Table of Contents
Advertisement
Quick Links
Advertisement
Table of Contents
Related Manuals for Electrolux WB6-50
Summary of Contents for Electrolux WB6-50
- Page 1 User manual Washer-extractors WB6–50 01201226/EN original instructions...
-
Page 3: Table Of Contents
Contents Contents 1 . Safety precautions..........................5 Symbols..........................10 Personal protection equipment....................11 Preliminary instructions ......................11 2 Warranty terms and exclusions......................13 3 Ergonomics certification........................14 4 Distributor Letter..........................15 5 Note about the A.C. power .........................16 6 Preparation ............................16 Loading...........................16 Detergents ..........................18 Detergent container .........................19 Maintenance ...........................19 Explanation of accelerometer....................19 7 Control panel ............................19... -
Page 5: Safety Precautions
User manual 1 . Safety precautions This machine should be installed in conformance to the health and safety regulations, and only used in a sufficiently aerated area. Check the instructions before installing or using the machine. CAUTION Before any use, to retire all the parts needed to install the machine put in the drum , please follow these actions 1. - Page 6 User manual CAUTION Before any use, it is compulsory to read the instruction handbook. Users must have learnt how the machine operates. This device must not be installed in places accessible to the public. The machine is only intended for water-wash use. Do not allow minors to use the machine.
- Page 7 User manual IMPORTANT The identification plate is located on the right side near the main switch. Never use the main switch as an emergency stop. Use it only when the machine does not work in progress. Instead of that, use the emergency stop buttons in both sides of the machine.
- Page 8 User manual CAUTION With AIDO(Automatic Inner Door Opening) option, Take care of the disc of the opening system above your head. Risk of cutting with the edge of the disc!! Take care also of the locking system on your side; risk of cutting with the edge of the plate!! CAUTION When you put your hands into the drum, take care of the edge of the outer drum doors...
- Page 9 User manual THINK OF THE ENVIRONMENT! The use and handling of chemical products such as detergent, chlorine, acids, desca- ling agents, etc may create hazards for health and environment ; the following precau- tions should be taken: • Do not breathe the dusts or steam; •...
-
Page 10: Symbols
User manual 1.1 Symbols Caution. Caution, presence of dangerous current. Read the instructions before using the machine. -
Page 11: Personal Protection Equipment
User manual 1.2 Personal protection equipment Given below is a summary table of the Personal Protection Equipment (PPE) to be used during the various phases of the machine’s service life. Phase Protection Safety Gloves Glasses Ear protectors Mask Safety helmet garments footwear Transport... - Page 12 User manual WARNING Risk of the upper door being raised quickly on loading WARNING After the installation, Send back the commissionning form ,signed document, to Elec- trolux to validate the warrantly of the product.
-
Page 13: Warranty Terms And Exclusions
Warranty will be applicable where the customer has used only genuine spare parts and has performed maintenance in accordance with Electrolux Professional user and maintenance documentation made available in paper or elec- tronic format. Electrolux Professional strongly recommends using Electrolux Professional approved cleaning, rinse and descaling agents to obtain optimal results and maintain product efficiency over time. -
Page 14: Ergonomics Certification
User manual 3 Ergonomics certification The human body is designed for movement and activity but physical stress injuries as a result of static and repetitive movements or unfavorable working postures may occur. The ergonomic features of our product, the ones which may influence your physical and cognitive interaction with it, have been assessed and certified. -
Page 15: Distributor Letter
User manual 4 Distributor Letter Chemical System Responsibility Disclaimer The following policy should be considered and understood as a warranty/disclaimer to customers operating textile care installations where liquid supply (chemical) systems use or may use peristaltic pumps to inject supplies into equipment. -
Page 16: Note About The A.c. Power
User manual 5 Note about the A.C. power According to the EN 60204-1:2018 standard, the machine is provided for A.C. supplies corresponding to the ex- tracted characteristics below : 4.3.2 A.C. supplies Voltage: Steady state voltage: from 0.9 to 1.1 of nominal voltage. Frequency: from 0.99 to 1.01 of nominal frequency continuously. - Page 17 User manual Open the inner drum doors. Press the safety latch (A) and at the same time on the upper and lower doors with both hands. Caution, maintain the doors until they are widely open. Attention, risk of jamming when opening the doors. Load the linen in the inner drum.
-
Page 18: Detergents
User manual Close the inner drum doors and press them to check the good working of the mechanical safety device (B). If doors are not properly closed, they might open during a washing cycle and strongly damage the machine. Check that no piece of linen is wedged between the doors and the inner drum. Close the outer drum door and lock it with the handle. -
Page 19: Detergent Container
User manual 6.3 Detergent container The detergent container has five compartments. Each compartment is connected to a water valve. The water supply to individual compartment is as follows : Softener, liquid. Main wash for liquid detergent. Alt. for mop machines, liquid mop chemicals in last rinse. Pre-wash, powder or liquid detergent, if option “pre-wash”... - Page 20 User manual Control knob Display Preset buttons Control knob The control knob is used to select wash program, options and any other available functions. Turn the knob until the required option is shown on the display. d2120 Confirm your choice by pushing in the knob. d2121 Repeat this procedure until all the required options have been chosen.
-
Page 21: How To Start The Machine
User manual 8 How to start the machine Select the desired program by turning the control knob or select program with the quick selection buttons (if some of the buttons are programmed with this function). It is possible to select options (if some of the buttons are programmed with this function). Note! Some programs do not allow options. -
Page 22: Wash Programs Description
User manual 9 Wash programs description General The machine is equipped with a number of programs adapted to the range of use to which the machine is intended. It is recommended to follow the care labelling of the garment as fa as possible. Normal 95 —... - Page 23 User manual Normal 60 — (3H03) Prewash Signal 2 & 5 Mainwash 10 minutes 60 °C Hot water Low level Extraction 30 seconds High level Rinse 2 x 2 minutes High level Signal 3 Last rinse 4 minutes Extraction 7 minutes Delicate 30 —...
- Page 24 User manual Drain 11 secondes High level Signal 3 Rinse 4 minutes Drain 11 secondes Extraction Library 3H03 Compartment 1 Prewash Compartments 2 & 4 Mainwash Compartment 3 Last rinse Signal 1 Prewash Signal 2 Mainwash Signal 3 Softener, last rinse Signal 5 Bleach, Whitening...
-
Page 25: Additional Functions
User manual 10 Additional functions Note! Some of the functions may not be available or active on your machine. Pause It is possible to pause an ongoing program. Press the control knob. A menu will appear on the display. Select PAUSE by turning the control knob and press the control knob to activate. -
Page 26: Unloading
User manual 11 Unloading 11.1 Unloading side (barrier washer) At the end of the wash When a program has finished, the indicating lamp on the clean side will show when the clean side unloading door can be opened. Caution With AIDO(Automatic Inner Door Opening) option, Take care of the disc of the opening system above your head. Risk of cutting with the edge of the disc!! The green key indicator blinks to indicate you can open the outer door. - Page 27 User manual Open the inner doors using the lever. Caution, maintain the doors until they are widely open. Attention, risk of jamming when opening the doors. Unload the linen from the inner drum. Close the inner drum doors and press them to check the good working of the mechanical safety device (B).
-
Page 28: At The End Of The Day
User manual sluice program. Therefore it is recommended to add a sluice step to a "normal" program via the option menu when re- quired as opposed to using a sluice program alone. The machine is now ready for launching a new washing cycle. 11.2 At the end of the day Leave the door open when ready. -
Page 29: Error Codes
User manual • Inspect the interior of the machine during an actual wash cycle to ensure that no leaks are noticed. 13 Error codes In order to limit the risk of failure in the electronic controls of the programming unit of the machine, the machine should be earthed. -
Page 30: Lubricant Table
User manual 14 Lubricant table MACHINE LUBRICATION Rolling Rolling Assembly Bare gears Flange joints Reducers Reducers Circuits and bearings bearings paste (fretting with wheels with gears pneumatic Chains shafts Union pipes corrosion) and screws devices USES Bearings Bearings Thread Steam high circuits Slides... -
Page 31: Explanation Of Washing Symbols
User manual 15 Explanation of washing symbols (ISO 3758:2005 standard) To overcome language barriers, the following are symbols used internationally to give you guidance and recommen- dations when washing different textiles. 15.1 Washing The tub symbolizes washing. Max. washing tem- Symbols Mechanical action perature in °C... -
Page 32: Drying
User manual Symbols Explanation Bleaching allowed (chlorine or oxygen). Bleaching allowed (only oxygen). Do not bleach. 15.3 Drying The circle in a square symbolizes tumble drying. Symbols Explanation Can be put in a tumble dryer. Normal temperature. Can be put in a tumble dryer. Lower temperature. - Page 33 User manual Mild dry cleaning with solvent of hydrocarbon. Do not dry clean. Normal water cleaning. Mild water cleaning. Very mild water cleaning.
- Page 36 Electrolux Professional AB 341 80 Ljungby, Sweden www.electroluxprofessional.com...