NA-FS80X1 / FS90X1 CONTENT Page 1. Attention in the Repair Work Security 2. Specification 3. Technical Information 3.1 Eco-Wash Systems 4. Operation Panel 4.1 Control Panel and Functions 4.2 Basic Operations and Indications 5. Program Sequences 8 - 19 6. Installation 20 - 21 7.
NA-FS80X1 / FS90X1 1. ATTENTION IN THE REPAIR WORK SECURITY In order to prevent any accident during repair work and ensure security of the product after repair work, somethings surely followed are explained below. ■ The level of the arised damages or dangers, when indicated contents are ignored, are classified by following indications and explained.
NA-FS80X1 / FS90X1 2. SPECIFICATION Model NA-FS80X1 NA-FS90X1 Rate Voltage 220V/50Hz Vietnam Thailand, Indonesia, Vietnam and Frequency Singapore (RBD) 230V/50Hz Singapore (DBD) Singapore (DBD) 230V/60Hz Philippines 240V/50Hz Malaysia Malaysia Rate Power 220~240V/50/60Hz 270~345W (Wash with load) 279~360W (Wash with load)
By rotating a drain tank (tank), water is pushed up through circulation course in a tank (drain tray). to imporve [Water saving circulation system], standard washing quantity of water 116L (NA-FS80X1, FS90X1) is materialized without reducing quantity of circulate water.
NA-FS80X1 / FS90X1 4.2 Basic Operations and Indications Turn on the power supply • When power supply turns on, a lamp of [ Normal ] and [ Wash • Rinse • Spin ] turns on. *When a child lock has been set, the remaining time display shows [CL].
NA-FS80X1 / FS90X1 5. PROGRAM SEQUENCES End Buzzer Brake Spin Intermittent Spin Drain Brake Bubble Clean Flooding Brake Bubble Limit Spin Bubble Limit Indirect Spin Drain Brake Rinse Tank Rotation Penetration Churning Water Supply Brake Water Supply Tank Rotation Brake...
Page 9
NA-FS80X1 / FS90X1 End Buzzer Brake Spin Intermittent Spin Drain Selective Components Water Supply Churning Keep and Churning Churning Without Air Brake Rinse Tank Rotation Brake Rinse Tank Rotation Water Supply Brake Water Supply Tank Rotation Brake Spin Intermittent Spin...
Page 10
NA-FS80X1 / FS90X1 End Buzzer Brake Spin Intermittent Spin Drain Brake Bubble Clean water Supply Brake Bubble Cut Drain Bubble Cut Spin Drain Brake Rinse Tank Rotation Penetration Churning Water Supply Brake Water Supply Tank Rotation Brake Spin Intermittent Spin...
Page 11
NA-FS80X1 / FS90X1 End Buzzer Brake Spin Intermittent Spin Drain Selective Components Water Supply Water Supply Churning Brake Rinse Tank Rotation Brake Rinse Tank Rotation Water Supply Water Supply Tank Rotation Brake Spin Intermittent Spin Brake Rinse Waterfall Brake Spin...
Page 12
NA-FS80X1 / FS90X1 End Buzzer Brake Spin Intermittent Spin Drain Selective Components Keep and Churning Brake Rinse Tank Rotation Brake Rinse Tank Rotation Water Supply Brake Water Supply Tank Rotation Brake Spin Intermittent Spin Drain Selective Components Keep and Churning...
Page 13
NA-FS80X1 / FS90X1 End Buzzer Brake Spin Intermittent Spin Drain Selective Components Water Supply Churning Keep and Churning Brake Rinse Tank Rotation Brake Rinse Tank Rotation Water Supply Brake Water Supply Tank Rotation Brake Spin Intermittent Spin Drain Selective Components...
Page 14
NA-FS80X1 / FS90X1 End Buzzer Brake Drain Intermittent Spin Drain Brake Tank Rotation Inertia Water Supply Tank Rotation Inertia Tank Rotation Inertia Tank Rotation Water Supply Brake Water Supply Tank Rotation Brake Spin Intermittent Spin Drain Brake Tank Rotation Inertia...
Page 15
NA-FS80X1 / FS90X1 End Buzzer Brake Spin Intermittent Spin Drain Brake Inertia Tank Rotation Inertia Tank Rotation Inertia Tank Rotation Inertia Tank Rotation Water Supply Brake Water Supply Tank Rotation Brake Spin Intermittent Spin Drain Brake Inertia Tank Rotation Inertia...
Page 16
NA-FS80X1 / FS90X1 End Buzzer Brake Spin Intermittent Spin Drain Brake Inertia Tank Rotation Inertia Water Supply Tank Rotation Inertia Tank Rotation Inertia Tank Rotation Water Supply Brake Water Supply Tank Rotation Brake Spin Intermittent Spin Drain Brake Tank Rotation...
Page 17
NA-FS80X1 / FS90X1 Brake Brake Rinse Tank Rotation Rinse Tank Rotation Brake Brake Water Supply Water Supply and Rinse and Rinse Brake Brake Rinse Tank Rotation Rinse Tank Rotation Brake Brake Rinse Tank Rotation Rinse Tank Rotation Stir Stir Water Supply...
Page 18
NA-FS80X1 / FS90X1 End Buzzer Flapping Brake Spin Flapping Brake Spin Flapping Brake Spin End Buzzer Brake Brake Spin Spin Intermittent Spin Intermittent Spin Drain Drain Brake Brake Rinse Tank Rotation Rinse Tank Rotation Brake Brake Water Supply Water Supply...
NA-FS80X1 / FS90X1 6. INSTALLATION An Instruction Manual Extract 2 In the case of replacing an interior drainage hose. You can replace position of the interior drainage hose at the rear and the left side depending on a drainage place. Please do not take off the interior drainage hose of the cock side.
Page 21
NA-FS80X1 / FS90X1 6 Confirm Level Check a Level Meter Adjust Inclination horizon ● No need for adjustment Bubble (Front) ● Raise Back is high ● Install rubber sheet. Level Meter ■ In case of protrude greatly Right is high ●...
NA-FS80X1 / FS90X1 7. TABLE OF ERRORS 7.1 Service Check 1. Turn off power supply. Power 2. Hold [washing] and [water level] botton at the same time by one hand. 3. Turn on power supply. Water 4. Release the buttons as referred to above 2, 3 (Check A) volume 5.
Page 23
NA-FS80X1 / FS90X1 The number of pushing Check Check Indication Operation the water level button Sequence Contents Display a history Display [E] initialy, whenever [wash] button is pushed, of the abnormal it turns the last time (22L turns on) the time...
NA-FS80X1 / FS90X1 7.2 Standard Self-Diagnosis Function (Abnormal Information) ※ It displays automatically when it detected an operation mistake or an abnormality during operating. Then stop the operation. ※ The indication of the abnormality detection displays alphabet (U or H) and a number in turn.
Page 25
NA-FS80X1 / FS90X1 An abnormal A check procedure / A cancellation Display Part Detected Contents Contents Measures Method ※ Communication When communication control is • Breaking communication line or Pull a power plug out. line disconnection abnormal between a controller for connector contact error.
NA-FS80X1 / FS90X1 7.3 Troubleshooting of H25, H26 If abnormal indication [H25] and [H26] appeared, perform following trouble diagnosis and specify a trouble part. ● Output measurement point of each geared motor Blue 2 pin connector ① Brown white lead wire ②...
NA-FS80X1 / FS90X1 8. DISASSEMBLY • ASSEMBLY INSTRUCTION Warning Warning ● Please make sure ● To connect the lead wire, use a solderless to pull out a power terminal and tighten it firmly. (Use a specified plug before part, regular bonding pliers) disassembly.
NA-FS80X1 / FS90X1 8.2 Door Lock Switch Illustration Disassembly Procedure ● Necessary tool plus driver ● Replacement of door lock switch (1) Refer to procedure (1) to (4) [replacement for controller display]. (5) Take off panel A sheet (2 screws) Panel sheet A (6) Take off door lock, switch installation screw (2 pieces).
NA-FS80X1 / FS90X1 8.4 Water Supply Valve • Baht Pump • Water Level Sensor • Lid Switch Illustration Disassembly Procedure ● Necessary tool ・minus driver plus driver ● Replacement of water supply valve (1) Open the cover and take off cover hinge axis (each right and left side) ※...
NA-FS80X1 / FS90X1 10. CIRCUIT DIAGRAM 10.1 Electric Circuit Diagram Part with mark is a safety part. Warning Please use specified part for replacment to maintain safety and performance. - 32 -...
NA-FS80X1 / FS90X1 10.2 Controller input • Output Measurement ・ Re-confirm the following output level and resistance at the time of controller replacement. ・ Measure output level by tester while switching a load part ・ Value mentioned below may be changed depend on power supply voltage or an error of the tester.
Important safety notice : Components identified by mark have special characteristics important for safety. When replacing any of these components, use only manufacturer's specified part. 11.2 Replacement Parts List : Part A of NA-FS80X1 / NA-FS90X1 Parts List Model Country / Qty Ref.
NA-FS80X1 / FS90X1 11.4 Replacement Parts List : Part B of NA-FS80X1 / NA-FS90X1 Parts List Model Country / Qty Ref. Part Name Part No. Safety Remark FS80X1 FS90X1 MAL DBD RBD INDO BODY A UNIT AXW001A7JP00 COLOUR : WHITE...
NA-FS80X1 / FS90X1 11.6 Replacement Parts List : Part C of NA-FS80X1 / NA-FS90X1 Parts List Model Country / Qty Ref. FS80X1 FS90X1 MAL DBD RBD INDO INNER LID AXW02007GF00 LID STOPPER A AXW11416RX00 INNER LID,OUTER TUB COVER OUTER TUB COVER...
① Follow a procedure as left figure. Roll up and tuck the case sheet into an inner cover. ② Close a cover. 11.8 Replacement Parts List : Packing Part of NA-FS80X1 / NA-FS90X1 Parts List Model Country / Qty Ref.
NA-FS80X1 / FS90X1 DETAIL CHANGE NOTICE REVISION ITEM NO. PAGE DETAIL REMARK JAN. 2012 ADD PICTURE OF NOISE FILTER PART ASSY SEPARATE ADD PART NAME & PART NO. FOR SALES SUPPLY MAR. 2013 ADD BALANCER PICTURE FOR SALES SEPARATE PART ADD PART NAME AND PART NO.