Sealey SA88.V3 Instructions

Thank you for purchasing a Sealey product. Manufactured to a high standard this product will, if used according to these instructions
and properly maintained, give you years of trouble free performance.
IMPORTANT: PLEASE READ THESE INSTRUCTIONS CAREFULLY. NOTE THE SAFE OPERATIONAL REQUIREMENTS, WARNINGS & CAUTIONS.
USE THE PRODUCT CORRECTLY AND WITH CARE FOR THE PURPOSE FOR WHICH IT IS INTENDED. FAILURE TO DO SO MAY CAUSE
DAMAGE AND/OR PERSONAL INJURY, AND WILL INVALIDATE THE WARRANTY. PLEASE KEEP INSTRUCTIONS SAFE FOR FUTURE USE.
1. SAFETY INSTRUCTIONS
3 Familiarise yourself with the application and limitations of the air hose reel, as well as the specific hazards.
p WARNING! Disconnect the air hose reel from the air supply before changing accessories, servicing or performing any maintenance.
3 Maintain the air hose reel in good condition (use an authorised service agent).
3 Replace or repair damaged parts. Use recommended parts only. Unauthorised parts may be dangerous and will invalidate the warranty.
3 Locate and fix the air hose reel in a suitable working area. Do not position the hose in direct sun light, or in areas of extreme heat or
cold. Ensure there is adequate lighting.
p WARNING! Ensure maximum air pressure is not exceeded.
3 Keep extended air hose away from heat, oil and sharp edges. Check hose for wear before each use, and ensure all connections are secure.
3 Keep the unwound air hose at a safe distance from the working area and free from wet, damp, oily surfaces.
p WARNING! Always wear approved eye or face protection when operating the air hose reel.
3 Maintain correct balance and footing. Ensure the floor is not slippery and wear non-slip shoes.
3 Remove ill fitting clothing. Remove ties, watches, rings, and other loose jewellery and contain and/or tie back long hair.
3 Keep children and unauthorised persons away from the working area.
7 DO NOT operate the air hose reel if any parts are damaged or missing as this may cause failure and/or personal injury.
7 DO NOT exceed the rated capacity of the air hose reel.
7 DO NOT use the air hose reel for any purpose other than that for which it is designed.
7 DO NOT operate the air hose reel when you are tired, under the influence of alcohol, drugs or intoxicating medication.
7 DO NOT direct air from the air hose at yourself or others.
3 When not in use ensure the air supply is turned off and tools disconnected. Disconnect from the air supply and retract the hose into case.
p WARNING! DO NOT dismantle the hose reel casing, or attempt to remove the screws and covers on the sides. To do so may result in
damage to the appliance and/or personal injury and will invalidate the warranty. Internal maintenance, which will require the opening of the
casing, must only be undertaken by an authorised service agent.
2. INTRODUCTION & SPECIFICATION
The SA88.V3 has a hard wearing composite casing with retracting air hose reel. Free-running operation enabling easy access to locations within
the extended air hose range. The reel comes complete with an attachment bracket for wall or ceiling mounting.
MODEL NO. . . . . . . . . . . . . . . . .SA88.V3
Hose length . . . . . . . . . . . . . . . . . . . .20m
Hose bore . . . . . . . . . . . . . . . . . . . .10mm
3. INSTALLATION
WARNING! Ensure the hose is disconnected from the air supply. Do not position the hose in direct sun light or in areas of
p
extreme heat or cold.
p
3.1 Attach the carrying handle to the reel casing just above the hose mouth using the two self tapping screws provided,
Mounting the reel.
3.2
3.3 Due to the way the retractable hose operates the reel should only be mounted in one of the four positions shown below. The
standard bracket supplied (BU100) will enable you to mount in positions 1 & 2. If wish to mount in positions 3 or 4 you will need to
purchase the optional bracket (BB100).
Do not mount the reel more than 4.8M above the ground. The maximum weight of any air tool attached to the end of the hose
should not exceed 2kg.
3.4 Ensure the wall, ceiling or other structure, to which the air hose is to be fixed is of sound construction and that the securing point will
hold the working strain of the hose when in use.
1
. WALL MOUNT (BU100)
( Up to 1.8m above ground.)
2
. OVERHEAD MOUNT (BU100)
( Up to 4.5m above ground.)
INSTRUCTIONS FOR:
RETRACTING AIR HOSE REEL
Model No: SA88.V3
Maximum pressure . . . . . . . . . . . . .290psi
Hose type . . . . . . . . . . . . . . . . . . . . .PVC
Inlet - Outlet Ø . . . . . . . . . .3/8” - 1/4”BSP
3
. FLOOR / BENCH MOUNT
(BB100)
4
. HIGH WALL MOUNT (BB100)
( Between heights 1.8 to 4.5M )
SA88.V3 - 1 - 080804