Service And Repairs; Service And Repairs; Servicing Air Cleaner - Toro Greensmaster 3200 Service Manual

Service and Repairs

Servicing Air Cleaner

Service air cleaner filter every 200 hours (more fre-
quently in extreme dusty or dirty conditions).
1. Check air cleaner body and hoses for damage
which could possibly cause an air leak. Replace air
cleaner body if damaged.
2. Release latches securing the air cleaner cover to
the air cleaner body. Separate cover from the body.
Clean inside of air cleaner cover.
3. Gently slide filter out of the air cleaner body to re-
duce the amount of dust dislodged. Avoid knocking filter
against the air cleaner body.
4. Inspect filter. Discard filter if damaged. Do not wash
or reuse a damaged filter.
Washing Method
A. Prepare a solution of filter cleaner and water.
Soak filter element for about 15 minutes. Refer to
directions on the filter cleaner carton for complete
information.
B. After soaking the filter for 15 minutes, rinse it with
clear water. Maximum water pressure must not ex-
ceed 40 psi to prevent damage to the filter element.
Rinse filter from the clean side to dirty to side.
C. Dry filter element using warm, flowing air that
dose not to exceed 160 F (71 C), or allow element
to air–dry. Do not use a light bulb to dry the filter ele-
ment because damage could result.
Compressed Air Method
Use eye protection such as goggles when
using compressed air
A. Blow compressed air from the inside to the out-
side of the dry filter element. Do not exceed 100 psi
to prevent damage to the element.
B. Keep air hose nozzle at least 2 inches (5 cm)
from the filter. Move nozzle up and down while rotat-
ing the filter element. Inspect for holes and tears by
looking through the filter toward a bright light.
Vanguard 3/LC Gasoline Engine
CAUTION
5. Inspect new filter for shipping damage. Check seal-
ing end of the filter. Do not install a damaged filter.
6. Insert new filter properly into the air cleaner body.
Make sure filter is sealed properly by applying pressure
to the outer rim of the filter when installing. Do not press
on the flexible center of the filter.
7. Reinstall cover and secure latches.
3
2
1. Air cleaner latches
2. Dust cup
Page 3 – 8
1
Figure 8
3. Filter
Greensmaster 3200