Table of Contents
Advertisement
Mini System
From week 619 onwards, the DVD Drive was changed from KSM310AAA to DM3151-B. New
MPEG Board and Display Borad Assy are used to match with the new DVD Drive.
Please refer chapter 6 to 12 for sets produced before week 618 and
chapter 13 to 19 for sets produced in or after week 619.
©
Copyright 2005 Philips Consumer Electronics B.V. Eindhoven, The Netherlands
All rights reserved. No part of this publication may be reproduced, stored in a retrieval
system or transmitted, in any form or by any means, electronic, mechanical, photocopying,
or otherwise without the prior permission of Philips.
Published by YT 0747 Service Audio
Version 3.0
Subject to modification
FWD16, FWD17
all versions
© 3141 785 30412
Advertisement
Table of Contents
Related Manuals for Philips FWD16 series
Summary of Contents for Philips FWD16 series
- Page 1 13 to 19 for sets produced in or after week 619. © Copyright 2005 Philips Consumer Electronics B.V. Eindhoven, The Netherlands All rights reserved. No part of this publication may be reproduced, stored in a retrieval system or transmitted, in any form or by any means, electronic, mechanical, photocopying, or otherwise without the prior permission of Philips.
-
Page 2: Table Of Contents
TABLE OF CONTENTS Handling chip components ........1-1 Service tools ............1-1 Leadfree and safety information ......1-2 Technical specification ..........2-1 Service measurement setup ........2-2 Connections and controls ........3-1...3-5 Disassembly diagram ........4-1...4-2 Service Test Program ..........5-1 For sets produced before week 618 For sets produced in or after week 618 (GW1006180xxxxx) (GW2006190xxxxx up) -
Page 3: Handling Chip Components
1 - 1 HANDLING CHIP COMPONENTS... - Page 4 1 - 2...
- Page 5 : 4 Hz - 20 kHz (44.1kHz) 4 Hz - 22 kHz (48kHz) TUNER - FM SECTION 4 Hz - 44 kHz (96kHz) Digital Output : SPDIF (Sony Philips Tuning range : 87.5 – 108.5 MHz digital interface) Coaxial IF frequency : 10.7 MHz ±...
-
Page 6: Service Measurement Setup
2 - 2 SERVICE MEASUREMENT Tuner FW Bandpass LF Voltmeter 250Hz-15kHz e.g. PM2534 e.g. 7122 707 48001 RF Generator e.g. PM5326 S/N and distortion meter e.g. Sound Technology ST1700B Use a bandpass filter to eliminate hum (50Hz, 100Hz) and disturbance from the pilottone (19kHz, 38kHz). Tuner AM (MW,LW) Bandpass LF Voltmeter... -
Page 7: Connections And Controls
3 - 1 CONNECTION AND CONTROLS... - Page 8 3 - 2 CONNECTION AND CONTROLS...
- Page 9 3 - 3 CONNECTION AND CONTROLS...
- Page 10 3 - 4 CONNECTION AND CONTROLS...
- Page 11 3 - 5 CONNECTION AND CONTROLS For more information onoperation instruction please visit Philips Audio internet site : http://www.p4c.philips.com...
- Page 12 4 - 1 4 - 1 DISASSEMBLY INSTRUCTION A. Remove Top Cover B. Remove Cassette mechanism D. Remove Cassette mechanism A1 remove screws M3x6 - 4 pcs. B1 remove screws T3x10 - 4 pcs. D1 remove screws M3x6 - 6 pcs. A2 remove screws M3x6 - 4 pcs.
- Page 13 4 - 2 4 - 2 DISASSEMBLY INSTRUCTION F. Remove DVD / MPEG board G. Remove Front Panel Assembly H. Remove Front Panel Assembly F1 remove screws M3x6 - 4 pcs. G1 remove screws M3x6 - 1 pc. H1 remove screws M3x8 (+ fi bre washers) - 9 pc. G2 remove screws M3x8 (C-head) - 2 pc.
-
Page 14: Service Test Program
5 - 1 5 - 1 SERVICE TEST PROGRAM To enter Service Test program, hold PLAY & STOP buttons depressed while switch the source to DISC. Display shows BLANK VERSION MACROVISION DISPLAY TEST CHECK CHECK FACTORY RESET REPEAT PLAY PLAY SHUFFLE STOP button pressed? -
Page 15: Block Diagram
6 - 1 6 - 1 SET BLOCK DIAGRAM... -
Page 16: Wiring Diagram
6 - 2 6 - 2 SET WIRING DIAGRAM... -
Page 17: Circuit Diagram
7 - 1 7 - 1 CIRCUIT DIAGRAM - DISPLAY / TUNER BOARD... -
Page 18: Layout Diagram
7 - 2 7 - 2 LAYOUT DIAGRAM - DISPLAY / TUNER BOARD COMPONENT SIDE COPPER SIDE... -
Page 19: Circuit Diagram
8 - 1 8 - 1 CIRCUIT DIAGRAM - MAIN AND POWER BOARD... -
Page 20: Layout Diagram
8 - 2 8 - 2 LAYOUT DIAGRAM - MAIN AND POWER BOARD (SIDE A) - Page 21 8 - 3 8 - 3 LAYOUT DIAGRAM - MAIN BOARD (SIDE B)
-
Page 22: Circuit Diagram
9 - 1 9 - 1 CIRCUIT DIAGRAM - CASSETTE BOARD 1709 T701 R IN 1725 T721 L IN PLAY RECORD 3723 3722 T702 1707 3701 T705 + TAPE 100R 3749 3748 2707 2706 T707 R OUT 220u 3707 3726 T708 L OUT 470k... - Page 23 9 - 2 9 - 2 LAYOUT DIAGRAM - CASSETTE BOARD 71 A 1 2729 C 5 3733 B 2 9756 C 3 72 D 5 2730 D 1 3734 D 5 9757 D 3 73 A 5 2731 C 1 3735 D 3 9759 D 4 74 A 1...
-
Page 24: Circuit Diagram
10 - 1 10 - 1 CIRCUIT DIAGRAM - DVD MPEG BOARD... - Page 25 10 - 2 10 - 2 LAYOUT DIAGRAM - DVD MPEG BOARD...
- Page 26 10 - 3 10 - 3 LAYOUT DIAGRAM - DVD MPEG BOARD...
-
Page 27: Exploded View Diagram
11 - 1 11 - 1 EXPLODED VIEW DIAGRAM... -
Page 28: Mechanical Partslist
11 - 2 ACCESSORIES 9940 000 02594 REMOTE CONTROL (FWD17) 9940 000 02595 AM LOOP ANT 9940 000 02596 RCA CABLE COMP VIDEO (R/B/G) 9940 000 02597 RCA CABLE VIDEO (YELLOW) 9940 000 02598 RCA CABLE AUDIO (RED/WHITE) 9940 000 02599 SPEAKER BOX 4"... -
Page 29: Electrical Partslist
12 - 1 ELECTRICAL PARTS LIST MAIN BOARD ASSEMBLY (con'd) FRONT / TUNER PCB ASSEMBLY D509 9940 000 02645 DIODE SCHOTTKY SS14 JK701 9940 000 02696 MICROPHONE JACK Q502 9940 000 02647 TRANS 2SB1370PNP S201 9940 000 02679 TACT SWITCH Q503 9940 000 02649 TRANS 2SC5343 NPN S202... -
Page 30: Block Diagram
13 - 1 13 - 1 SET BLOCK DIAGRAM... -
Page 31: Wiring Diagram
13 - 2 13 - 2 SET WIRING DIAGRAM... -
Page 32: Circuit Diagram
14 - 1 14 - 1 CIRCUIT DIAGRAM - DISPLAY / TUNER BOARD VR701... -
Page 33: Layout Diagram
14 - 2 14 - 2 LAYOUT DIAGRAM - DISPLAY / TUNER BOARD COMPONENT SIDE COPPER SIDE... -
Page 34: Circuit Diagram
15 - 1 15 - 1 CIRCUIT DIAGRAM - MAIN AND POWER BOARD... -
Page 35: Layout Diagram
15 - 2 15 - 2 LAYOUT DIAGRAM - MAIN AND POWER BOARD (SIDE A) - Page 36 15 - 3 15 - 3 LAYOUT DIAGRAM - MAIN BOARD (SIDE B)
-
Page 37: Circuit Diagram
16 - 1 16 - 1 CIRCUIT DIAGRAM - CASSETTE BOARD 1709 T701 R IN 1725 T721 L IN PLAY RECORD 3723 3722 T702 1707 3701 T705 + TAPE 100R 3749 3748 2707 2706 T707 R OUT 220u 3707 3726 T708 L OUT 470k... -
Page 38: Layout Diagram
16 - 2 16 - 2 LAYOUT DIAGRAM - CASSETTE BOARD 71 A 1 2729 C 5 3733 B 2 9756 C 3 72 D 5 2730 D 1 3734 D 5 9757 D 3 73 A 5 2731 C 1 3735 D 3 9759 D 4 74 A 1... - Page 39 17 - 1 17 - 1 CIRCUIT DIAGRAM - DVD MPEG BOARD (Part 1) i l p o i t i l p o i t t ' n < - - - - < - - - - < - - - <...
- Page 40 17 - 2 17 - 2 CIRCUIT DIAGRAM - DVD MPEG BOARD (Part 2) v i r v i r i f i l o l l e t I &...
- Page 41 17 - 3 17 - 3 CIRCUIT DIAGRAM - DVD MPEG BOARD (Part 3) < l e t...
- Page 42 17 - 4 17 - 4 CIRCUIT DIAGRAM - DVD MPEG BOARD (Part 4)
- Page 43 17 - 5 17 - 5 LAYOUT DIAGRAM - DVD MPEG BOARD...
-
Page 44: Exploded View Diagram
18 - 1 18 - 1 EXPLODED VIEW DIAGRAM... -
Page 45: Mechanical Partslist
18 - 2 ACCESSORIES 9940 000 02594 REMOTE CONTROL FOR FWD17 9940 000 02595 AM LOOP ANT 9940 000 02596 RCA CABLE COMP VIDEO (R/B/G) 9940 000 02597 RCA CABLE VIDEO (YELLOW) 9940 000 02598 RCA CABLE AUDIO (RED/WHITE) 9940 000 02599 SPEAKER BOX 6 OHM 30W (For FWD17/21M only) MECHANICAL PARTS LIST... -
Page 46: Electrical Partslist
19 - 1 ELECTRICAL PARTS LIST MISCELLANEOUS T401 9940 000 02659 POWER TRANSFORMER,110/230V 9965 000 40072 SERVO/MPEG PWB ASSY FWD17A 9965 000 40073 DISP/TUN/MIC PWB ASSY FWD17A MAIN BOARD ASSEMBLY JK601 9940 000 02637 SPEAKER JACK PST-403 JK602 9940 000 02638 JACK RCA (RED/WHITE) JK603 9940 000 02643... - Page 47 19 - 2 ELECTRICAL PARTS LIST SERVO AND MPEG PWB ASSEMBLY 9965 000 40075 IC ZR36862PQCG DVD MPEG DECODE 9940 000 02667 IC 16M SDRAM K4S161622H-UC60 9940 000 02667 IC 16M SDRAM K4S161622H-UC60 9940 000 02668 IC SST39VF800A-70-4C-EK 8M 9965 000 40076 IC LM358 9965 000 40077 IC BA5888FP MOTOR DRIVER...
- Page 48 19 - 3 ELECTRICAL PARTS LIST FRONT PANEL PCB ASSEMBLY JK701 9940 000 02696 MICROPHONE JACK PPJ 35G-01 L301 9940 000 02687 FM COIL 4.5TX5X0.6MM L302 9940 000 02688 FM OSC COIL 2.5TX0.4MM L303 9940 000 02687 FM COIL 4.5TX5X0.6MM T301 9940 000 02689 FM DETECT IFT BLACK 7MM...
-
Page 49: Revision
20 - 1 REVISION LIST Version 1.0 (3141 785 30410) • First issue Version 1.1 (3141 785 30411) From week 619 onwards, the DVD Drive was changed from KSM310AAA to DM3151-B. New MPEG Board and Display Borad Assy are used to match with the new DVD Drive. •...