Hitachi I-28 Service Manual page 2

SAFETY PRECAUTIONS
WARNING: Since the chassis of this receiver is connected
to one side of the Mains Supply during operation, service
should not be attempted by anyone unfamiliar with the
precautions necessary when working on this type of
equipment.
The following precautions should be observed:
1. Do not install, remove, or handle the picture tube in
any manner unless shatter-proof goggles are worn.
People not so equipped should be kept away while
picture tubes are handled. Keep picture tube away
from the body while handling.
When service is required, an isolation transformer
should be inserted between power line and the receiver
before any service is performed on a "HOT" chassis
receiver.
When replacing a chassis in the cabinet, always replace
all the protective devices are put back in place, such as;
barriers, non-metallic knobs, adjustment and compart-
ment cover or shields, isolation resistor-capacitor, etc.
When service is required, observe the original lead
dress. Extra precaution should be taken to assure
correct lead dress in the high voltage circuitry area.
Always use the manufacturer's replacement com-
ponent. Especially critical components as indicated on
the circuit diagram should not be replaced by other
makes.
Furthermore where a short circuit has occurred,
replace those components that indicate evidence of
overheating.
Before returning a serviced receiver to the customer,
the service technician must thoroughly test the unit to
be certain that it is completely safe to operate without
danger of electrical shock, and be sure that no
protective device built into the instrument by the
manufacturer has become defective, or inadvertenly
defeated during servicing.
Therefore, the following checks are recommended for
the continued protection of the customer and service
technician.
BLOCK DIAGRAM
UNE IAT UHE_TUNER(7O-POSITION DETENT TYPE) Paya SPEAKER
. UHF MIX 1 SOUND OUT PUT
| | KC583C
| VIDEO IF AMP
VHF ANT
|
DETECTOR AGC
o
We ee thee oe
J
NOISE ELIMNATOR
VHF TUNER SYNC. SIGNAL
NiGe WGUCEREOUENCY VHE MIX VHF HIGH-FREQUENCY VHF MIX VIDEO IF AMP SEPARATOR
UHF IF AMP UHF IF AMP | RF AGC DELAY AMP VIDEO AMP VIDEO OUT PUT CRT
tc) Ic2 TR251
eScese eset | Hal 144 HALIG7 280856
ee
!
| VHF OSC |
| i VERTICAL MIDDLE
I I BLANKING VOLTAGE RECTIFIER
!
aes
oe)
Le we ee
2 VERTICAL OSC
Naan
hve
DRIVE OUT PUT
POWER RECTIFIER
ERROR DETECTOR
AMP
1c4
KC58IC
VERTICAL &
DAMPER = HORIZONTAL ae
CREOI
BOOSTER
&
> HIGH VOLTAGE
ee +8 SiBQI-02/) RECTIFIER
cR702
HORIZONTAL vooc
PHASE DETECTOR SS
1C5 TR7OI
00000000
HORIZONTAL
OUT PUT CR70} F
voO6c
HORIZONTAL
DAMPER