1. Manuals
  2. Brands
  3. Sony Manuals
  4. TV
  5. KV-29FQ85E
  6. Service manual

Sony KV-29FQ85E Service Manual

Fd trinitron color tv
Hide thumbs Also See for KV-29FQ85E:
Table of Contents

Advertisement

Quick Links

Download this manual

SERVICE MANUAL

MODEL
KV-29FQ85E
COMMANDER
DEST
CHASSIS NO.
RM-943
ESP
SCC-Q81T-A
AE-6BAD/Y
MODEL
KV-29FQ85K
KV-29FQ85
- 1 -
CHASSIS
COMMANDER
DEST
CHASSIS NO.
RM-943
OIRT
SCC-Q82L-A
RM-943

Advertisement

Table of Contents
loading

Related Manuals for Sony KV-29FQ85E

Summary of Contents for Sony KV-29FQ85E

  • Page 1: Service Manual

    SERVICE MANUAL AE-6BAD/Y CHASSIS MODEL MODEL COMMANDER DEST CHASSIS NO. COMMANDER DEST CHASSIS NO. KV-29FQ85E KV-29FQ85K RM-943 SCC-Q81T-A RM-943 OIRT SCC-Q82L-A KV-29FQ85 RM-943 - 1 -...

  • Page 2: Table Of Contents

    PARTS LIST ARE CRITICAL FOR SAFE OPERATION. REPLACE TANCE CRITIQUE POUR LA SÈCURITÈ DU FONCTIONNEMENT, NE LES REMPLACER QUE PAR DES COMPSANTS SONY DONT THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN LE NUMÈRO DE PIÈCE EST INDIQUÈ...

  • Page 3: Caution

    Due to the higher melting point of Lead Free Solder the soldering iron tip temperature needs to be set to 370 degrees centigrade. This requires soldering equipment capable of accurate temperature control coupled with a good heat recovery characteristics. For more information on the use of Lead Free Solder, please refer to http://www.sony-training.com - 3 -...
  • Page 4 l l a . s l . s l . s l . s l . s l e i l . s l t c i n i l i n i y t i - 4 -...

  • Page 5: Connectors

    21 pin connector Pin No Signal Signal level Audio output B Standard level : 0.5V rms (right) Output impedence : Less than 1kohm* Audio input B Standard level : 0.5V rms (right) Output impedence : More than 10kohm* Audio output A Standard level : 0.5V rms (left) Output impedence : Less than 1kohm*...

  • Page 6: Self Diagnostic Software

    AE-6BAD/Y SELF DIAGNOSTIC SOFTWARE The identification of errors within the AE-6BAD/Y chassis is triggered in one of two ways :- 1: Busy or 2: Device failure to respond to IIC. In the event of one of these situations arising the software will first try to release the bus if busy (Failure to do so will report with a continuous flashing LED) and then communicate with each device in turn to establish if a device is faulty.

  • Page 7: General

    SECTION 1 GENERAL - 7 -...
  • Page 8 - 8 -...
  • Page 9 - 9 -...
  • Page 10 - 10 -...
  • Page 11 - 11 -...
  • Page 12 - 12 -...

  • Page 13: Disassembly

    SECTION 2 DISASSEMBLY 2-1. Rear Cover Removal 2-2. Speaker Connector Disconnection => => => => Remove the rear cover fixing screws indicated and pull the Before completely removing the rear cover disconnect the rear cover backwards away from the set. Take care when speaker connector which is located on the inside of the set.

  • Page 14: Service Position

    2-4. Service Position 2-5. G Board Removal Clips To remove the G Board remove the two screws from the To place the chassis in the service position, insert the main middle of the board, release the clips circled and ease the bracket firmly into the T-slot located on the left corner of the board gently away from the support bracket.

  • Page 15: Picture Tube Removal

    2-8. Picture Tube Removal WARNING: BEFORE REMOVING THE ANODE CAP High voltage remains in the CRT even after the power is disconnected. To avoid electric shock, discharge CRT before attempting to remove the anode cap. Short between anode and CRT coated earth ground strap.
  • Page 16 - 16 -...

  • Page 17: Set-Up Adjustments

    SECTION 3 SET-UP ADJUSTMENTS • When complete readjustment is necessary or a new picture tube Carry out the adjustments in the following order : is installed, carry out the following adjustments. 3-1. Beam Landing. • Unless there are specific instructions to the contrary, carry out 3-2.

  • Page 18: Convergence

    Fig.3-4 Align both Purity Purity magnets Purity control magnets magnets to the vertical position Align pips on each magnet 3-2. Convergence (1) Screen centre convergence [Static convergence] Input a dot pattern signal from the pattern generator. Normalize the picture setting. [Moving vertically], adjust the V.STAT magnet so that the vertical red, green and blue dots coincide at the centre of the screen.
  • Page 19 Correction for HMC [Horizontal mis-convergence] and VMC HTIL correction can be performed by adding a THL correction [Vertical mis-convergence] by using the BMC [Hexapole] assembly to the Deflection yoke. magnet. a). HMC correction by BMC [Hexapole] magnet and movement of the electron beam.

  • Page 20: Focus Adjustment

    Layout of each control 3-3. Focus Adjustment Receive a television broadcast signal. Normalize the picture setting. Purity magnet Adjust the focus control located on the flyback transformer to BMC (Hexaploe) magnet obtain the best focus at the centre of the screen. V STAT convergence magnet Bring only the centre area of the screen into focus, the magenta- Y-splitting axis correction magnet...

  • Page 21: Circuit Adjustments

    SECTION 4 CIRCUIT ADJUSTMENTS 4-1. Electrical Adjustments Service adjustments to this model can be performed using the supplied remote Commander RM-943. Programming the Remote Commander for Operation in Service Mode Press and hold the left Mode Select button until the VCR and DVD LED’s flash. Press 99999.
  • Page 22 Sub Brightness Adjustment Input a Monoscope pattern. Program the Remote Commander for operation in Service Mode. [ See Page 21 ]. Press ‘AUX/VIDEO’ ‘AUX/VIDEO’ 13 on the Remote Commander. Adjust the ‘Sub-Brightness’ data so that there is barely a difference between the 0 IRE and 10 IRE signal levels. Sub Contrast Adjustment Input a video signal that contains a small 100% white area on a black background.

  • Page 23: Test Mode

    Sub Colour Adjustment 4-2. TEST MODE 2: Receive a PAL colour bar signal. Test Mode 2 is available by programming the Remote Commander for Connect an oscilloscope to Pin 5 of CN7331 [C Board]. operation in Service Mode [ As shown on Page 21 ] then pressing the Program the Remote Commander for operation in Service Mode.

  • Page 24: Block Diagrams

    5-1. BLOCK DIAGRAMS (1) CN3601 IC3600 RIGHT OUT AUDIO/VIDEO SWITCH BUFFER V-OUT-35 V-OUT-3B RIGHT IN V-OUT-15 LAST RF SC3-IN-R Q3656 AV3 IN R LEFT OUT V-OUT-25 AV2 OUT SC2-IN-R AV2 I R LEFT IN CVBS/Y MAIN BUFFER CVBS Y MAIN SC1-IN-R V-OUT-25 V-OUT-2B...

  • Page 25: Block Diagrams

    5-1. BLOCK DIAGRAMS (2) CN3100 KEY 2 B 1/2 ( BACKEND,SCANRATE, IR-DATA LVDS,A_INTERFACE LUMISPONDER EPG MODE OCP-OVP OCP-FLAG MAIN-SW DG SW KEY 1 IC3400 BACKEND VIDEO SIRCS CN3400 H TRAP R OUT BUFFER BUFFER AMP HV PROT PWM3 Q5503 Q3400, Q3403 IC0001 B 2/2 ( G OUT...

  • Page 26: Block Diagrams

    5-1. BLOCK DIAGRAMS (3) IC8700 IC8701 CN8203 CN8700 V DRV+ Q8700 DRIVERS Q8702, Q8703 V DRV- Q8701 TO A BOARD ABL-COMP CN3008 Q8704 DQP-DRV CN8206 Q8508 Q8512 DQP-V-COMP TO VM BOARD CN9401 IC8527 IC8103 COMPARATOR CN2912 HP R HP R J2901 TO A BOARD Q8118, Q8201,...

  • Page 27: Block Diagrams

    5-1. BLOCK DIAGRAMS (4) TUNER TU1100 IC2000 AGC DEFEAT SWITCH SOUND IC2200 FROM B BOARD 5-2. CIRCUIT BOARD LOCATION Reference Information Q1100 PROCESSOR AUDIO AMP J2200 CONNECTOR REAR-R SPEAKERS REAR-L IC2400 FM/AM RESISTOR : METAL FILM AUDIO AMP WOOFER CN2400 WOOFER SP TO WOOFER C Board...
  • Page 28 ~ A Board Waveforms ~ 20us/div 5ms/div 700 mVp-p (V) 56 Vp-p (V) ~ A Board Location Table (A Side) ~ ~ A Board Location Table (B Side) ~ - 28 -...
  • Page 29 ~ A Board Semiconductor Voltage Table ~ ~ A Board IC Voltage Table ~ - 29 -...

  • Page 30: A Board Schematic

    B-#SSAE6B<...>-A..-29FQ85 10000PF 0.47 0.47 ROTATION COIL TO J BOARD CN3604 0.01 0.01 3.9K AV LINK CONVERTER 3.9K ~ A Board Schematic Diagram [ Audio, Deflection J Interface ] Page 1/3 ~ - 30 -...
  • Page 31 B-#SSAE6B<...>-A..-29FQ85 COMPONENTS MARKED AS XX ARE NOT FITTED ON THIS MODEL F1101 BTF-EC411 10UH TAB(CONTACT) BA12T 12V REGULATOR KF25BDT 2.5V REGULATOR 150K ~ A Board Schematic Diagram [ Tuner, Regulators ] Page 2/3 ~ - 31 -...
  • Page 32 4.7K 0.01 B-#SSAE6B<...>-A..-29FQ85 ~ A Board Schematic Diagram [ B Interface ] Page 3/3 ~ - 32 -...
  • Page 33 ~ A Printed Wiring Board Conductor side A ~ - 33 -...
  • Page 34 ~ A Printed Wiring Board Conductor side B ~ - 34 -...

  • Page 35: B Board Schematic

    B-#SSAE6B<...>-B..-29FQ85 CXD3804R-T6 ~ B Board Schematic Diagram [ Backend,Scanrate,LVDS,A_Interface ] Page 1/3 ~ - 35 -...
  • Page 36 B-#SSAE6B<...>-B..-29FQ85 BUFFER BUFFER SWITCH SWITCH BUFFER SWITCH ~ B Board Schematic Diagram [ Backend,Scanrate,LVDS,A_Interface ] Page 2/3 ~ - 36 -...
  • Page 37 B-#SSAE6B<...>-B..-29FQ85 M24C32-WMN6T(A) 3.3k M27V160-100K1-6BA001 ~ B Board Schematic Diagram [ Backend,Scanrate,LVDS,A_Interface ] Page 3/3 ~ - 37 -...
  • Page 38 ~ B Printed Wiring Board Conductor side A ~ ~ B Printed Wiring Board Conductor side B ~ ~ D2 Printed Wiring Board Conductor side ~ - 38 -...

  • Page 39: D2 Board Schematic

    B-#SSAE6B<...>-D2.-29FQ85 0.33 SWITCH 8.2K DTZ-5.1B 8.2K 8.2K 6.8K 8.2K TAB(CONTACT) TAB(CONTACT) MMDL914T1 ~ D2 Board Schematic Diagram [ Smart Mode Deflection ] ~ - 39 -...

  • Page 40: F1 Board Schematic

    ~ F1 Board Schematic Diagram [ Power Switch, Fuse, SIRCS and Stand-By LED ] ~ ~ H1 Board Schematic Diagram [ Front AV Input, Headphone and Control Switches ] ~ TO J BOARD TO A BOARD F1.-29FQ85 CN3600 CN2300 POWER SWITCH, FUSE, SIRCS &...
  • Page 41 ~ G Board Semiconductor Location Table ~ ~ G Printed Wiring Board Conductor side ~ ~ H1 Printed Wiring Board Conductor side ~ Note : Portions of the circuit contained within the marked areas as shown have high voltages present. Use care to prevent electric shock during inspection or repair.

  • Page 42: G Board Schematic

    B-#SSAE6B<...>-G..-29FQ85 OVER CURRENT PROTECTION D1NL40-TA2 4.7UH CONTROL IC 4700 SW MOSFET 4.7UH SW MOSFET S1VB40 SWITCH ~ G Board Schematic Diagram [ Power Supply ] ~ - 42 -...

  • Page 43: C Board Schematic

    C..-29FQ85 R7337 IC7300 CN7333 1/2W R7309 TDA6118JF RED VIDEO OUT FV FOCUS C7334 R7334 250V 1/4W R7301 C7305 C7306 1/10W 1000p D7300 1SS83TA R7340 R7306 J7330 C7303 2.7k R7305 R7308 1/10W Q7301 R7307 MSD601-RST1 1/2W Q7300 BUFFER BF550 D7302 D7301 D7303 1SS133 1SS83TA...
  • Page 44 ~ C Board Waveforms ~ ~ C Printed Wiring Board Conductor side ~ 10us/div 10us/div ~ J Printed Wiring Board Conductor side A ~ 3.0 Vp-p (H) 3.0 Vp-p (H) 10us/div 10us/div 100 Vp-p (H) 3.0 Vp-p (H) 10us/div 10us/div 95 Vp-p (H) 95 Vp-p (H) 20us/div...

  • Page 45: J Board Schematic

    J..-29FQ85 L3614 C3642 R3653 AUDIO R OUT 1/10W C3645 SC1-OUT-R R3654 R2604 R2608 R2600 C2604 C2610 D2600 470k Q3656 0.022 UDZS-TE17-9.1B 1/10W MSD601-RST1 1/10W 1/10W 1/10W AUDIO R IN BUFFER R3652 SC1-IN-R C2601 R2601 R2605 R2609 C2605 C2608 D2601 1/10W 470k 1000p UDZS-TE17-9.1B...
  • Page 46 ~ D Printed Wiring Board Conductor side ~ ~ D Board Waveforms ~ ~ D Board IC Voltage Table ~ ~ D Board Semiconductor Voltage Table ~ 10us/div 10us/div 10us/div 10us/div 10us/div 1.5 Vp-p (H) 130 Vp-p (H) 1.4 Vp-p (H) 140 Vp-p (H) 455 Vp-p (H) TP10...

  • Page 47: D Board Schematic

    B-#SSAE6B<...>-D..-29FQ85 470K 3.3K 680K 0.01 680K MSD601-RST1 470K 2.2K 0.033 0.033 3.3K 0.033 3.3K 470K 4.7K 1SS133T 100K KTA4370A MSD601-RST1 CXA8070AP 4.7K LM318N 470K 2.2K 270PF KTA1659A 0.33 10V 3.3K 2.2K 100K 1.5K 100PF MMDL914T1 MSB709-RT1 MSB709-RT1 47PF 8.2K 47PF UN2213 560K 5.6K...

  • Page 48: Semiconductors

    5-4. SEMICONDUCTORS RD15ES-B2 BYV98-200-RAS 15/12 L7809CV/LSY CATHODE 1SS133T-77 RD39ES-B2 STP5NK40Z(033Y) 1SS83 RD3.6ES-B2 ST2310DHI D1NL20U RD5.6ESB2 D1NL20U-TR RK14V1 ANODE D1NL40-TA2 EL1Z CATHODE ERA22-08 CA0005AD GP08D LA6393DLL FUF4005 LA6500-FA HZS9.1NB2 MTZJ-33B ANODE MTZJ-4.7C 1PS184-115 CXA2019AQ-TL MM3Z4V7T1 CXA2149AQ-TL MM3Z6V8T1 MM3Z9V1ST1 MM3Z15VT1 MMDL914T1 ANODE UDZSTE-1713B LM393DT UDZSTE-1718B...
  • Page 49 UPC1093J-1-T PQ1CG2032FZ CATHODE ANODE VSP9417BC3G PST9143NL 1 2 3 4 5 SE135N-LF4 (TOP VIEW) SENSE 2 COLLECTOR 3 GND STV9379 TDA7482 TDA7269 TLHK5190 CATHODE ANODE TL1431CZ-AP - 49 -...

  • Page 50: Ic Blocks

    5-5. IC BLOCK DIAGRAMS A BOARD IC5400 STV9379A FLYBACK GENERATOR POWER AMPLIFIER THERMAL PROTECTION G BOARD IC6001 MCZ3001D Remote DVLD Internal Driver Sel=34v ref 5v Reg. 10v 15v/8v Level Shift Vsense Control Logic Latch Centre Timer A BOARD IC6210 BA033T REFERENCE VOLTAGE - 50 -...
  • Page 51 A BOARD IC2000 MSP3411G SBUS Interface I2C Interface DEMODULATOR IDENT SCART Switching Facilities G BOARD IC6003 SE135N-LF4 - 51 -...

  • Page 52: Exploded Views

    SECTION 6 EXPLODED VIEWS NOTE : Items with no part number and no description are not Items marked “*” are not stocked stocked because they are seldom required for routine since they are seldom required for service. routine service. Some delay should The construction parts of an assembled part are indicated be anticipated when ordering these items.

  • Page 53: Picture Tube

    6-2. PICTURE TUBE REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK - 53 -...

  • Page 54: Electrical Parts List

    SECTION 7 ELECTRICAL PARTS LIST PARTS LISTING TABLE OF CONTENTS Page A BOARD COMPLETE Parts List : ....................55 D BOARD COMPLETE Parts List : ....................61 B BOARD COMPLETE Parts List : ....................65 D2 BOARD COMPLETE Parts List : ....................
  • Page 55 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK * A-1302-331-A A Board, Complete C2203 1-126-963-11 ELECT 4.7UF 20.00% 50V C2204 1-126-960-11 ELECT 20.00% 50V 4-382-854-01 SCREW (M3X8), P, SW (+) C2205 1-126-960-11 ELECT 20.00% 50V 4-382-854-01 SCREW (M3X8), P, SW (+) C2206 1-162-970-11 CERAMIC CHIP 0.01UF...
  • Page 56 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK C5120 1-165-176-11 CERAMIC CHIP 0.047UF 10.00% 16V C6237 1-126-767-11 ELECT 1000UF 20.00% 16V C5121 1-165-176-11 CERAMIC CHIP 0.047UF 10.00% 16V C6238 1-136-165-00 FILM 0.1UF 5.00% 50V C5122 1-164-156-11 CERAMIC CHIP 0.1UF C6239 1-104-665-11 ELECT 100UF...
  • Page 57 D1 A REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK D5100 8-719-081-97 DIODE MMDL914T1 IC6207 8-759-640-19 IC PQ1CG2032FZ D5103 8-719-110-86 DIODE RD39ESB IC6210 8-759-445-59 IC BA033T D5104 8-719-976-99 DIODE DTZ5.1B IC6211 6-701-848-01 IC KF25BDT D5200 8-719-081-97 DIODE MMDL914T1 IC6212 8-759-474-09 IC SI-8050S-LF1101 D5201 8-719-081-98...
  • Page 58 F4 A REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK Q2202 8-729-010-29 TRANSISTOR MSD601-RST1 JR6010 1-216-864-11 SHORT CHIP Q2300 8-729-010-05 TRANSISTOR MSB709-RT1 JR6012 1-216-864-11 SHORT CHIP Q2301 8-729-010-29 TRANSISTOR MSD601-RST1 JR6013 1-216-864-11 SHORT CHIP Q2302 8-729-010-29 TRANSISTOR MSD601-RST1 JR6023 1-216-864-11 SHORT CHIP Q2400 8-729-010-05...
  • Page 59 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R2206 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R2510 1-163-021-91 CAP CERAMIC 0.01 10% R2207 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R2511 1-216-837-11 METAL CHIP 1/10W R2208 1-216-821-11 METAL CHIP 1/10W R2512 1-216-835-11 METAL CHIP 1/10W R2209...
  • Page 60 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R5210 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R5414 1-249-383-11 CARBON 1/4W R5212 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R5415 1-249-389-11 CARBON 1/4W R5213 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R5416 1-243-568-21 METAL OXIDE R5214 1-216-829-11 METAL CHIP...
  • Page 61 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK < TUNER > C8140 1-117-836-11 FILM 6800PF 3.00% 1.5KV C8141 1-117-836-11 FILM 6800PF 3.00% 1.5KV TU1100 8-598-533-10 FRONTEND BTF-EC411 C8142 1-127-681-11 FILM 10000PF 100V C8143 1-125-893-11 FILM 680PF 3.00% 1.5KV < CRYSTAL > C8144 1-125-893-11 FILM...
  • Page 62 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK C8804 1-102-114-00 CERAMIC 470PF 10.00% 50V IC8101 8-759-665-11 IC LM393DT C8805 1-102-114-00 CERAMIC 470PF 10.00% 50V IC8102 8-759-638-79 IC NJM3404AD-W IC8103 8-759-659-67 IC LA6393DLL < CONNECTOR > IC8527 8-759-701-01 IC NJM2904M IC8700 8-759-595-52 IC CXA8070AP CN8104...
  • Page 63 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK Q8126 8-729-010-05 TRANSISTOR MSB709-RT1 R8128 1-218-887-11 METAL CHIP 0.5% 1/10W Q8127 8-729-010-05 TRANSISTOR MSB709-RT1 R8129 1-218-887-11 METAL CHIP 0.5% 1/10W Q8128 8-729-010-29 TRANSISTOR MSD601-RST1 R8130 1-218-908-91 RES CHIP 360K 0.5% 1/10W Q8132 8-729-421-19 TRANSISTOR UN2213 R8131...
  • Page 64 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R8183 1-216-825-11 METAL CHIP 2.2K 5% 1/10W R8700 1-216-853-11 METAL CHIP 470K 5% 1/10W R8186 1-216-825-11 METAL CHIP 2.2K 5% 1/10W R8701 1-216-827-11 METAL CHIP 3.3K 5% 1/10W R8188 1-218-867-11 METAL CHIP 6.8K 0.5% 1/10W R8702 1-216-853-11...
  • Page 65 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK * A-1302-336-A B Board, Complete C3105 1-127-715-91 CERAMIC CHIP 0.22UF C3106 1-127-715-91 CERAMIC CHIP 0.22UF 4-087-203-01 PLASTIC RIVET C3107 1-165-176-11 CERAMIC CHIP 0.047UF 10.00% 16V C3108 1-165-176-11 CERAMIC CHIP 0.047UF 10.00% 16V <...
  • Page 66 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK C3320 1-126-947-11 ELECT 47UF 20.00% 35V C3824 1-164-156-11 CERAMIC CHIP 0.1UF C3321 1-115-758-11 ELECT 470UF 20.00% 16V C3825 1-164-156-11 CERAMIC CHIP 0.1UF C3324 1-164-156-11 CERAMIC CHIP 0.1UF C3826 1-164-156-11 CERAMIC CHIP 0.1UF C3402 1-126-947-11 ELECT...
  • Page 67 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK C3884 1-164-156-11 CERAMIC CHIP 0.1UF L0006 1-414-928-21 INDUCTOR C5503 1-162-927-11 CERAMIC CHIP 100PF 5.00% 50V L0007 1-414-928-21 INDUCTOR C5504 1-218-899-91 RES CHIP 150K 0.5% 1/16W L0008 1-414-928-21 INDUCTOR C5508 1-162-970-11 CERAMIC CHIP 0.01UF 10.00% 25V L3100 1-414-928-21...
  • Page 68 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK Q3806 8-729-010-29 TRANSISTOR MSD601-RST1 R0026 1-216-809-11 METAL CHIP 1/10W Q3807 8-729-010-29 TRANSISTOR MSD601-RST1 R0027 1-216-809-11 METAL CHIP 1/10W Q3808 8-729-010-29 TRANSISTOR MSD601-RST1 R0028 1-216-833-11 METAL CHIP 1/10W Q3811 8-729-010-05 TRANSISTOR MSB709-RT1 R0029 1-216-809-11 METAL CHIP 1/10W...
  • Page 69 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R0085 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R3408 1-216-797-11 METAL CHIP 1/10W R0086 1-216-809-11 METAL CHIP 1/10W R3409 1-216-864-11 SHORT CHIP R0087 1-216-809-11 METAL CHIP 1/10W R3410 1-216-797-11 METAL CHIP 1/10W R0088 1-216-809-11 METAL CHIP 1/10W...
  • Page 70 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R3826 1-216-817-11 METAL CHIP 1/10W R5501 1-216-821-11 METAL CHIP 1/10W R3829 1-216-817-11 METAL CHIP 1/10W R5502 1-216-809-11 METAL CHIP 1/10W R3830 1-216-841-11 METAL CHIP 1/10W R5503 1-216-817-11 METAL CHIP 1/10W R3833 1-216-809-11 METAL CHIP 1/10W R5504...
  • Page 71 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK RB0035 1-233-576-11 RES, CHIP NETWORK 100 C6811 1-162-966-11 CERAMIC CHIP 0.0022UF 10.00% 50V RB0036 1-233-576-11 RES, CHIP NETWORK 100 C6812 1-130-495-00 MYLAR 0.1UF 5.00% 50V C6813 1-126-947-11 ELECT 47UF 20.00% 35V RB0037 1-233-576-11 RES, CHIP NETWORK 100 C6814...
  • Page 72 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK D6814 8-719-063-73 DIODE D1NL20U-TR Q6811 8-729-901-06 TRANSISTOR DTA144EK D6815 8-719-976-99 DIODE DTZ5.1B Q6812 8-729-010-05 TRANSISTOR MSB709-RT1 D6816 8-719-081-98 DIODE MM3Z6V8T1 Q6813 8-729-010-29 TRANSISTOR MSD601-RST1 D6817 8-719-063-70 DIODE D1NL20U Q8900 8-729-010-29 TRANSISTOR MSD601-RST1 D6818 8-719-082-03 DIODE MM3Z15VT1...
  • Page 73 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R6849 1-216-834-11 METAL CHIP 1/10W < TRANSFORMER > R6852 1-216-809-11 METAL CHIP 1/10W R6853 1-216-833-11 METAL CHIP 1/10W T6800 £ 1-453-444-21 TRANSFORMER ASSY, FLYBACK NX-6020//Z214 R6854 1-216-849-11 METAL CHIP 220K 5% 1/10W T8900 1-437-690-11 TRANSFORMER, FERRITE (DFT)
  • Page 74 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK < CONNECTOR > L6009 1-414-181-11 INDUCTOR 4.7UH L6014 1-414-189-31 INDUCTOR 100UH CN6001 £ *1-691-291-11 PIN, CONNECTOR (PC BOARD) 5P CN6002 £ *1-508-786-00 PIN, CONNECTOR (5MM PITCH) 2P < PHOTOCOUPLER > CN6003 £ *1-508-765-00 PIN, CONNECTOR (5MM PITCH) 3P CN6004 £...
  • Page 75 H1 C REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R6049 1-218-869-11 METAL CHIP 8.2K 0.5% 1/10W R2901 1-249-406-11 CARBON 1/4W R6050 1-218-823-11 METAL CHIP 0.5% 1/10W R2902 1-249-406-11 CARBON 1/4W R6054 1-211-981-11 METAL CHIP 0.5% 1/10W R2903 1-249-406-11 CARBON 1/4W R6057 1-216-829-11...
  • Page 76 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK < DIODE > R7304 1-216-813-11 METAL CHIP 1/10W R7306 1-216-864-11 SHORT CHIP D7300 8-719-901-83 DIODE 1SS83 R7307 1-247-807-31 CARBON 1/4W D7301 8-719-901-83 DIODE 1SS83 R7308 1-202-557-00 SOLID 1/2W D7302 8-719-991-33 DIODE 1SS133T-77 R7310 1-216-821-11 METAL CHIP...
  • Page 77 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK < DIODE > C2636 1-165-908-11 CERAMIC CHIP 1UF C2637 1-165-908-11 CERAMIC CHIP 1UF D0981 8-719-109-89 DIODE RD5.6ESB2 C2638 1-126-947-11 ELECT 47UF 20.00% 35V D0983 8-719-082-12 DIODE TLHK5190 C2639 1-126-947-11 ELECT 47UF 20.00% 35V C2655 1-165-908-11 CERAMIC CHIP 1UF...
  • Page 78 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK D2603 8-719-069-60 DIODE UDZSTE-179.1B JR2617 1-216-864-11 SHORT CHIP D2604 8-719-069-60 DIODE UDZSTE-179.1B JR2618 1-216-864-11 SHORT CHIP D2605 8-719-069-60 DIODE UDZSTE-179.1B JR2628 1-216-864-11 SHORT CHIP D2606 8-719-069-60 DIODE UDZSTE-179.1B D2607 8-719-069-60 DIODE UDZSTE-179.1B R0800 1-216-809-11 METAL CHIP...
  • Page 79 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R2647 1-216-853-11 METAL CHIP 470K 5% 1/10W R3658 1-216-837-11 METAL CHIP 1/10W R2648 1-216-821-11 METAL CHIP 1/10W R3659 1-216-821-11 METAL CHIP 1/10W R2649 1-216-837-11 METAL CHIP 1/10W R3660 1-216-841-11 METAL CHIP 1/10W R2650 1-216-837-11 METAL CHIP...
  • Page 80 *4-095-663-31 CUSHION, CRUSHED HONEYCOMB R9425 1-243-572-21 METAL OXIDE *4-095-957-01 PAPER CUSHION R9426 1-216-839-11 METAL CHIP 1/10W R9427 1-216-839-11 METAL CHIP 1/10W 4-095-508-11 INSTRUCTION MANUAL(KV-29FQ85E) (GERMAN/GREEK/TURKISH) R9429 1-216-821-11 METAL CHIP 1/10W 4-095-508-21 INSTRUCTION MANUAL(KV-29FQ85E) R9430 1-216-809-11 METAL CHIP 1/10W (ENGLISH/GERMAN/FRENCH/ITALIAN) R9431...
  • Page 81 • User programmable Functional Check through Infrared • Fast and documented Test Mode setting of all Sony TV chassis Additional features such as Adjustments and Troubleshooting are available in chassis-dependent software modules. Please contact your local Sony Service organisation for the latest information.

This manual is also suitable for:

Kv-29fq85k

Table of Contents