All rights reserved. No part of this publication may be reproduced, stored in a retrieval system or transmitted, in any form or by any means, electronic, mechanical, photocopying, or otherwise without the prior permission of Philips. Published by WO 0472 Service PaCE...
EN 4 FTL13U AA & AB Safety Instructions, Warnings, and Notes 2. Safety Instructions, Warnings, and Notes Index of this chapter: Service Default Mode (see chapter 5) with a colour bar 2.1 Safety Instructions signal and stereo sound (L: 3 kHz, R: 1 kHz unless stated 2.2 Warnings...
)pressure inside the body. If the packaging was opened before usage, the IC has to be heated up for some hours Philips CE is going to produce lead-free sets (PBF) from (around 90°C) for drying (think of ESD-protection!). 1.1.2005 onwards.
Mechanical Instructions FTL13U AA & AB EN 17 4. Mechanical Instructions or falling. They can be mounted and removed quickly and Index of this chapter: 4.1 Service Positions easily with use of the provided screws, which can be tightened 4.2 Assy/PWB Removal and loosened manually without the use of tools.
Page 18
EN 18 FTL13U AA & AB Mechanical Instructions 4.2.3 Main switch/LED panel 4.2.5 Audio Amplifier CL 36532064_051.eps 161003 Figure 4-4 Main switch/LED panel 1. Disconnect the cable on the rear of the panel. CL 36532064_053.eps 2. Remove the two fixing screws (1).
Page 19
Mechanical Instructions FTL13U AA & AB EN 19 4.2.7 Main Power Supply 4.2.8 LCD Panel CL 36532064_057.eps 201003 CL 36532064_055.eps Figure 4-10 LCD panel 161003 Figure 4-8 Wall mounting bracket Make sure that the power is switched “off” and that all necessary cables are disconnected.
Service Default Mode (SDM) and Service Alignment Mode 5.2.2 Service Alignment Mode (SAM) (SAM) offer several features for the service technician, while the Customer Service Mode (CSM) is used for communication between a Philips Customer Care Center (P3C) and a Purpose customer. • To perform (software) alignments.
Page 21
(for more details, see paragraph Software downloading). development analysis, before initializing. This will give the Philips Service department an extra possibility for You will find details of the software versions in the chapter diagnosis (e.g. when Development asks for this).
Page 22
EN 22 FTL13U AA & AB Service Modes, Error Codes, and Fault Finding CUSTOMER SERVICE MENU 2 • ON TIMER. Indicates if the “On Timer” is set “ON” or “OFF” • COLOUR. Gives the last status of the color saturation, as and if the timer is “ON”...
Page 23
"127" or higher, and the value is also high on other programs, check the aerial cable/aerial system. For some ComPair (Computer Aided Repair) is a service tool for Philips software versions, the noise figure will only be valid when Consumer Electronics products. ComPair is a further “Active Control”...
Page 24
EN 24 FTL13U AA & AB Service Modes, Error Codes, and Fault Finding Beside fault finding, ComPair provides some additional features like: • Up- or downloading of pre-sets. • Managing of pre-set lists. • Emulation of the Dealer Service Tool (DST).
Page 25
Service Modes, Error Codes, and Fault Finding FTL13U AA & AB EN 25 ON/OFF switch to ON OTC gets supply voltage OTC resets, Initialise IO pins Read NVM identification enable watchdog start time extraction Stand-by stand-by bit = off t<500ms Step 1 t<250ms...
Page 26
EN 26 FTL13U AA & AB Service Modes, Error Codes, and Fault Finding Note (*): When an error occurs and the error buffer is full, then the new • When the set is in stepwise mode and, due to stepping-up,...
Page 27
Service Modes, Error Codes, and Fault Finding FTL13U AA & AB EN 27 Table 5-1 Error Table Error Device Description Def. item Def. Module indication Diagram M24C32 NVM, spontaneous blinking error 1 7011 Control SAA4978 PICNIC 7713 Feature Box Supply 5 V...
Page 28
EN 28 FTL13U AA & AB Service Modes, Error Codes, and Fault Finding 5.7.4 Hardware Protection DC_PROT (from audio) IRQ-DIGITAL (98) Short-circuiting the 3V3 supply from the DC/DC converter will shut down the DC/DC converter. The absence of the 3V3...
Page 29
Service Modes, Error Codes, and Fault Finding FTL13U AA & AB EN 29 5.8.3 Protections 5.8.4 Power Supply Activating SDM via the “service pads” will overrule the The simplest way to repair the power supply is to check (and processor-controlled protections, but not the hardware replace if necessary) the components that are marked gray on protections.
Page 30
EN 30 FTL13U AA & AB Service Modes, Error Codes, and Fault Finding Personal Notes: E_06532_012.eps 131004...
Wiring Diagram, Block Diagrams, and Overviews FTL13U AA & AB 6. Wiring Diagram, Block Diagrams, and Overviews Wiring Diagram 1345 Topcontrol LCD Panel LCD Panel 0304 0303 Audio Amplifier Class D Aux Supply amplifier HIGH HIGH Backlight Supply Connector LCD Panel...
Wiring Diagram, Block Diagrams, and Overviews FTL13U AA & AB Testpoint Overview Aux and Power Supply AUX SUPPLY (TRACK SIDE VIEW) POWER SUPPLY (TRACK SIDE VIEW) 1355 1333 1346 1370 1309 400V_HOT 1309 7005 7011 400V_HOT 6021 5002 MAINS TRAFO...
Wiring Diagram, Block Diagrams, and Overviews FTL13U AA & AB Testpoint Overview Small Signal Board SSB side B SSB side A 1E02 7E02 7D57 7L02 A/D CONVERTOR A/D CONVERTOR (2FH) 7E09 (FOR OSD) EPLD 1E03 FLASH EPLD 7L01 7V01 7D51...
Page 47
Circuit Diagrams and PWB Layouts FTL13U AA & AB Small Signal Board (AA): Connector 0005 G1 2S01 F1 2S07 F14 2S13 F9 2S19 G6 2S26 G4 2S32 G5 2S38 G2 2S44 G3 2S50 I15 3S01 F10 3S07 D12 3S15 G8...
Page 48
Circuit Diagrams and PWB Layouts FTL13U AA & AB Small Signal Board (AA): IF, I/O Videoprocessing 1305 E11 3462 D14 1306 E12 3463 B5 1307 E12 3468 H11 1308 E13 3473 D11 IF,I/O VIDEOPROCESSING 1403 A1 3474 F9 1406 E5...
Page 49
Circuit Diagrams and PWB Layouts FTL13U AA & AB Small Signal Board (AA): Feature Box (PICNIC) 1702 J5 3834 H17 2701 B2 3835 D3 2702 B2 3836 I17 FEATURE BOX (PICNIC) 2703 C2 3837 B11 2704 C2 3845 J14 2705 D2...
Page 50
Circuit Diagrams and PWB Layouts FTL13U AA & AB Small Signal Board (AA): Falconic 2776 I12 2780 I1 FALCONIC 2782 I3 PHILIPS 2784 E1 4721 2785 D4 4722 4723 2786 E4 4724 2787 F4 4712 4713 2788 E4 4714 2789 I6...
Page 51
Circuit Diagrams and PWB Layouts FTL13U AA & AB Small Signal Board (AA): Eagle 2709 C6 3792 C13 FF63 D7 2710 D6 3793 A6 FF64 G12 2711 E7 3800 G8 IF51 A8 +5VA +3V3A +1V5FCC +3V3FCD EAGLE 2712 A7 3801 H10...
Page 52
Circuit Diagrams and PWB Layouts FTL13U AA & AB Small Signal Board (AA): 2FH Interface 2724 E2 2842 A6 2858 E5 3700 A2 3723 C5 3796 E3 3799 E4 3848 F6 3852 E3 3856 F1 5702 D5 6846 E3 7743 A5...
Page 53
Circuit Diagrams and PWB Layouts FTL13U AA & AB Small Signal Board (AA): HOP 1301 G4 3344 E10 7316 B12 1304 H3 3345 D9 7317 C12 2301 C2 3346 D9 7318 E10 (NOT USED, UNLESS OTHERWISE INDICATED) 2303 F9 3347 D9...
Page 54
Circuit Diagrams and PWB Layouts FTL13U AA & AB Small Signal Board (AA): OTC-Flash 1001 F4 3031-C D13 3078-D A3 FC06 B7 +5V_CON +8V_CON FC57 FC60 +3V3_INTOTC 1401 H12 3031-D C13 3079 D3 FC07 C8 +3V3_INTOTC +3V3_INTOTC +3V3_INTOTC 2031 FC01...
Page 55
Circuit Diagrams and PWB Layouts FTL13U AA & AB Small Signal Board (AA): Backlight Control Small Signal Board (AA): OTC-Flash 1402 C1 2C02 D3 3C03 B2 3C06-A B4 3C06-D C4 3C07-C C4 7017 B2 9C00 A2 FC62 F3 FC65 C1...
Page 56
Circuit Diagrams and PWB Layouts FTL13U AA & AB Small Signal Board (AA): Audio Demodulator 1A00 G7 2A92 I6 5A13 H1 2A00 A3 2A93 I12 5A14 I1 2A01 B2 2A94 I12 5A15 I1 AUDIO DEMODULATOR 2A02 B1 2A95 I11 5A16 C13...
Page 57
Circuit Diagrams and PWB Layouts FTL13U AA & AB Small Signal Board (AA): Dolby Digital Decoder 2AD0 B6 2AD1 B6 2AD3 B4 2AD4 B6 (NOT USED) DOLBY DIGITAL DECODER 2AD5 B5 2AD6 B6 2AE2 D8 2AE3 D7 2AE4 D2 2AE5 D7...
Page 58
Circuit Diagrams and PWB Layouts FTL13U AA & AB Small Signal Board (AA): Dolby Pro Logic Processor 2AB9 D1 7A61-B B10 2AC0 E1 7A62-A E12 2AD7 B2 7A62-B D10 DOLBY PRO LOGIC PROCESSOR (NOT USED) 2AD8 H12 7A63 C3 2AD9 B2...
Page 59
Circuit Diagrams and PWB Layouts FTL13U AA & AB Small Signal Board (AA): 3D-Comb Filter 1B01 C10 2B06 C4 2B13 E4 2B20 A8 2B27 C10 2B34 E9 2B46 C2 2B56 C1 3B05 B3 3B12 A7 3B20 D2 3B27 D9 5B01 C2...
Page 60
Circuit Diagrams and PWB Layouts FTL13U AA & AB Small Signal Board (AA): DC/DC-Convertor 1U01 A2 2U07 D4 2U15 A2 2U23 D12 2U32 D2 3U05 C4 3U13 D6 3U21 E3 3U29 C3 3U37 F9 3U45 E2 5U02 A2 6U04 B5...
Page 61
Circuit Diagrams and PWB Layouts FTL13U AA & AB Small Signal Board (AA): Tun1/Tun2 1T01 C2 2T02 D9 2T05 C1 2T09 D3 2T13 B2 2T16 D10 3T03 B2 3T06 D6 6T01 B2 6T04 B7 6T08 D5 9T02 B7 9T05 D2...
Page 62
Circuit Diagrams and PWB Layouts FTL13U AA & AB Small Signal Board (AA): I/O US 0001 H4 0002 H3 0003 H2 1I02 H12 1I70 H6 2I01 G5 2I02 C4 I/O US 2I03 C4 2I04 D4 2I05 D4 2I06 E4 2I07 F4...
Page 63
Circuit Diagrams and PWB Layouts FTL13U AA & AB Small Signal Board (AA): I/O US V00 L18 1I10 D19 1I26 B3 1I44 E14 1I55 K4 2I10 B4 2I26 F3 2I35 K3 2I46 K21 2IC9 C15 3I49 C4 3I78 C15 3I91 G3...
Page 64
Circuit Diagrams and PWB Layouts FTL13U AA & AB Small Signal Board (AA): 2FH I/O 1I07 F11 FIB2 F10 1I15 G4 FIB3 H4 1I65 F11 FIB5 F13 1I66 F13 FIB6 F11 1I67 F12 FIB7 F11 1I68 G3 II50 G2 1I69 H3...
Page 65
Circuit Diagrams and PWB Layouts FTL13U AA & AB Small Signal Board (AA): Audio I/O 2I71 B2 2I72 B2 2I73 B2 2I74 B2 2I75 B2 2I76 B3 B1 --> B20 2I77 C1 AUDIO I/O 2I78 C1 2I79 C1 2I80 D2...
Page 66
Circuit Diagrams and PWB Layouts FTL13U AA & AB Small Signal Board (AA): PIP-HIP 1000-A E1 3P12 E2 9P20 F11 1P00 E11 3P13 F2 9P21 G11 PIP - HIP 1P01 E12 3P14 F5 9P22 G11 1P02 E13 3P15 G5 9P23 I6...
Page 67
Circuit Diagrams and PWB Layouts FTL13U AA & AB Small Signal Board (AA): PIP 1P50 D2 2P53 E2 2P57 G5 2P61 E6 2P65 G9 2P69 H9 2P73 D8 2P77 D4 2P81 E14 2P85 F10 2P90 D5 3P53 E2 3P57 G5...
Page 68
Circuit Diagrams and PWB Layouts FTL13U AA & AB Small Signal Board (AA): PIP-Muppet 2PA0 B4 2PA7 D4 2PB4 G4 2PC1 B6 2PC8 C8 2PD5 B10 2PE2 E13 2PE9 D13 2PF8 G5 3PA5 H12 3PB2 D1 3PB9 F2 3PC6 G4...
Page 69
Circuit Diagrams and PWB Layouts FTL13U AA & AB Small Signal Board (AA): DVI RGB 0004 I3 FD65 H5 1D07 H2 FD66 H7 2D51 B3 FD67 H7 DVI RGB REF2 2D52 C3 FD69 C8 2D53 B9 FD70 D9 +8V-VIDEO B1-B20...
Page 70
Circuit Diagrams and PWB Layouts FTL13U AA & AB Small Signal Board (AA): DVI Receiver 1V21 F1 1V27 H3 1V48 F8 2V26 D18 2V33 D22 2V41 G18 2V50 H23 2V57 K22 2V63 N23 2V71 H15 2V79 N26 3V25 N24 3V33 K15...
Page 71
Circuit Diagrams and PWB Layouts FTL13U AA & AB Small Signal Board (AA): HDI A/D Convertor 2L01 A1 5L10 E3 2L02 A2 5L11 F3 2L03 A2 5L12 F3 HDI A/D CONVERTOR 2L04 A2 5L13 A1 2L05 A2 5L14 B1 2L06 A3...
Page 72
Circuit Diagrams and PWB Layouts FTL13U AA & AB Small Signal Board (AA): EPLD Control 1E02 A8 1E04 G8 2D02 G11 2D03 E11 2D04 F2 EPLD CONTROL 2D08 G5 2D15 I7 2D21 I3 2D22 I3 3E77 2E50 E3 2E51 E2...
Page 73
Circuit Diagrams and PWB Layouts FTL13U AA & AB Small Signal Board (AA): EPLD OSD 2E02 B3 3E48 E1 2E04 A4 3E49 C1 2E05 E3 3E90 B1 2E09 G3 3E91 D1 2E10 A4 3E92 G1 EPLD OSD +5VA-OSD 2E11 I3...
Page 74
Circuit Diagrams and PWB Layouts FTL13U AA & AB Small Signal Board (AA): EPLD I/O 2V05 C1 2V06 B13 2V07 A11 2V08 A12 2V09 A12 2V10 A11 2V11 C4 EPLD I/O 2V12 D4 +3V3-EPLD +3V3-EPLD +3V3-EPLD 2V13 D5 2V14 C13...
Page 75
Circuit Diagrams and PWB Layouts FTL13U AA & AB Small Signal Board (AA): I/O 2 1Y01 C8 2Y00 C2 2Y03 A9 2Y06 B9 2Y09 B9 2Y12 B9 3Y02 B3 3Y05 B3 5Y01 B7 5Y04 C7 7Y00 B2 FY02 B8 FY05 B8...
Page 76
Circuit Diagrams and PWB Layouts FTL13U AA & AB Layout Small Signal Board (AA) (Top Side Overview) PART 2 CL 36532064_48b.eps PART 1 CL 36532064_48a.eps PART 4 CL 36532064_48d.eps PART 3 CL 36532064_48c.eps 3104 303 3860.4 CL 36532064_048.eps 221003...
Page 77
Circuit Diagrams and PWB Layouts FTL13U AA & AB Mapping Small Signal Board (AA) (Top Side Overview) Personal Notes: 1001 C7 2394 C5 2A13 E5 2D04 E9 2P17 C2 2Y02 F7 3739 E6 3AB5 E4 3L01 A8 3U31 E8 5PA2 C3...
Page 78
Circuit Diagrams and PWB Layouts FTL13U AA & AB Layout Small Signal Board (AA) (Top Side Part 1) Part 1 of 3104 303 3860.4 CL 36532064_48a.eps 221003...
Page 79
Circuit Diagrams and PWB Layouts FTL13U AA & AB Layout Small Signal Board (AA) (Top Side Part 2) Part 2 of 3104 303 3860.4 CL 36532064_48b.eps 221003...
Page 80
Circuit Diagrams and PWB Layouts FTL13U AA & AB Layout Small Signal Board (AA) (Top Side Part 3) Part 3 of 3104 303 3860.4 CL 36532064_48c.eps 221003...
Page 81
Circuit Diagrams and PWB Layouts FTL13U AA & AB Layout Small Signal Board (AA) (Top Side Part 4) Part 4 of 3104 303 3860.4 CL 36532064_48d.eps 221003...
Page 82
Circuit Diagrams and PWB Layouts FTL13U AA & AB Layout Small Signal Board (AA) (Bottom Side Overview) PART 1 PART 2 CL 36532064_49a.eps CL 36532064_49b.eps PART 3 CL 36532064_49c.eps PART 4 CL 36532064_49d.eps CL 36532064_049.eps 3104 303 3860.4 221003...
Page 83
Circuit Diagrams and PWB Layouts FTL13U AA & AB Mapping Small Signal Board (AA) (Top Side Overview) Personal Notes: 1301 C5 2769 E3 2B51 E9 2L17 C1 2S42 B6 3095 C4 3A35 D6 3I90 A2 3P46 C8 5A05 E6 6I92 A3...
Page 84
Circuit Diagrams and PWB Layouts FTL13U AA & AB Layout Small Signal Board (AA) (Bottom Side Part 1) Part 1 of 3104 303 3860.4 CL 36532064_49a.eps 221003...
Page 85
Circuit Diagrams and PWB Layouts FTL13U AA & AB Layout Small Signal Board (AA) (Bottom Side Part 2) Part 2 of 3104 303 3860.4 CL 36532064_49b.eps 221003...
Page 86
Circuit Diagrams and PWB Layouts FTL13U AA & AB Layout Small Signal Board (AA) (Bottom Side Part 3) Part 3 of 3104 303 3860.4 CL 36532064_49c.eps 221003...
Page 87
Circuit Diagrams and PWB Layouts FTL13U AA & AB Layout Small Signal Board (AA) (Bottom Side Part 4) Part 4 of 3104 303 3860.4 CL 36532064_49d.eps 221003...
Circuit Diagrams and PWB Layouts FTL13U AA & AB Small Signal Board (AB): HOP 1301 G4 3343 D12 7314 A10 1304 G3 3344 D10 7315 B10 2301 B2 3345 D9 7316 A12 2303 E9 3346 C9 7317 B12 2304 G7...
Page 90
Circuit Diagrams and PWB Layouts FTL13U AA & AB Small Signal Board (AB): OTC Flash OTC-FLASH 1001 G4 3031-C D13 3078-D B3 FC02 A7 1401 I12 3031-D D13 3079 E3 FC03 B7 +5V_CON +8V_CON FC57 FC60 +3V3_INTOTC +3V3_INTOTC +3V3_INTOTC 2002 G3...
Page 91
Circuit Diagrams and PWB Layouts FTL13U AA & AB Small Signal Board (AB): Backlight Control Small Signal Board (AB): OTC-Flash 2063 C3 3023 C1 3030 A2 3036 A4 7020 B2 7021-2 B4 3022 A1 3028 B2 3032 B3 3037 C4...
Page 92
Circuit Diagrams and PWB Layouts FTL13U AA & AB Small Signal Board (AB): Tun1 / Tun2 1T01 C2 2T02 D9 2T05 C1 2T09 D3 2T13 B2 2T16 D10 2T19 B2 3T04 B6 5T02 C5 6T02 B6 6T06 D10 7T01 C5...
Page 93
Circuit Diagrams and PWB Layouts FTL13U AA & AB Small Signal Board (AB): I/O Eur 0001 H4 I/O US 0002 H3 B14A B14A 0003 H2 1I02 H12 1I70 H6 2I01 G5 2I02 C4 2I03 C4 2I04 D4 2I05 D4 2I06 E4...
Page 94
Circuit Diagrams and PWB Layouts FTL13U AA & AB Small Signal Board (AB): I/O Eur V00 L18 1I10 D19 1I26 B3 1I44 E14 1I55 K4 2I10 B4 2I26 F3 2I35 K3 2I46 K21 2IC9 C15 3I49 C4 3I78 C15 3I91 G3...
Page 95
Circuit Diagrams and PWB Layouts FTL13U AA & AB Small Signal Board (AB): 2FH I/O 1I07 F11 FIB2 F10 1I15 G4 FIB3 H4 2 FH I/O B14C B14C 1I65 F11 FIB5 F13 1I66 F13 FIB6 F11 1I67 F12 FIB7 F11...
Page 96
Circuit Diagrams and PWB Layouts FTL13U AA & AB Small Signal Board (AB): Audio I/O 2I71 B2 AUDIO I/O 2I72 B2 B14D B14D 2I73 B2 2I74 B2 B1 --> B20 2I75 B2 2I76 B3 2I77 C1 2I78 C1 3IH9 2I79 C1...
Page 97
Circuit Diagrams and PWB Layouts FTL13U AA & AB Small Signal Board (AB): DVI RGB 0004 I3 FD63 H12 1D07 H2 FD64 H5 DVI RGB B19A B19A 2D51 B3 FD65 H5 REF2 2D52 C3 FD66 H7 2D53 C9 FD67 H7...
Page 98
Circuit Diagrams and PWB Layouts FTL13U AA & AB Small Signal Board (AB): DVI Receiver 1V21 F1 1V27 H3 1V48 F8 2V26 D18 2V33 D22 2V41 G18 2V50 H23 2V57 K22 2V63 N23 2V71 H15 2V79 N26 3V25 N24 3V33 K15...
Page 99
Circuit Diagrams and PWB Layouts FTL13U AA & AB Small Signal Board (AB): HDI A/D Convertor 2L01 A1 5L10 E3 2L02 A2 5L11 F3 HDI A/D CONVERTOR B19C B19C 2L03 A2 5L12 F3 2L04 A2 5L13 A1 2L05 A2 5L14 B1...
Page 100
Circuit Diagrams and PWB Layouts FTL13U AA & AB Small Signal Board (AB): EPLD Control 1E02 A8 1E04 G8 2D02 G11 2D03 E11 EPLD CONTROL B19D B19D 2D04 F2 2D08 G5 2D15 I7 2D21 I3 2D22 I3 3E77 2E50 E3...
Page 101
Circuit Diagrams and PWB Layouts FTL13U AA & AB Small Signal Board (AB): EPLD OSD 2E02 B3 3E48 E1 2E04 A4 3E49 C1 EPLD OSD B19E B19E 2E05 E3 3E90 B1 +5VA-OSD 2E09 G3 3E91 D1 2E10 A4 3E92 G1...
Page 102
Circuit Diagrams and PWB Layouts FTL13U AA & AB Small Signal Board (AB): EPLD I/O 2V05 C1 EPLD I/O 2V06 B13 B19F B19F 2V07 A11 2V08 A12 2V09 A12 2V10 A11 +3V3-EPLD +3V3-EPLD +3V3-EPLD 2V11 C4 2V12 D4 B19d,f 2V13 D5...
Page 103
Circuit Diagrams and PWB Layouts FTL13U AA & AB Layout Small Signal Board (AB) (Top Side Overview) Part 2 E_13450_023b.eps Part 1 E_13450_023a.eps Part 3 E_13450_023c.eps Part 4 E_13450_023d.eps 3104 313 6038.5 E_13450_023.eps 291204...
Page 104
Circuit Diagrams and PWB Layouts FTL13U AA & AB Layout Small Signal Board (AB) Mapping (Top Side) 1001 C7 2339 B5 2790 D7 2A47 E5 2B32 E2 2IC5 A5 2PE3 D3 3076 C6 3720 E6 3A20 D4 3E38 E9 3P20 C2...
Page 105
Circuit Diagrams and PWB Layouts FTL13U AA & AB Layout Small Signal Board (AB) (Top Side Part 1) Part 1 E_13450_023a.eps 291204...
Page 106
Circuit Diagrams and PWB Layouts FTL13U AA & AB Layout Small Signal Board (AB) (Top Side Part 2) Part 2 E_13450_023b.eps 291204...
Page 107
Circuit Diagrams and PWB Layouts FTL13U AA & AB Layout Small Signal Board (AB) (Top Side Part 3) Part 3 E_13450_023c.eps 291204...
Page 108
Circuit Diagrams and PWB Layouts FTL13U AA & AB Layout Small Signal Board (AB) (Top Side Part 4) Part 4 E_13450_023d.eps 291204...
Page 109
Circuit Diagrams and PWB Layouts FTL13U AA & AB Layout Small Signal Board (AB) (Bottom Side Overview) Part 1 E_13450_024a.eps Part 2 E_13450_024b.eps Part 3 E_13450_024c.eps Part 4 E_13450_024d.eps 3104 313 6038.5 E_13450_024.eps 291204...
Page 110
Circuit Diagrams and PWB Layouts FTL13U AA & AB Layout Small Signal Board (AB) Mapping (Bottom Side) 1301 C5 2713 E4 2A85 E5 2E57 D1 2L32 C1 2S21 C6 3005 C4 3384 C5 3B02 E9 3I78 A5 3L08 C1 3U36 F4...
Page 111
Circuit Diagrams and PWB Layouts FTL13U AA & AB Layout Small Signal Board (AB) (Bottom Side Part 1) Part 1 E_13450_024a.eps 291204...
Page 112
Circuit Diagrams and PWB Layouts FTL13U AA & AB Layout Small Signal Board (AB) (Bottom Side Part 2) Part 2 E_13450_024b.eps 291204...
Page 113
Circuit Diagrams and PWB Layouts FTL13U AA & AB Layout Small Signal Board (AB) (Bottom Side Part 3) Part 3 E_13450_024c.eps 291204...
Page 114
Circuit Diagrams and PWB Layouts FTL13U AA & AB Layout Small Signal Board (AB) (Bottom Side Part 4) Part 4 E_13450_024d.eps 291204...
Alignments FTL13U AA & AB EN 133 8. Alignments Index of this chapter: 4. The second item (HIGH/LOW) informs you whether the 8.1 General Alignment Conditions AFC-frequency is too high or too low. 8.2 Hardware Alignments 8.3 Software Alignments Table 8-1 OSD feedback of AFC alignment 8.4 Option Settings...
Page 134
EN 134 FTL13U AA & AB Alignments 8.3.3 OSD CLAMPING Table 8-4 Option overview Not necessary to align, set all values to "0". Menu-item Subjects Options Description Diplay Fixed. Technology 8.3.4 LUM. DEL. 30" Panel size (in inches). Size Display 42"...
Page 135
Alignments FTL13U AA & AB EN 135 14), and "Integrated RC" (Bit 15) are set for this particular model. Table 8-5 Option bytes Group 1 Byte nr. Bit nr. Decimal value Option name Settings (in decimal values) Option Byte value Featurebox 0= None (n.a.)
Page 136
EN 136 FTL13U AA & AB Alignments Table 8-6 Option bytes Group 2 Byte nr. Bit nr. Decimal values Option name Settings (in decimal values) Option Byte value n.a. Auto Store Mode 0= None (US/LA/AP-N) 2= PDC/VPS (EU) 4= TXT Page (EU) 6= PDC/VPS/TXTpage (EU) n.a.
Circuit Descriptions, Abbreviation List, and IC Data Sheets FTL13U AA & AB EN 137 9. Circuit Descriptions, Abbreviation List, and IC Data Sheets Index of this chapter: 9.1 Introduction 9.2 Block Diagram 9.3 Power Supply 9.4 Input/Output (I/O) 9.5 Video Processing 9.6 Audio...
Page 138
EN 138 FTL13U AA & AB Circuit Descriptions, Abbreviation List, and IC Data Sheets TO LCD PANEL LVDS DC/DC CONVERTER 3D COMB AUDIO PROC. FBX (2FH) PIXEL PLUS LVDS DW/PIP EPLD HIP 2 HIP1 TUNER MAIN Audio SERVICE ANTENNA Receiver...
Page 139
To 2FH/3FH inputs CL 36532064_058.eps 171003 Figure 9-3 Block diagram FTL13U (video path) The main tuner is a PLL tuner and delivers the IF-signal, via audio and video SAW-filters, to the main HIP (High-end Input After the PICNIC, the YUV-signals are fed to the FALCONIC for Processor).
Page 140
EN 140 FTL13U AA & AB Circuit Descriptions, Abbreviation List, and IC Data Sheets For the power supply of the FBX, a separate DC/DC converter between the live AC line and the DC ground. The high current is used, generating 3.3 V.
Page 141
Circuit Descriptions, Abbreviation List, and IC Data Sheets FTL13U AA & AB EN 141 Block diagram Voltage Booster This circuit is build around capacitors 2U03, 2U04, 2U05, T 800mA 12.5V resistor 3U51, and diodes 6U03 and 6U04. It generates the boost voltage (approx. +20 V) for supplying the "high-side"...
Page 142
EN 142 FTL13U AA & AB Circuit Descriptions, Abbreviation List, and IC Data Sheets Role of Other Components On/Off • The capacitors 2U06 and 2U10 are filtering the ripple Power state switch Remarks current generated by the commutation of power MOS-FET SEMI STAND BY Standby supply is working.
Page 143
Circuit Descriptions, Abbreviation List, and IC Data Sheets FTL13U AA & AB EN 143 Input/Output (I/O) 2fH/3fH input flow Selection AV5 or AV6 Eur START AV4 or AV5 US 9.4.1 Introduction Put ADC: full power Mute sound, Blank picture •...
Page 144
The I/O peripherals are as follows: (see also figure "Block • The HIP contains a multi standard IF circuit for video diagram FTL13U" in paragraph "Block Diagram"): demodulation with AFC (Automatic Frequency Control) • Four AV inputs 1fH (AV4 can be 1fH or 2fH/3fH YPbPr), a functionality, a sound IF amplifier, and an AM demodulator.
Page 145
Circuit Descriptions, Abbreviation List, and IC Data Sheets FTL13U AA & AB EN 145 Basic functionality of the OTC The OTC combines the microprocessor and OSD functionality; it will also handle some of the status detections. 9.5.2 Video Source Selection...
Page 146
EN 146 FTL13U AA & AB Circuit Descriptions, Abbreviation List, and IC Data Sheets 9.5.3 Video Processing H-SYNC-DVI V- SYNC-DVI SILICON EPL D EU ROPE H-SYNC-VGA V- SYNC-VGA EPROM TDA8601 AD 9883A Y -2FH-0...7 Video U- 2FH-0...7 Matrix A/ D YU V V -2FH-0...7...
Page 147
Circuit Descriptions, Abbreviation List, and IC Data Sheets FTL13U AA & AB EN 147 needed. • AV3. Remark: Enabling the comb filter does not necessarily • AV4 (YPbPr 1fH or 2fH/3fH). mean that the signals will be combed. • Side I/O.
Page 148
EN 148 FTL13U AA & AB Circuit Descriptions, Abbreviation List, and IC Data Sheets Supply (Diagram A7) A Low Pass Filter at the output passes only the average of the The supply voltage is a symmetrical voltage of +/- 14.5 V_dc, output wave, which is an amplified version of the input signal.
Page 149
Circuit Descriptions, Abbreviation List, and IC Data Sheets FTL13U AA & AB EN 149 Synchronization 9.7.1 Introduction There is a different sync flow for 1fH, 2fH, or 3fH inputs. Sync and Clock Flow EPLD EBIL D H-SYNC-VGA (DVI) AD9883A H-2FH-AD-OUT...
Page 150
EN 150 FTL13U AA & AB Circuit Descriptions, Abbreviation List, and IC Data Sheets 9.7.4 Sync Flow 3fH input sync signals 9.8.4 LED Control 3fH Sync Signals In USA the same LED configuration is used as in Europe, the •...
Page 151
Because of the dip in the OTC supply voltage, the OTC will get a reset and The LC300W01 from LPL (LG.Philips LCD) is a color Active restarts the set. If the fault cause is still present at that start-...
Page 152
EN 152 FTL13U AA & AB Circuit Descriptions, Abbreviation List, and IC Data Sheets • Standard single ended signal (TTL). – This requires 28 signal lines and more than 14 Constraints: grounds. • Needs the EPG flash memory, so this device must be –...
Page 153
Circuit Descriptions, Abbreviation List, and IC Data Sheets FTL13U AA & AB EN 153 Data Memory Space Code Memory Space START XRAM (2MB) Clear EPG flash 0x800000 Load bootstrap into EPG flash XROM-FLASH (4MB) Is bootstrap loaded Exchange 0x400000 Switch of the set,...
EN 154 FTL13U AA & AB Circuit Descriptions, Abbreviation List, and IC Data Sheets 9.12 Abbreviation list EBILD Eagle Based Intelligent LCD Driver (Programmed EPLD) E-DDC Enhanced Display Data Channel 2DNR Spatial (2D) Noise Reduction (VESA standard for communication 3DNR Temporal (3D) Noise Reduction channel and display).
Page 155
Circuit Descriptions, Abbreviation List, and IC Data Sheets FTL13U AA & AB EN 155 Mbps Mega bits per second SCART Syndicat des Constructeurs Monochrome TV system. Sound d'Appareils Radiorecepteurs et carrier distance is 4.5 MHz Televisieurs MOSFET Metal Oxide Silicon Field Effect...
EN 156 FTL13U AA & AB Circuit Descriptions, Abbreviation List, and IC Data Sheets 9.13 IC Data Sheets This section shows the internal block diagrams and pin layouts of ICs that are drawn as "black boxes" in the electrical diagrams (with the exception of "memory"...
Page 157
Circuit Descriptions, Abbreviation List, and IC Data Sheets FTL13U AA & AB EN 157 9.13.2 Diagram B11, uPD64083 (IC7B00) Block Diagram E XTD Y C O 9-0 D Y C O Error S elect VC LY D YC O 9-0...
Page 158
EN 158 FTL13U AA & AB Circuit Descriptions, Abbreviation List, and IC Data Sheets 9.13.3 Diagram B14A, TEA6415 (IC7I24) DIAGR AM P ERI P ER I LUMA CHROM A DE C. POWE R CVBS (MAC/DEC ) CV BS (PER I PLUG1 )
Page 159
Circuit Descriptions, Abbreviation List, and IC Data Sheets FTL13U AA & AB EN 159 9.13.4 Diagram B19E, AD9066JR (IC7E09, 7E16) FUNCTIONAL BLOCK DIAGRAM AD9066 6-BIT D0A-D5A REF A ENCODE 6-BIT D0B-D5B REF B PIN CONFIGURATIONS ENCODE D5A (MSB) REF A...
Page 160
EN 160 FTL13U AA & AB Circuit Descriptions, Abbreviation List, and IC Data Sheets 9.13.5 Diagram SP1, TNY266 (IC7500) BYPASS DRAIN (BP) REGULATOR 5.8 V LINE UNDER-VOLTAGE 240 µA 50 µA FAULT BYPASS PIN UNDER-VOLTAGE PRESENT AUTO- RESTART COUNTER 5.8 V CURRENT 4.8 V...
Page 161
Circuit Descriptions, Abbreviation List, and IC Data Sheets FTL13U AA & AB EN 161 9.13.6 Diagram SP2, STR83145 (IC7805) Overvoltage protection circuit RBV series IN(AC) RM11C µ µ µ : 4.7 /400V, C : 1 F/50V, C : 0.047 F/50V (Observe strictly) µ...
Chapter 7: Schematics and PWB layout of updated SSB are added. – Only changed schematics are added.. • Chapter 10: Spare Part List of FTL13U AB SSB is added • Some small layout and text changes are made in the text chapters.