Visual Inspection; Engine Basic Inspection - Suzuki GRAND VITARA 2005 Service Manual

Visual Inspection

Visually check the following parts and systems.
Inspection item
• Engine oil-level, leakage
• Engine coolant-level, leakage
• Fuel-level, leakage
• Air cleaner element-dirt, clogging
• Battery-fluid level, corrosion of terminal
• Water pump belt-tension damage
• Vacuum hoses of air intake system-disconnection,
looseness, deterioration, bend
• Connectors of electric wire harness-disconnection, friction
• Fuses-burning
• Parts-installation, bolt-looseness
• Parts-deformation
• Other parts that can be checked visually
Also check the following items at engine start, if possible
• Malfunction indicator lamp-Operation
• Charge warning lamp-Operation
• Engine oil pressure warning lamp-Operation
• Engine coolant temp. meter-Operation
• Fuel level meter-Operation
• Tachometer-Operation
• Abnormal air being inhaled from air intake system
• Exhaust system-leakage of exhaust gas, noise
• Other parts that can be checked visually

Engine Basic Inspection

This check is very important for troubleshooting when ECM has detected no DTC and no abnormality has been found
in "Visual Inspection: ".
Follow the flow carefully.
Step
1 Check battery voltage
Is it 11 V or more?
2 Is engine cranked?
3 Does engine start?
4 Was the trouble symptom able to be confirmed?
5 Check immobilizer system
Refer to "Immobilizer Control System Check: in Section
10C".
Is it in good condition?
Action
Engine General Information and Diagnosis:
Referring section
"Engine Oil and Filter Change: in Section 0B"
"Coolant Level Check: in Section 1F"
"Fuel Lines and Connections Inspection: in Section
0B"
"Air Cleaner Filter Inspection: in Section 0B"
"Battery Description: in Section 1J"
"Accessory Drive Belt Inspection: in Section 1J"
"Air intake Pipe Removal and Installation: in Section
1D" and "Vacuum Pump Removal and Installation: in
Section 1D"
"Malfunction Indicator Lamp (MIL) Check: "
"Generator Symptom Diagnosis: in Section 1J"
"Oil Pressure Switch Inspection: in Section 9C"
"Fuel Level Sensor Inspection: in Section 9C"
Yes
Go to Step 2.
Go to Step 3
Go to Step 4.
Go to "Fault Finding-
Customer Complaints: ".
Go to "Fault Finding-
Customer Complaints: ".
1A-25
S5JB0B1104009
S5JB0B1104010
No
Charge or replace
battery.
Go to "Cranking System
Symptom Diagnosis: in
Section 1I".
Go to Step 5.
Go to Step 7 of "Engine
and Emission Control
System Check: ".
Repair malfunction part.