HOW TO ORDER PARTS ..BACK PAGE LIMITED WARRANTY FOR CRAFTSMAN GENERATORS SEARS warrants to the original purchaser that the alternator and engine for its portable generator will be free from defects in materials or workmanship for the items and period set forth below from the date of original purchase.
Page 3
• Never operate the generator: in rain; in any enclosed compartment; when connected electrical devices overheat; if electrical The engine exhaust from this product output is lost; if engine or generator sparks; if flame contains chemicals known to the State of or smoke is observed while unit is running;...
KNOW YOUR GENERATOR Read the owner's manual and safety rules before operating your generator. Compare the illustrations with your generator to familiarize yourself with the locations of various controls and adjustments. Save this manual for future reference. -- FuelTank Spark Plug (inside cover) Engine ON/OFF Switch Choke Lever...
TO REMOVE GENERATOR FROM CARTON CONTENTS CARTON Check all contents against those listed below: • Main unit • Remove staples along top center of flaps, bend • Oil bottle flaps open, then remove all packing material. • Owner's manual • Remove the generator and contents from the shipping carton.
HOW TO USE YOUR GENERATOR To Add Engine Oil: • Place the generator on a level surface. If you have any problems operating your generator • Remove the oil fill cover. after reading the manual, please call the generator helpline at 1-800-222-3136. •...
Page 7
NOTE: O ccasionally clearthefuelstrainer o fanydirt, rust,or otherparticulate matter. • Install f uelcapandwipeupanyspilledgasoline. ® Occasionally youmayheara light"spark knock" o r "pinging" ( metallic rapping noise) whileoperating underheavyloads. T hisis nocauseforconcern. I f sparkknock or pinging occurs at a steadyengine speed undernormal l oad,change brands of gasoline or obtain a higher o ctaneratedfuel.If pinging or spark knockpersists, seeyourSearsrepaircenter.
• Connect battery charge cable clamp with red Charging a Battery handle to battery post or terminal indicated by WARNING! Storage batteries emit explosive POSITIVE, POS or (+). gas while charging that remains around a battery for a long time after it has been charged. The slightest spark can ignite the gas, causing To 12 Volt DC an explosion that can shatter the battery and...
DON'T OVERLOAD • If the appliance, tool or motor does not give wattage, multiply volts times ampere rating to GENERATOR determine watts (volts x amps = watts). Overloading a generator in excess of its rated wattage • Some electric motors, such as induction types, capacity can result in damage to the generator and to require about three times more watts of power for connected electrical devices.
MAINTENANCE SCHEDULE Follow the hourly or calendar intervals, whichever occurs first. More frequent service is required when operating in adverse conditions noted below. Item Each use Operation First Month or Every 3 months Every 6 months 25 hours or 50 hours or 100 hours Enqine oil Check level...
To Clean the Generator: Clean/Replace Spark Plug • Use a damp cloth to wipe exterior surfaces clean. Check and clean the spark plug every 50 hours of operation or every three months, whichever comes • A soft bristle brush may be used to loosen caked first.
• Loosen the screw on the muffler tail pipe and Clean Spark Arrester Screen remove the spark arrester screen. The engine muffler is equipped with a removable • Use a brass or stiff-bristle brush to remove carbon spark arrester screen. Inspect and clean the screen deposits from the spark arrester surface.
Page 13
Toavoidengine problems, thefuelsystem shouldbe emptied before storage of 30daysor longer. F ollow CAUTION! Avoid spray from spark plug hole when cranking engine slowly. theseinstructions: • Cover spark plug hole with rag. Crank slowly several times to distribute oil. Protect Fuel System •...
Page 14
Problem Cause Correction Reset circuit breaker. One of the circuit breakers is open. Engine is running, but Fault in generator. Contact Sears service facility. Poor connection or defective cord set. no AC or DC Check and repair. output is available. Connected device is bad.
Page 15
EN@_NE SENSOR UNZT C[3NTR[3L P&NEL EH@ZNE S_7[TCH DZL LEVEL WHERE 2WITCH WHERE ALTERNATDR YELLOW _[RCUK ]_REAf<ER dBSV, B.OA) GREEN BROWN BLACK BLACK BROWN GREEN GRDUN_ BROdN _ROWH C[RCUK BREAKER (LEVY, L0,0a?
Page 16
CRAFTSMAN 1000 Watt AC Generator 580.329100 Unit Exploded View & Parts List 22-.. Pan # Pan # Item Item Description Description 187378 ROTOR 187392 PHMS, M6-1.0, W/L/FW 187411 187383 BASE, GEN 187379 STATOR 187390 BOLT, FLNG, M6-1.0 X 10 187430...
Page 22
Engine, 2.4 HP, Mitsubishi, Model GM82 - Exploded Views & Parts Lists Fan Cover, Recoil Starter, Oil Sensor Item Part # Description 187521 CVR, FAN /_/_lj_f 187522 CVR, FAN 187523 CVR, FAN 187524 BOLT, FAN CVR Item Part # Description 187557 ASSY, RECOIL, STRTR 187558...
Page 23
Engine, 2.4 HP, Mitsubishi, Model GM82 - Exploded Views & Parts Lists Lead Wires, Muffler, Gasket Set Item PaN # Description 187571 WIRE, LEAD 187572 PLUG, SPARK 187573 CAP, PLUG 187574 TIEWRAP, LEAD WIRE 187575 WIRE, LEAD Item PaN # Description 187449 NUT, FLNG...
Page 24
YOUR WARRANTY RIGHTS AND receipts covering maintenance on your engine, but Sears cannot deny warranty solely due for the lack of OBLIGATIONS receipts or for your failure to ensure the performance of all scheduled maintenance. The California Air Resources Board ("CARB") and Sears Roebuck and Co., USA, are pleased to explain As the engine owner, you should be aware that Sears the Emission Control System Warranty on your model...
WHAT IS COVERED Add-on or Modified Parts The use of add-on or modified parts can be grounds Repair or Replacement of Parts for disallowing a warranty claim. Sears is not liable to • Repair or replacement of any warranted part will cover failures of warranted parts caused by the use of be performed at no charge to the owner at an add-on or modified parts.
Page 26
GARANTIA LIMITADA GENERADORES CRAFTSMAN SEARS le garantiza al comprador original que el altemador y el motor de su generador portatil estara libre de defectos en materiales y mano de obra en los componentes y por el periodo de tiempo establecido a continuaci6n a partir de la fecha de compra original.
Page 27
• No Ilene el tanque de combustible excesivamente. Siempre permita que exista espacio para la expansi6n del combustible. Si el tanque esta demasiado Ileno, el El escape del motor de este producto contiene combustible podria rebosarse y caer sobre el motor elementos quimicos, los cuales son reconocidos en caliente y ocasionar un INCENDIO o una EXPLOSION.
Page 28
CONOZCA SU GENERADOR Lea este manual del propietario y las reglas de seguridad antes de operar su generador. Compare las ilustraciones con su generador para familiarizarse con la ubicaci6n de los diferentes controles ajustes. Conserve este manual para referencias futuras. Bujia (cubierta del interior) Tanque de Combustible...
PARA SACAR EL GENERADOR CONTENIDO DEL EMPAQUE EMPAQUE Verifique el contenido contra la lista de articulos detallados a continuaci6n: • Quite todas las grapas a Io largo de la parte superior • Unidad principal central, d6blelas hacia fuera y despu6s quite todo el material de empaque.
Page 30
COMO UTILIZAR SU GENERADOR SAE 10W-30 es el recomendado para uso general bajo todas las temperaturas. Este aceite de multi-viscosidad Si tiene cualquier problema al operar su generador despu6s mejorara el arranque en climas frios, pero provocara un de leer el manual, por favor Ilame a la linea de ayuda del incremento en el consumo de aceite.
Si el nivel de combustible es bajo, afiada lentamente la gasolina recomendada al tanque de combustible, hasta el borde del filtro de combustible. Tenga cuidado de no sobrellenarlo (no debe haber combustible en el cuello del rellenador). Llene a Este Nivel Colocue el interruptor del motor en la posici6n "ON"...
Detener el Motor Para recargar baterias de 12 Voltios, Ileve a cabo los siguientes procedimientos: • Desconecte todas las cargas el6ctricas de la unidad. • Limpie los terminales de la bateria si es necesario. Nunca arranque o detenga el motor con dispositivos el6ctricos conectados a 61 y encendidos.
Page 33
NO SOBRECARGUE amperaje para determinar los vatios (voltios x amperios = vatios). GENERADOR • Algunos motores el6ctricos, como los de inducci6n, Sobrecargar el generador mas alia de su capacidad de requieren aproximadamente tres veces mas vatios de vatiaje puede ocasionar dafios al mismo y a los dispositivos poder para su arranque que para su funcionamiento.
Page 34
PROGRAMA DE MANTENIMIENTO Siga los intervalos horarios o de calendario, Io que ocurra primero. Se requiere de servicio con mayor frecuencia cuando opere la unidad en las condiciones adversas descritas a continuaci6n. item En cada Primer Mes o Cada 3 meses o Cada 6 meses o Operaci6n 25 horas...
• Rellene con el aceite recomendado y verifique su nivel. Para Limpiar el Generador Consulte la pagina 30 para conocer cuales son las • Utilice una franela hQmeda para limpiar las superficies recomendaciones de aceite. externas. • Limpie cualquier aceite derramado. •...
Page 36
• Reinstale el elemento de filtro de aire y la cubierta. protector contra chispas. El propietario/operador debera Apriete manualmente los tornillos de la cubierta del filtro conservar en buen estado el protector contra chispas. de aire. Revise el tamiz protector contra chispas y tenga el centro del servicio de Sears reemplacelo siesta doblado, perforado Limpiar el Tamiz...
Cambie el Aceite Generador Mientras el motor esta todavia caliente, drene el aceite del • Limpie el generador tal y como se describe en la contenedor del motor. Rellene con aceite de la gradaci6n pagina 35 ("Para Limpiar el Generador"). recomendada.
Page 38
Problema Causa Solucibn Uno de los cotacircuitos esta abierto. Reajuste el cortacircuito. Falla en el generador. P6ngase en contacto con la Planta de El motor est_ funcionando Servicio de Sears. Mala conexi6n o juego de cordones Revise y repare. pero no existe salida de defectuoso.
Page 39
Si tiene preguntas acerca de sus responsabilidades y derechos Sus Obligaciones y Derechos de Garantia de garantia, deber& ponerse en contacto con su centro de La Junta Directiva de Recursos Ambientales de California ("CARB') servicio autorizado mas cercano o Ilamar a Sears al y Sears Roebuck and Co.
Page 40
For in-home major brand repair service: Call 24 hours a day, 7 days a week 1-800-4-MY-HOM E SM (1-800-469-4663) Para pedir servicio de reparacibn a domicilio - 1-800-676-5811 In Canada for all your service and parts needs call - 1-800-665-4455 Au Canada por tout le service ou les pi6ces For the repair or replacement parts you need:...