Table Of Contents - Kenwood TK-5810 Service Manual

TK-5810 BG
(
GENERAL ................................................................... 2
SYSTEM SET-UP ....................................................... 4
REALIGNMENT ......................................................... 5
INSTALLATION ........................................................ 12
DISASSEMBLY FOR REPAIR .................................. 20
CIRCUIT DESCRIPTION .......................................... 24
COMPONENTS DESCRIPTION ............................... 32
PARTS LIST ............................................................. 35
EXPLODED VIEW .................................................... 50
PACKING .................................................................. 52
TROUBLE SHOOTING ............................................ 54
ADJUSTMENT ........................................................ 56
Document Copyrights
Copyright 2010 by Kenwood Corporation. All rights re-
served.
No part of this manual may be reproduced, translated,
distributed, or transmitted in any form or by any means,
electronic, mechanical, photocopying, recording, or other-
wise, for any purpose without the prior written permission
of Kenwood.
Disclaimer
While every precaution has been taken in the preparation
of this manual, Kenwood assumes no responsibility for er-
rors or omissions. Neither is any liability assumed for dam-
ages resulting from the use of the information contained
herein. Kenwood reserves the right to make changes to any
products herein at any time for improvement purposes.
INTRODUCTION
SCOPE OF THIS MANUAL
This manual is intended for use by experienced techni-
cians familiar with similar types of commercial grade com-
munications equipment. It contains all required service
information for the equipment and is current as of the pub-
lication date. Changes which may occur after publication
are covered by either Service Bulletins or Manual Revisions.
These are issued as required.
2
/5810H BG
) ( )
CONTENTS
TERMINAL FUNCTION ........................................... 75
PC BOARD
FINAL UNIT (X45-3790-XX): TK-5810(BG) ......... 80
FINAL UNIT (X45-3800-XX): TK-5810H(BG) ...... 82
CONTROL UNIT (X53-4400-10) .......................... 86
TX-RX UNIT (X57-7270-XX) ................................ 90
INTERCONNECTION DIAGRAM ............................ 94
SCHEMATIC DIAGRAM .......................................... 96
BLOCK DIAGRAM ................................................. 114
LEVEL DIAGRAM .................................................. 120
SPECIFICATIONS .................................................. 121
Firmware Copyrights
The title to and ownership of copyrights for firmware
embedded in Kenwood product memories are reserved for
Kenwood Corporation. Any modifying, reverse engineer-
ing, copy, reproducing or disclosing on an Internet website
of the firmware is strictly prohibited without prior written
consent of Kenwood Corporation. Furthermore, any resell-
ing, assigning or transferring of the fi rmware is also strictly
prohibited without embedding the firmware in Kenwood
product memories.
Transceivers containing AMBE+2™ Vocoder:
The AMBE+2™ voice coding technology is embedded in
the fi rmware under the license of Digital Voice Systems, Inc.
GENERAL
ORDERING REPLACEMENT PARTS
When ordering replacement parts or equipment informa-
tion, the full part identifi cation number should be included.
This applies to all parts: components, kits, or chassis. If the
part number is not known, include the chassis or kit number
of which it is a part, and a suffi cient description of the re-
quired component for proper identifi cation.