Page 1
Built-in Dishwasher SERVICE MANUAL Models ESD400/ESD401/ESD402 Features Energy Star for energy consumption of USA rules Stainless steel Interior tub Electronic control Triple level filter system Three-spraying, higher cleaning ratio The capacity for 12 place settings Soil sensor Part # DW-8888-26...
Serial Number: Version:00.00 Edition: Nov.-23-2005 Built-In Dishwasher Model: ESD400/ESD401/ESD402 1.Product Code Illumination and Series Introduction Model Identification ESD □□ □ A: Energy Star Dishwasher B: Series of factory design C: Code of Color 0:White 1:Black 2:Stainless steel Examples: ESD400 It represents energy star dishwasher of 400 series, the color of appearance is white. ESD401 It represents energy star dishwasher of 400 series, the color of appearance is black.
Serial Number: Version:00.00 Edition: Nov.-23-2005 Built-In Dishwasher Model: ESD400/ESD401/ESD402 3/4”(1.9 cm) insulation-may be compressed 33-7/8”(86cm) min.with wheels removed 5.Installation 5.1 Tools and materials needed A. pliers B. Phillips screwdriver C. 5/8”open end wrench D. measuring tape or ruler E. 10” adjustable wrench that opens to 1-1/8”(2.9cm) F.
Serial Number: Version:00.00 Edition: Nov.-23-2005 Built-In Dishwasher Model: ESD400/ESD401/ESD402 5.2 Parts supplied 2 drain hose clamps 1-large 1-small Make sure all these parts are included. See parts list for accessories available for your dishwasher. B. 2 No.ST4.2 X 18 Philips-head screws C.
Page 9
Serial Number: Version:00.00 Edition: Nov.-23-2005 Built-In Dishwasher Model: ESD400/ESD401/ESD402 Electrical It is the customer’s responsibility: To contact a qualified electrician. To assure that the electrical installation is adequate and in conformance will all national and local codes and ordinances. You must have: - 120-volt, 60Hz, AC-only, 15- or 20-amp.,fused electrical supply.
Page 10
Serial Number: Version:00.00 Edition: Nov.-23-2005 Built-In Dishwasher Model: ESD400/ESD401/ESD402 Drain You must : - Use the new drain hose supplied with your dishwasher. If this is not suitable, use a new drain hose with a maximum length of 12 feet(3.7 m) that meets all current AHAM/IAPMO test standards, is resistant to heat and detergent, and fits the drain connector on your dishwasher.
Serial Number: Version:00.00 Edition: Nov.-23-2005 Built-In Dishwasher Model: ESD400/ESD401/ESD402 6. PARTS AND FEATURES 7. Control Panel Page 26 / 48...
Serial Number: Version:00.00 Edition: Nov.-23-2005 Built-In Dishwasher Model: ESD400/ESD401/ESD402 8.START-UPGUIDE Before using your dishwasher, remove all packaging materials. Using New Dishwasher 1. Rinse aid is essential for good drying. Be sure to fill the dispenser before you use your new dishwasher.
Serial Number: Version:00.00 Edition: Nov.-23-2005 Built-In Dishwasher Model: ESD400/ESD401/ESD402 or bumped. -Make sure pot lids and handles, pizza pans, cookie sheets, etc., do not interfere with the spray arm rotation. -Conserve water, energy and save time over hand rinsing by running a rinse cycle to keep dishes moist if you do not plan to wash them soon.
Serial Number: Version:00.00 Edition: Nov.-23-2005 Built-In Dishwasher Model: ESD400/ESD401/ESD402 2. To release, press the button of the track stop and pull track stop out of the track. 3. After removing both track stops, pull rack out. To replace the top rack 1.
Use only detergent specifically made for use in dishwashers. Cascade, Cascade Complete and Electrasol Automatic Dishwashing Detergents have been approved for use in all Haier dishwashers. Keep your detergent fresh and dry. Don't put powder detergent into the dispenser until you're ready to wash dishes.
Serial Number: Version:00.00 Edition: Nov.-23-2005 Built-In Dishwasher Model: ESD400/ESD401/ESD402 detergent. NOTE: Use both sections for cycles with 2 washes. Use only the main wash section for cycles with 1 wash, See the "Cycle Selection Charts "for more details. How much detergent to use -Different brands of dishwasher detergent have different amounts of phosphorous for softening water .If you have hard water and use a detergent with a phosphorous content of less than 8.7%, you might need to use more detergent , or use a...
Serial Number: Version:00.00 Edition: Nov.-23-2005 Built-In Dishwasher Model: ESD400/ESD401/ESD402 You can add an item anytime before the main wash starts. Open the door and check the detergent dispenser If the cover is still closed, you can add items. TO add items 1.
Serial Number: Version:00.00 Edition: Nov.-23-2005 Built-In Dishwasher Model: ESD400/ESD401/ESD402 After the first time that you use delay, the control will start by calling up the last delay that you can. You can adjust from there if you want to change it. To delay the start 1.Close the door.
Serial Number: Version:00.00 Edition: Nov.-23-2005 Built-In Dishwasher Model: ESD400/ESD401/ESD402 particles from redepositing on the clean dishes. The wash water continuously flows through the filter, trapping food particles. -Two water jets, located under the spray arm, remove the food particles from the filter. -A coarse strainer prevents bones, pits, and other large objects from entering the pump system.
Serial Number: Version:00.00 Edition: Nov.-23-2005 Built-In Dishwasher Model: ESD400/ESD401/ESD402 14.Washing special items and dishwasher care To clean interior Page 38 / 48...
Serial Number: Version:00.00 Edition: Nov.-23-2005 Built-In Dishwasher Model: ESD400/ESD401/ESD402 Make a paste with powdered dishwasher detergent on a damp sponge and clean. Use liquid automatic dishwasher detergent and clean with a damp sponge. See the vinegar rinse procedure in "spotting and filming on dishes" in "Troubleshooting." NOTE: Run a Normal cycle with detergent after cleaning the interior 15.Drain Air Gap Check the drain air gap anytime your dishwasher isn't draining well.
Serial Number: Version:00.00 Edition: Nov.-23-2005 Built-In Dishwasher Model: ESD400/ESD401/ESD402 17.Function Schedule 1、Anti-Bacterial wash(Heavy soil) Second rinse 130F Pre-wash First Rinse 150F Main wash Third rinse 161F Sanitize Rinse Drying(If heated dry is selected) Notice: If user selected the soak option, the dishwasher would add a 4h scour & soak rinse before the cycle start.
Page 42
Serial Number: Version:00.00 Edition: Nov.-23-2005 Built-In Dishwasher Model: ESD400/ESD401/ESD402 5.Normal Wash( Middle soil level) Rinse Pre-wash warmly *130F Main wash **Final Rinse Drying(If heated dry is selected) Notice: *:The temp. should 140 F when selecting Hi-Temp Wash. **:If user select Sanitize Rinse option, the dishwasher would heat water to 161F in this step. 6.Normal Wash(Light soil level) Pre-wash warmly *130F Main wash...
Serial Number: Version:00.00 Edition: Nov.-23-2005 Built-In Dishwasher Model: ESD400/ESD401/ESD402 18.Maintenances Services and Trouble Shooting If the 2-digit 7-segment displayer display “Er”, it shown that the temperature sensor is fault. Page 42 / 48...
Page 44
Serial Number: Version:00.00 Edition: Nov.-23-2005 Built-In Dishwasher Model: ESD400/ESD401/ESD402 Analysis of the common breakdowns. Phenomenon: the cycle and option can not been selected Is the door closed? Close the door Do you put the plug(if Put the plug into the outlet. installed) into the outlet? Is the power switch (if installed)turned on?
Page 45
Serial Number: Version:00.00 Edition: Nov.-23-2005 Built-In Dishwasher Model: ESD400/ESD401/ESD402 Phenomenon: the dishwasher is running properly without water in tub Is the water shut-up valve turned on? Turn on the valve The overfill floater is Press the floater The water pressure is too The water pressure is slow,a A booster pump before...
Page 46
Serial Number: Version:00.00 Edition: Nov.-23-2005 Built-In Dishwasher Model: ESD400/ESD401/ESD402 Heating trouble Phenomenon: program controller stop turning Whether socket connector is connected well Connect it well Whether thermo limiter is change thermo limiter Whether heater is OK change heater PCB or circuit is broken Page 45 / 48...
Page 47
Serial Number: Version:00.00 Edition: Nov.-23-2005 Built-In Dishwasher Model: ESD400/ESD401/ESD402 Power supply trouble Phenomenon: dishwasher cannot work check whether the power connector Connect it properly check whether the power connector is in position is in position check whether the circuit the cable or the controller board between the two terminals should be suspected is open...
Serial Number: Version:00.00 Edition: Nov.-23-2005 Built-In Dishwasher Model: ESD400/ESD401/ESD402 19.Circuit Diagram 1 2 0 V ~ 6 0 H Z D o o r s w it c h G r o u n d D o o r s w it c h W - W P 2 - 6 C o n t o r l b o a r d...