Motorola MOTORIZR Z6tv Service Manual page 69

Level 1 and 2 Service Manual
6809513A80-B
Short Travel Test (Slider Open)
1. Hold the phone at a 45 degree angle with one hand as shown.
Figure 80. Slider Stop Test
1. Fully close the slider.
2. Place thumb over top edge of push bar as shown. Slightly open the slider so
that the bottom tip of the slider is 0.0 – 1.0mm above the recessed arc on the
front housing.
3. Release the slider by quickly lifting thumb and letting push bar slide beneath
it. To guarantee a clean release, lift thumb directly upward or in opposite
direction of slider motion. Never allow thumb to move in the same direction as
slider motion.
4. If the slider fails to reach its fully closed position within 2 seconds after release,
the phone fails this test. The speed of the motion is irrelevant.
5. All failed phones must be quarantined and reworked.
February 19, 2008
Thumb over push bar
Below "2
key
Disassembly
V483981
69