Page 1
WM-EX2000 3 7 63 1515 0 SERVICE MANUAL E Model Chinese Model Ver 1.0 2000. 10 Tourist Model Manufactured under license from Dolby Laboratories Model Name Using Similar Mechanism Licensing Corporation. Tape Transport Mechanism Type MT-WMEX2000-162 “DOLBY” and the double-D symbol ; are trademarks of Dolby Laboratories Licensing Corporation.
COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINE WITH MARK 0 ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY.
SERVICE NOTE 3 7 63 1515 0 [Service Mode] The service mode enables to operate the mechanism of WM-EX2000 2. PRE-SET status while the MAIN board is opened. The set must be in this state before the PLAY, FF and REW modes Rotation of the idler gear (A) (S side) is detected using the photo- can be entered.
Page 4
http://www.xiaoyu163.com 3 7 63 1515 0 [ Slider (NR) ] slider (NR) F side flywheel F side center R side [ Rotational system ] 2. Rotational System of FF Mode 1. Rotational System of PLAY Mode idler gear (A) (S side) gear (reel) (T side) idler gear (A) (T side) gear (reel) (T side)
http://www.xiaoyu163.com SECTION 3 DISASSEMBLY 3 7 63 1515 0 • The equipment can be removed using the following procedure. Ornament (OPEN) "Switch, Leaf (S704)" Lid Assy, Cassette Case Block Assy Belt (F0), Motor (M601) Block Assy Main Board Holder Assy Pinch Lever (N2)/(R2) Assy Magnetic Head (HP701) Note :...
http://www.xiaoyu163.com 3 7 63 1515 0 3-5. BELT (F0), MOTOR (M601) 1 Belt (F0) × 2 Two screws (M1.4 2.7) 4 Motor (M601) 3 Retainer (F1) motor Belt (F0) L 13942296513 3-6. HOLDER ASSY 8 Screw (M1.4 × 2) 0 Bracket (cassette) assy qa Remove soldering from Head flexible board.
http://www.xiaoyu163.com 3 7 63 1515 0 3-7. PINCH LEVER (N2)/(R2) ASSY Claw 2 Remove the pinch lever (N2) assy in the direction of the arrow. Note: Be careful of the claw Claw 1 Remove the pinch lever (R2) assy in the direction of the arrow.
WM-EX2000 3 7 6 3 1 5 1 5 0 6-4. SCHEMATIC DIAGRAM MAIN (2/2) SECTION • Refer to page 22 for IC Block Diagrams. • Refer to page 23 for IC Pin Function Description. • Waveform IC601 456...
http://www.xiaoyu163.com 3 7 63 1515 0 6-5. IC BLOCK DIAGRAMS IC301 TA2123AF 36 35 32 31 28 27 26 – CAMP SW RF IN MT TC PW GND – BEEP PW OUT R BEEP AMS OUT PW OUT C NT SW PW OUT L –...
Page 14
http://www.xiaoyu163.com 3 7 63 1515 0 IC601 LB1994M M CENTER BUFFER COMPARATOR BUFFER 13 PW P-SIG COMPARATOR D/DT PULSE 12 CI 11 Vref POWER W OUT CURRENT V OUT U OUT SOFT CLIP 10 P SIG PW•SW CTRL BLOCK DECODER 4 5 6 L 13942296513 IC703 MM1305BWBE...
http://www.xiaoyu163.com SECTION 7 EXPLODED VIEWS 3 7 63 1515 0 NOTE: • -XX, -X mean standardized parts, so they may • Hardware (# mark) list and accessories and have some differences from the original one. packing materials are given in the last of this parts •...
http://www.xiaoyu163.com SECTION 8 MAIN ELECTRICAL PARTS LIST 3 7 63 1515 0 NOTE: • Due to standardization, replacements in the • RESISTORS • SEMICONDUCTORS parts list may be different from the parts All resistors are in ohms. In each case, u: µ, for example: specified in the diagrams or the components METAL: metal-film resistor uA...: µA...
Page 19
http://www.xiaoyu163.com MAIN 3 7 63 1515 0 Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks < IC > R106 1-218-955-11 RES-CHIP 1.5K 1/16W R107 1-218-955-11 RES-CHIP 1.5K 1/16W IC301 8-759-579-12 IC TA2123AF(EL) R108 1-218-969-11 RES-CHIP 1/16W IC302 8-759-597-24 IC NJM2190V(TE2) R109...