Figure 27
1. Center-to-center distance (rear of tires)
2. Forward
3. Center-to-center distance (front of tires)
3. If the measurement is greater than
loosen the jam nuts at both ends of the tie rods
(Fig. 28).
4. Rotate both tie rods to move the front of the tire
inward or outward.
Figure 28
1. Jam nut
2. Tie rod8
5. Tighten tie rod jam nuts when the adjustment is
correct.
6. Ensure that there is full travel of the steering
wheel in both directions.
Servicing the Fuel System
Fuel Lines and Connections
Check lines and connections every 400 hours or
1
2
3
1
⁄
in. (6.4 mm),
4
yearly, whichever occurs first. Inspect for
deterioration, damage, or loose connections.
Replacing the Fuel Filter
Replace the fuel filter after every 800 operating hours
or yearly, whichever occurs first.
1. Raise the bed and support it with the prop rod.
2. Place a clean container under the fuel filter.
3. Remove the clamps securing the fuel filter to the
fuel lines.
1. Fuel filter
4. Install the new fuel filter to the fuel lines with the
clamps previously removed. The filter to be
mounted so arrow points toward the carburetor.
Spark Plugs
Service Interval/Specification
Replace spark plugs after every 800 operating hours
or yearly, whichever occurs first, to assure proper
engine performance and reduce exhaust emission
level.
Type: Champion RC 12YC (or equivalent)
Air Gap: 0.76 mm (0.03")
Note: The spark plug usually lasts a long time;
however, the plug should be removed and checked
whenever the engine malfunctions.
29
1
Figure 29