Service Overview; Notes On Service; Note On Replacement Of Parts; Note On Replacement Of Pr-211 Board - Sony BVP-550 Maintenance Manual

2-1. Notes on Service

2-1-1. Note on Replacement of Parts

Every component electrical part mounted on the PR-211
and CN-1142 boards cannot be replaced. And also a 68-pin
connector on the CN-1120/1121 board cannot be. If there
is any defective part, replace the mounted circuit board
itself.

2-1-2. Note on Replacement of PR-211 Board

The PR-211 board is equipped with a termination board
CN-1142 on it. If replacing the PR-211 board, be sure to
connect the CN-1142 board that was used before to a new
PR-211 board.

2-1-3. Description of EEPROM Data

The table below gives the holding data of EEPROM on
every printed circuit board.
Board Ref. No. Holding data
VA-163 IC26 VA-163 adjustment data
AT-95 IC46 Triming/Reference files
SG-234 IC21 SG-234 adjustment data
DA-88 IC10 DA-88 adjustment data
IF-510 IC155 IF-510 adjustment data
MB-602 IC5 Model name, Serial number of the unit
n
The IC listed above cannot be replaced because it is the
EEPROM that is holding data inherent in the board. The
part number listed in Section 5 "Spare Parts" is for an
EEPROM which is not programmed. If replacement is
needed, consult your Sony representatives.

2-1-4. Extension Boards

The extension boards and harness are available separately
for check or adjustment of some printed circuit boards.
Extension Board/Harness Sony P/N
EX-464 J-6395-040-A VA-163
BVP-550
BVP-550P
Section 2

Service Overview

2-1-5. Notes on Repair Parts

1. w
2. Standardization of Parts
3. Stock of Parts
4. Units Representation
Units
Capacitance
Inductance
Resistance
5. Destination Representation
To be extended
AT-95
SG-234
DA-88
IF-510
Plug-in boards for CA
w w w
w
Safety Related Components Warning
Components marked ! are critical to safe operation.
Therefore, specified parts should be used in the case of
replacement.
Some repair parts supplied by Sony differ from those
used for the unit. These are because of parts common-
ality and improvement.
Parts list has the present standardized repair parts.
Parts marked with "o" at SP(Supply Code) column of
the spare parts list may be not stocked. Therefore, the
delivery date will be delayed.
The following represented units are changed or
omitted in writing.
Representation
µF
uF
µH
uH
Ω
Abbreviation
The part indicated "For UCJ/CE" in the spare parts list
is used in the unit written below.
For UCJ : The part is used in a unit for Japan, U.S.A.
and Canada.
For CE : The part is used in a unit for regions except
the above countries.
2-1 (E)