Failure Code [B@Bczk] Eng Water Level Low - Komatsu PC130-8 Shop Manual

SEN04119-01

Failure code [B@BCZK] Eng water level low

User code Failure code
— B@BCZK
Contents of • While engine was running, signal circuit of radiator coolant level sensor was opened (disconnected
trouble with GND).
Action of • Displays radiator coolant level monitor on machine monitor.
machine monitor • Even if cause of failure disappears, system does not reset itself until starting switch is turned OFF.
Problem that
appears on • If machine is operated as it is, engine may overheat.
machine
• Input from the radiator coolant level sensor can be checked with monitoring function.
Related
(Code: 04500 Monitor Input 1)
information
• Method of reproducing failure code: Turn starting switch ON.
Lowering of radiator coolant
1 level
(when system is normal)
Defective radiator coolant
2 level switch (internal discon-
nection)
Possible causes
and standard
Disconnection in wiring har-
value in normal
ness
state
3 (Disconnection in wiring or
defective contact in connec-
tor)
4 Defective machine monitor
12
Engine water level low
Trouble
(Machine monitor system)
Cause Standard value in normal state/Remarks on troubleshooting
a
a
Between (1) – (2)
a
Wiring harness between CM02 (female) (3)
– P24 (female) (1)
Wiring harness between P24 (female) (2) –
chassis ground
a
Between (3) –
chassis ground
Check the coolant level and add coolant.
(If this phenomenon frequently occurs, investigate the cause.)
Prepare with starting switch OFF, then carry out troubleshoot-
ing without turning starting switch ON.
P24 (male) Radiator coolant level
Value in normal state
Value when coolant
level is low
Prepare with starting switch OFF, then carry out troubleshoot-
ing without turning starting switch ON.
Prepare with starting switch OFF, then turn starting switch ON
and carry out troubleshooting.
CM02 Radiator coolant level
Value in normal state
Value when coolant
level is low
40 Troubleshooting
1
Resistance
Max. 1 z
Min. 1Mz
Resis-
Max. 1 z
tance
Resis-
Max. 1 z
tance
Voltage
Max. 1 V
20 – 30 V
PC130-8