Page 1
Installation Overthe Range Microwave Oven Instructions BEFORE YOU BEGIN Read these instructions completely and carefully. • Note to Consumer - Keep these instructions fi)r flmue reference. • IMPORTANT - Savethese • Skilllevel- Installationofthisappliancerequires instructions ti)r local inspe{tor's use. basic mechanical and electrical skills.
Installation Instructions mMPORTANT SAFETY mNSTRUCTmONS You should have the wall receptacle and circuit checked This produ( t requires a three-pro_g grounded by a qualified electrician to make sure the receptacle omlet. The inaalier must perform a groined (::omimfi b- properly grounded. check on the power omlet...
Installation Instructions HOOD EXHAUST NOTE: Read these next two pages only if you plan to vent your exhaust to the outside. If you plan to recirculate the air back into the room, proceed to page 6. OUTSIDE TOP EXHAUST (EXAMPLE ONLY) Tile fi)llo_fing chart des(rihes...
Page 5
Installation Instructions Maximum duct length: NOTE: If you need to install ducts, note that the total duct length of 3 V/' x 10" rectangular or 6" diameter round For satisLt{ to D air movement, the total du{t length of duct should not exceed 140 equivalent feet (42.67 m).
Installation Instructions PARTS INCLUDED DAMAGE - SHmPMENT/ HARDWARE PACKET * If the unit is damaged in shipment, re_uvn d_e unh PART QOANTITY _o d_e s_ore h_ whhh h was bough_ for repair or WoodScrews (Y/' x 2") * If the unit is damaged by the customer, rep_ir 05 veplacemem is d_e responsibility...
Installation Instructions TOOLS YOU WILL NEED Ruleror tape measureand Pencil #1 and#2 Phillipsscrewdriver t edge (optional) Tin snips(for cutting damper,if required) Scissors Electric drill with ¾_"VS" a nd%" (to cut template, if necessary) drill bits Fillerblocksor scrap wood pieces,if needed for top cabinetspacing (usedon recessedbottom cabinet installationsonly)
Installation Instructions I- PLACEMENT OF THE MOUNTING PLATE REMOVING THE MICROWAVE FINDING THE WALL STUDS OVEN FROM THE CARTON/ REMOVING THE MOUNTING PLATE Remove tile installation instructions, filters, glass tray and the small hardware bag. Do not remove the Styroloam protecting the front of tile oven.
Installation Instructions DETERMINING WALL PLATE LOCATION UNDER YOUR CABINET Plate position - beneath framed recessed Plate position - beneath flat bottom cabinet cabinet bottom Mounting Plate Tabs Cabinet Bottom i the Mounting Plate Tabs Touching the Back Frame c I)iLUIIIFL I II 30"...
Installation Instructions ALIGNING THE WALL PLATE Draw a Vertca Hole Line onWall u_-- fromCenter of T°pCabinet %," HoleC J; HoleD ', CAUTION: Wear gloves to avoid cutting fingers on sharp edges. Draw a vertical line on the wall at tile center of tim 30" NOTE: Holes C and D are inside area E.
Installation Instructions INSTALLATION TYPES (Choose A, B or C) lot adaptation NOTE: This microwave is shipped assembled tot Outside This microwave oven is designed to tile Top Exhaust (except fin non-vented models). Select tile tollowing three types of ventilation: type of ventilation required tot your installation A.
Installation Instructions OUTSIDE TOP EXHAUST (Vertical Duct) INSTALLATION OVERVIEW A 1. Attach Mounting Plate to Wall A2. Prepare Top Cabinet A3. Check Damper Operation A4. Mount Microwave Oven A5. Adjust Exhaust Adaptor A6. Connect Duc/work To use toggle bolts: ATTACH THE MOUNTING PLATE TO THE WALL Spacing f orToggles MoreThan Wall...
Installation Instructions USE TOP CABINET TEMPLATE MOUNT THE MICROWAVE FOR PREPARATION OF TOP OVEN CABINET You need to drill holes for the top support screws, a hole large enougll for tile power cord to fit through, and a cutout large enougll for tile exhaust adaptor.
Installation Instructions CabinetFront ADJUST THE EXHAUST CabinetBottomShelf ADAPTOR Filler Block Open the top cabinet and a([iust tile exhaust adaptor to connect to the house duct. Depth of Cabinet quivalentto Backof Recess Blower Plate Damper Microwave For Front-to-Back o r Side-to-Side Insert 2 self:aligning screws Adjustment,Slidethe...
Installation Instructions OUTSIDE BACK EXHAUST (Horizontal Duct) INSTALLATION OVERVIEW B1. Prepare Rear Wall B2. Attach Mounting Plate to Wall B3. Prepare Top Cabinet B4. A(ljust Blower B5. Mount the Microwave Oven This microwave oven is shipped assembled ti)r top PREPARING THE REAR WALL exhaust.
Installation Instructions To use toggle bolts: PREPARING THE REAR WALL FOR OUTSIDE BACK EXHAUST Spacing for Toggles More (continued) -_l_-_i_ Than WallThickness Toggle W ings Mounting House Damper Hinge On Top Plate Duct B01t E nd DamperSwings Place the mounting plate against the wall and insert the toggle wings into the holes in the wall to [_Fit...
Installation Instructions Roll the blower unit 90 ° so that fan blade ADAPTING MICROWAVE openings are lacing out the back of the BLOWER FOR OUTSIDE uliciowave, BACK EXHAUST BeforeRolling After Rolling Remove and save screw that holds bh)wer motor UlI( I'OW}lVe, Blower Motor Micr0wave...
Installation Instructions CabinetFront MOUNT THE MICROWAVE CabinetBottomShelf OVEN FillerBlock to Depth of Cabinet quivalent Recess Self-AligningScrew FOR L4SIER INSTAI,IATION AND PERSONAL SAFETY, WE RECOMMEND THAT TWO PEOPLE INSTALL THIS MICROWAVE OVEN. IMPORTANT: Do not grip or use handle Insert 2 sell:aligning screws during installation.
Installation Instructions RECIRCULATJNG (Non-Vented #uctJess) INSTALLATION OVERVIEW C1. Attach Mounting Plate to Wall C2. Prepare Top Cabinet C3. Check Microwave Assembly CA. A(ljust Blower C5. Mount the Microwave Oven _ ..C6. Install Charcoal Fiher Place the mounting plate against the wall and ATTACH THE MOUNTING insert the toggle wings into the holes in the wall to PLATE TO THE WALL...
Installation Instructions CHECK MICROWAVE ASSEMBLY Carefhlly pull out tile bh)wer unit. Tile wires adjust xdll extend far enough to alh)w you to tile Exhaust Adaptor (absent bh)wer unit. on models shipped recirculatirm exhaust Backof Microwave ; • Place tile microwave in its upright position, with tile...
Installation Instructions NOTE: When inounting ADAPTING MICROWAVE tile ulicrowave ()veil, BLOWER FOR thread power cord RECJRCULATJON (continued} through hole in bottoin top cabinet. Keep it tight Place tile bh)wer unit back into tile opening. throughout Steps 1-3. Do IJft inicrowave, tilt it not pinch cord or lift oven CAUTION: Do not pull or stretch the blower unit...
Installation Instructions iNSTALLING MOUNT THE MICROWAVE CHARCOAL FILTER OVEN (continued} Remove 2 screws on flrmt r)f grille using a #1 Insert 2 self:aligning screws Phillips s( rewdriver, through outer top (abinet holes. Turn two flfll turns Open the door. each screw. Remove the grille.
Installation Instructions BEFORE YOU USE YOUR MICROWAVE _k4ke sllFe _he micro_%_ve o_er_ h;-_s been Marmal. installed according _o instructions. Read _l_e Owner's KEEP INSTALLATK)N INSTRUCTIONS FOR THE L()CAI_ INSPECT()R'S USE. Remove all packing material flom mi( ro_,k2_ e o_erh Install turntable and ring in cavity.