Before Servicing Thinkpad T520, T520I, And W520; 1010 Battery Pack - Lenovo ThinkPad T520 Hardware Maintenance Manual

Before servicing ThinkPad T520, T520i, and W520

Removal steps of SIM card
Some models of the ThinkPad T520, T520i, and W520 you are servicing might have the SIM card that the
customer has installed.
If the computer you are servicing has the SIM card, remove it before you start the servicing.
To remove the SIM card, you need to remove the battery pack first. (See "1010 Battery pack" on page 66.)
After you finish the servicing, make sure that you insert the card back into the slot firmly.

1010 Battery pack

Important notice for replacing a battery pack:
The Lenovo ThinkVantage Toolbox and Lenovo Solution Center (in Windows 7) have an automatic battery
diagnostic that determines if the battery pack is defective. A battery pack FRU should not be replaced unless
this diagnostic shows that the battery is defective.
The only exception to this is if the battery pack is physically damaged or a customer is reporting a possible
safety issue.
If ThinkVantage Toolbox or Lenovo Solution Center is not installed in the computer, the customer should
download this program before a non-physically damaged battery pack is replaced. Note that the replacement
of a physically damaged battery pack is not covered by the warranty.
Removal steps of battery pack
DANGER
Use only the battery specified in the parts list for your computer. Any other battery could ignite
or explode.
Unlock the battery latch
the direction shown by arrow
66
Hardware Maintenance Manual
1
. Holding the battery latch in the unlocked position
3 .
2
, remove the battery pack in