firmware •If you conduct the loop at 3times, * INSTART MENU12.RF remote control Test3. change the MR15R. Firmware download LGE Internal Use Only Copyright ⓒ 2016 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 54
Main B/D ☞A15 Check & Repair Close Wifi cable connection ☞A4 Wi-Fi Mac value Close is “NG”? Change the Wifi assy LGE Internal Use Only Copyright ⓒ 2016 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 55
- S/W Version HDMI/ Check and fix DVI, Optical Replace Main B/D Fix in external device/cable Recognition error accordance with technical information LGE Internal Use Only Copyright ⓒ 2016 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 56
“Part related to nose” in the Owner’s then proceed as shown in the solution manual Manual. (For models without any fix information, provide the description) LGE Internal Use Only Copyright ⓒ 2016 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 57
Zoom part with Module Replace module exterior damage damage Cabinet Replace cabinet damage Remote Replace remote control control damage Stand Replace stand dent LGE Internal Use Only Copyright ⓒ 2016 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 58
A. Video error_ Color error condition <Appendix> Exchange Module (1) A-1/2 Defected Type caused by T-Con/ Exchange Module (2) A-2/2 Inverter/ Module LGE Internal Use Only Copyright ⓒ 2016 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 59
Remote control operation checking method D. Function error Motion Remote operation checking method Wifi operation checking method LGE Internal Use Only Copyright ⓒ 2016 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 60
After Remove the Rear Cover, turning on the power and check with the naked eye, Whetehr you can see light from locations. LGE Internal Use Only Copyright ⓒ 2016 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 61
3. After recording the R, G, B (GAIN, Cut) value of Color Temp (Cool/Medium/Warm), re-enter the value after replacing the MAIN BOARD. LGE Internal Use Only Copyright ⓒ 2016 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 62
Content date All Settings Channels Channel Tuning When the signal is strong, use the attenuator (-10dB, -15dB, -20dB etc.) LGE Internal Use Only Copyright ⓒ 2016 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 63
Version checking method Content date 1. Checking method for remote control for adjustment Version Press the IN-START with the remote control for adjustment LGE Internal Use Only Copyright ⓒ 2016 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 64
1. Check the signal strength or check whether the screen is normal when the external device is connected. 2. After measuring each voltage from power supply, finally replace the MAIN BOARD. LGE Internal Use Only Copyright ⓒ 2016 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 65
Revised Content Connection diagram date As the part connecting to the external input, check the screen condition by signal LGE Internal Use Only Copyright ⓒ 2016 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 66
Content Check Link Cable (EPI) reconnection condition date Check the contact condition of the Link Cable, especially dust or mis insertion. LGE Internal Use Only Copyright ⓒ 2016 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 67
Brightness difference Line Dim Crosstalk Press damage Crosstalk Un-repairable Cases In this case please exchange the module. Burnt A – 1/2 LGE Internal Use Only Copyright ⓒ 2016 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 68
Green Noise on power on/off time Line Defect Un-repairable Cases In this case please exchange the module. Mura A – 2/2 LGE Internal Use Only Copyright ⓒ 2016 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 69
B. Power error _No power symptom date Revised Content Check front display Logo date ST-BY condition: On or Off Power ON condition: Turn Off LGE Internal Use Only Copyright ⓒ 2016 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 70
Error Established B. Power error _No power symptom date Revised Check power input voltage Content date Check the DC 24V, 13V LGE Internal Use Only Copyright ⓒ 2016 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 71
1. Press the IN-START button of the remote control for adjustment 2. Check the entry into adjustment item 3(power On/Off Status) LGE Internal Use Only Copyright ⓒ 2016 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 72
1. Press the Setting button on the remote control 2. Select the Sound function of the Menu 3. Select the Sound Out 4. Select TV Speaker LGE Internal Use Only Copyright ⓒ 2016 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 73
③ Connect the tester RX1 to the speaker terminal and if you hear the Chik Chik sound when you touch the GND and output terminal, the speaker is normal. LGE Internal Use Only Copyright ⓒ 2016 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 74
Checking order 1, 2. Check IR cable condition between IR & Main board. Check the st-by 3.5V on the terminal 4 LGE Internal Use Only Copyright ⓒ 2016 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 75
Check WIFI Combo cable condition between WIFI Combo Assy & Main board. Check the st-by 3.5V P4102 on the terminal 4 Check the 3.5V_WIFI P4101 on the terminal 8 LGE Internal Use Only Copyright ⓒ 2016 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 76
Checking order 1, 2. Check Wifi cable condition between Wifi assy & Main board. Check the 3.3V on the terminal 8. LGE Internal Use Only Copyright ⓒ 2016 LG Electronics. Inc. All right reserved. Only for training and service purposes...