CAUTION Danger of explosion if battery is incorrectly replaced. Replaced only with the same or equivalent type recommended by the manufacturer. Discord used batteries according to the manufacturer's instructions. MVH-350BT/XMEW5...
2. Before disassembling the unit, be sure to turn off the power. Unplugging and plugging the connectors during power-on mode may damage the ICs inside the unit. 3. Be careful in handling ICs. Some ICs such as MOS type are so fr agile that the y can be damaged b y electrostatic induction. MVH-350BT/XMEW5...
Compared with eutectic solders, lead-free solders have higher bond strengths but slower wetting times and higher melting temperatures (hard to melt/easy to harden). The following lead-free solders are available as service parts: Parts numbers of lead-free solder: GYP1006 1.0 in dia. GYP1007 0.6 in dia. GYP1008 0.3 in dia. MVH-350BT/XMEW5...
2. SPECIFICATIONS 2.1 SPECIFICATIONS MVH-350BT/XMEW5, MVH-150UI/XMEW5 General Power source......14.4 V DC (10.8 V to 15.1 V allowable) USB standard specification Grounding system ....Negative type ........USB 2.0 full speed Maximum current consumption Maximum current supply ........10.0 A ........1A Backup current ....4.0 mA or less USB Class ......MSC (Mass Storage Class)
Page 7
Equalizer (5-Band Graphic Equalizer): Frequency....80 Hz/250 Hz/800 Hz/ 2.5 kHz/8 kHz Equalization range ..±12 dB (2 dB step) Subwoofer (mono): Frequency....50 Hz/63 Hz/80 Hz/100 Hz/ 125 Hz/160 Hz/200 Hz Slope......–6 dB/oct, –12 dB/oct Gain ......+6 dB to –24 dB Phase......Normal/Reverse MVH-350BT/XMEW5...
2.2 DISC/CONTENT FORMAT The Bluetooth word mark and logos are owned by the Bluetooth SIG, Inc. and any use of such marks by Pioneer Corporation is under license. Other trademarks and trade names are those of their respective owners. MVH-350BT/XMEW5...
Distortion Noise Volume too low Volume too high Volume fluctuating Sound interrupted 3.2 PCB LOCATIONS BT Unit Tuner Amp Unit 350BT/XMEW5 355BT/XMES Keyboard Unit A:MVH-350BT/XMEW5 B:MVH-355BT/XMES C:MVH-150UI/XMEW5 D:MVH-155UI/XMES E:MVH-155UI/XMES1 F:MVH-159UI/XMID Unit Number QWM3482(A) Unit Number QWM3483(B) Unit Number QWM3477(C) Unit Number...
In case of the above signal, the communication Source keys with Grille microcomputer may fail. operative If the time interval is not 300 msec, the oscillator may be defective. Source ON SYSPW <- H Pin 8 Completes power-on operation. (After that, proceed to each source operation) MVH-350BT/XMEW5...
There are no Select a list that current. OFF, then to ACC songs in the contains songs. or ON and then current list. connect only NOT FOUND No related Transfer songs to compliant USB songs. the iPod. storage devices. MVH-350BT/XMEW5...
Page 14
Turn the ignition for the switch OFF and Bluetooth module then to ACC or of this unit. If the error message is still displayed after performing the above action, please contact your dealer or an authorized Pioneer Service Station. MVH-350BT/XMEW5...
6. SERVICE MODE 6.1 DISPLAY TEST MODE 1 [How to enter Test mode] Press and hold BUTTON A and "LIST" buttons together, and turn BUP and ACC on. SOURCE LIST BUTTON A PHONE MVH-350BT/XMEW5 PHONE MVH-355BT/XMES iPod MVH-150UI/XMEW5 iPod MVH-155UI/XMES iPod...
The screen gets still when entering this item. On (an initial value or On (state when setting value of default entering test mode) Switching to next display menu) by pressing “ 1 ” + “ 3 ” buttons together. MVH-350BT/XMEW5...
The display is continued until the power supply is turned OFF. If the power supply is turned ON again, the display is not changed. The upgrading using USB is disabled, so it is necessary to write programs in serial Flash using E10A. MVH-350BT/XMEW5...
- Removing the Tuner Amp Unit and the BT Unit (Fig.3) Tuner Amp Unit Disconnect the connector. Remove the two screws. Remove the two screws and then remove the Tuner Amp Unit. Remove the screw and then remove the BT Unit. BT Unit Fig.3 MVH-350BT/XMEW5...
Page 21
1. Attach the button from the front side of the panel. Fig.6 2. Attach the spring to the arm as shown in the figure. The bended tip of the spring is set to this side. Hitch the spring to the groove. Fig.7 MVH-350BT/XMEW5...
The frequency of the clock signal is 600 kHz that is divided by 20th of the oscillation frequency of X601 (12MHz). The clock signal should be 600 kHz(- 25 Hz, + 25 Hz). If the clock signal is out of the range, the X'tal (X601) should be replaced with new one. MVH-350BT/XMEW5...
For the applying amount of lubricants or glue, follow the instructions in this manual. (In the case of no amount instructions,apply as you think it appropriate.) 9.1 EXTERIOR 350BT/XMEW5 150UI/XMEW5 350BT/XMEW5 150UI/XMEW5 355BT/XMES 155UI/XMES 155UI/XMES1 159UI/XMID 355BT/XMES 155UI/XMES 155UI/XMES1 355BT/XMES 159UI/XMID 155UI/XMES 155UI/XMES1 159UI/XMID 350BT/XMEW5 355BT/XMES 159UI/XMID MVH-350BT/XMEW5...
Page 25
14-3 Service Network See Contrast table (2) Contain Box See Contrast table (2) Handle QNC3021 (2) CONTRAST TABLE MVH-350BT/XMEW5, MVH-355BT/XMES, MVH-150UI/XMEW5, MVH-155UI/XMES, MVH-155UI/XMES1 and MVH-159UI/XMID are constructed the same except for the following: Mark Description MVH-350BT/XMEW5 MVH-355BT/XMES MVH-150UI/XMEW5 MVH-155UI/XMES Microphone Assy CPM1083...
Page 27
See Contrast table (2) Screw BPZ20P100FTC Holder QNC3020 Panel QNS3387 Spring CBH2210 (2) CONTRAST TABLE MVH-350BT/XMEW5, MVH-355BT/XMES, MVH-150UI/XMEW5, MVH-155UI/XMES, MVH-155UI/XMES1 and MVH-159UI/XMID are constructed the same except for the following: Mark Description MVH-350BT/XMEW5 MVH-355BT/XMES MVH-150UI/XMEW5 MVH-155UI/XMES Cord Assy QDP3014 CDP1480 QDP3014 CDP1480...
R801 2.2k R805 AUXL R803 SOURCE R806 R807 R804 AUXR NOTE : AUXGND MVH-350BT/XMEW5 Symbol indicates a resistor. MVH-355BT/XMES RGBST/ILMCLR2 No differentiation is made between chip resistors and MVH-150UI/XMEW5 CTF171 discrete resistors. RGBCK/ILMCLR1 US5V USB5V Symbol indicates a capacitor. MVH-155UI/XMES...
Page 29
R812 RGBCK/ILMCLR1 R961 R813 RGBDT/DIMMER 2.2k DIAG MASK C330 Dim off 12.13 V R814 2.2k Q875 KYDT Dim on 8.03 V TPD1052F DPDT LTC043EEB R816 2.2k ROT0 ILMPW B.REM&A.ANT R817 2.2k ROT1 SWVDD L851 IC801 DPDT OUTY TC7SET08FUS1 SWVDD MVH-350BT/XMEW5...
KDT1 S1842 SEG51 KDT0 SOURCE DGND IC1941 GP1UXC14RK REMOTE 5 MHz X1801 CSS1547-A R1942 R1944 L1801 DGND DGND ILLUMINATION only A, C DGND except A, C V1801 CAW2024 SEGMENT LCD LTC014 COLOR2 BLUE only B ILMGND D1952-D1966 : FC-F1608BK-470H5 MVH-350BT/XMEW5...
Page 35
AUX:+2.2 dBs DSENS ILLUMINATION DGND CN1911 CKS6443-A C1911 0.1u/16 LTC014EEB LTC014EEB Q1952 Q1953 ILMGND DGND COLOR1 USB:±0.0 dBs only A USBGND except B D1967-D1981 : FC-1608SXK630D08 Q1951 MVH-350BT/XMEW5 only B MVH-355BT/XMES MVH-150UI/XMEW5 MVH-155UI/XMES ILMCLR MVH-155UI/XMES1 MVH-159UI/XMID ILMGND except B MVH-350BT/XMEW5...
11.3 BT UNIT BT UNIT SIDE A (only A, B) CN971 BT MODULE BT UNIT SIDE B (only A, B) MVH-350BT/XMEW5 MVH-355BT/XMES MVH-150UI/XMEW5 MVH-155UI/XMES MVH-155UI/XMES1 MVH-159UI/XMID MVH-350BT/XMEW5...
The expression of the unit in this manual is shown by u instead of µ. Please do not make a mistake. Circuit Symbol and No. Part No. Circuit Symbol and No. Part No. A:MVH-350BT/XMEW5 IC 551 (A,19,111) IC BD9876EFJ B:MVH-355BT/XMES...
Page 45
R 637 (A,100,90) RS1/16SS473J R 312 (A,99,129) RS1/16SS103J R 401 (A,161,106) RS1/16SS221J R 638 (A,104,92) RS1/16SS473J R 402 (A,161,100) RS1/16SS751J R 639 (A,97,91) RS1/16SS472J R 403 (A,139,104) (A,C,D,E,F) RS1/16SS391J R 640 (A,98,91) RS1/16SS472J (A,139,104) (B) RS1/16SS331J R 643 (A,99,82) RS1/16SS104J MVH-350BT/XMEW5...
Page 46
CKSRYB105K16 R 953 (A,125,115) (C) RS1/16SS153J C 402 (A,155,101) CKSSYB103K16 C 403 (A,152,102) CKSRYB105K10 R 961 (A,127,112) RS1/16SS103J R 962 (A,130,113) RS1/16SS103J C 405 (A,162,101) CKSSYB103K16 R 963 (A,129,112) RS1/16SS105J C 406 (A,160,101) CKSSYB103K16 R 973 (A,90,63) (A,B) RS1/16SS0R0J MVH-350BT/XMEW5...
Page 47
(A,32,114) 4.7 uF CCG1201 C 966 (A,128,112) CKSSYB333K16 C 565 (A,15,107) 4.7 uF CCG1222 C 969 (A,135,113) 22 uF DCH1256 C 601 (A,104,66) CKSSYB104K10 C 973 (A,98,53) (A,B) CCSSCH470J50 C 602 (A,109,65) CKSSYB104K10 C 603 (A,111,65) CKSSYB104K10 C 604 (A,112,65) CKSSYB104K10 MVH-350BT/XMEW5...
Page 48
C 24 (A,7,44) CKSRYB105K10 R 1807 (B,60,31) RS1/10SR473J C 26 (A,27,48) 10 uF CCG1192 R 1808 (B,58,32) RS1/10SR473J C 29 (A,17,45) CKSRYB105K10 R 1823 (B,50,23) RS1/10SR273J C 33 (A,9,54) 10 uF CCG1192 R 1931 (B,43,11) RS1/10SR222J C 34 (A,42,30) CKSRYB105K10 MVH-350BT/XMEW5...
Page 49
Circuit Symbol and No. Part No. C 36 (A,32,40) CKSRYB104K16 C 38 (A,15,46) 10 uF CCG1192 C 39 (A,6,42) 10 uF CCG1192 MVH-350BT/XMEW5...