Maintenance; Service; Replacement Parts Ordering; Addresses - Motorola R-20018 Manual

--
5-14.
MAJOR ASSEMBLIES
5-15. The Communication System Analyzer is designed for ease of maintenance. Most of the circuitry is on
seven plug-in circuit boards. A list of all subassemblies is given in table 5-1. The assembly locations are shown
in figures 5-1 and 5-2.
Table 5-1. List of Subassemblies
Ref. Part Number
Replacement
Des.
Item
As Labeled
Order Part No.
A1 Low Voltage Power Supply Module 01-P07897V001 RTP-1005A
A1A1
Low Voltage Power Supply Switcher 01-P07891 V001 RTP-4016A
Module
A1A2
Low Voltage Power Supply Output 01-P07856V001
RTP-4013A
Module
A1A3 Low Voltage Power Supply Control 01-P07853V001
RTP-4012A
Module
A1A4 Lower Voltage Power Supply Relay
01-P07892V001 01-80305A68
Module
A2 Scope Amplifier Module
01-P00413N002 RTC-40078
A3
Scope/DVM Control Module
01-P00409N002 RTC-40088
A4 Receiver Module 01-P00389N002
RTL-10028
AS Synthesizer Module 01-P00385N002 RTC-10018
A5A'
Digital Synthesizer Card 01-P00358N002
RTC-40098
A58' RF Synthesizer Card 01-P00386N002
RTC-40108
A6 Audio Synthesizer Module
01-P00426N002 RTC-40118
A7 Processor Input/Output Module
01-P00405N002 RTC-40128
AS IEEE Bus Module (Optional)
01-P00203N002
RTC-40138
A9 Microprocessor/Character 01-P07894V001
RTC-40198
Generator Module
5-4
I
I
I
5-1. SERVICE
SECTION V
MAINTENANCE
5-2. The Motorola Test Equipment Repair Center is charged with the service responsibility for all test
equipment supplied by the Motorola Communications Group. The center maintains a stock of original
equipment replacement parts and a complete library of service information for all Motorola test equipment.
5-3. Most in-warranty repair are performed at the center. Exceptions include repairs on some equipment not
manufactured by Motorola which are performed by the original supplier under the direction of the Test
Equipment Repair Center. Out-of-warranty service is performed on a time and materials basis at competitive
rates and the maximum turn-around goal is less than ten working days. Customer satisfaction is continually
surveyed by reply cards returned with repaired instruments.
5-4. The Test Equipment Repair Center also provides a convenient telephone troubleshooting service.
Frequently, a user technician can troubleshoot a piece of equipment and isolate defective components under
the direction of the Test Equipment Repair Center via telephone. Required replacement parts are then
immediately shipped to the user thereby reducing shipping time and servicing costs. For telephone
troubleshooting contact the Test Equipment Repair Center toll free at (BOO) 323-6967.
5-5. All other inquiries and requests for test equipment calibration and repairs should be directed to the Area
Parts Office. They will contact the Test Equipment Repair Center, process the necessary paperwork and. if
necessary. have the Center contact you to expedite the repair.
5-6. REPLACEMENT PARTS ORDERING
5-7. Motorola maintains a number of parts offices strategically located throughout the United States. These
facilities are staffed to process parts orders. identify part numbers, and otherwise assist in the maintenance
and repair of Motorola Communications products.
5-8. Orders for all replacement parts should be sent to the nearest area parts and service center listed below.
When ordering replacement parts the complete identification number located on the equipment should be
included.
5-9.
ADDRESSES
5-10. General Offices
MOTOROLA INC.
Communications Division Parts Dept.
1313 E. Algonquin Rd.,
Schaumburg, Illinois 60196
Phone: 312-397-1000
Executive Offices: 1301 E. Algonquin Rd.,
Schaumburg, Illinois 60196
5-1