Table Of Contents - Whirlpool 27' Job Aid

INTRODUCTION .................................................................................................................. II
TABLE OF CONTENTS ...................................................................................................... III
SECTION ONE
GENERAL INFORMATION
Electric Requirements .................................................................................................. 1
Exhaust Requirements for Electric and Gas Dryers .................................................. 5
Gas Requirements for Gas Dryers .............................................................................. 6
Recessed and Closet Installation Instructions ........................................................... 8
SECTION TWO
THEORY OF OPERATION
Controls and Cycles ....................................................................................................................9
Electronic Dryer Control ...........................................................................................................10
Heated Air Circulation............................................................................................................... 11
SECTION THREE
COMPONENT ACCESS .................................................................................................... 13
Removing the Console ..........................................................................................................13
Removing the Timer ..............................................................................................................14
Removing the Clean touch Switch Assembly ........................................................................14
Removing the Push to Start Button .......................................................................................14
Removing the Buzzer ............................................................................................................14
Removing the Electronic Control Board ................................................................................14
Removing the Dryer Top ........................................................................................................14
Replacing the Drum Lamp .....................................................................................................15
Removing the Door Switch ....................................................................................................15
Removing the Toe Panel .......................................................................................................15
Removing the Blower Wheel .................................................................................................16
Replacing the Blower Housing ..............................................................................................16
Replacing the Motor ..............................................................................................................17
Replacing the Operating Thermostat and Bias Heater ..........................................................17
Replacing the Thermal Fuse .................................................................................................17
Replacing the Heating Element .............................................................................................18
Replacing the Burner Assembly ............................................................................................18
Replacing the High Limit Thermostat and Thermal Cutoff ....................................................18
Replacing the Heat Duct Assembly .......................................................................................18
Removing the Dryer Door ......................................................................................................19
Removing the Front Panel .....................................................................................................19
Removing the Belt and Drum ................................................................................................20
Replacing the Front Support Rollers and Shafts ...................................................................20
Replacing the Grille Assembly ..............................................................................................20
Removing the Rear Bulkhead Assembly ...............................................................................21
Reattaching the Rear Bulkhead ............................................................................................21

TABLE OF CONTENTS

III