HP Indigo Division Series Instruction For Use & Installation Instructions page 10

Heading Step Reference
28. Installing the chiller
on page 72
Chiller and
chiller pipes
(60 mins)
29. Install the UPS on
page 75
UPS
(10 mins)
30. Install the writing
Writing head
head on page 76
(30 mins)
HVPS 31. Install the HVPS on
page 77
(40 mins)
Roof 32. Install the HVPS on
page 77
(15 mins)
Utility cabinet 33. install on page 117
top cover
(15 mins)
34. Install system
components on page
80
Various
components
(45 mins)
rd
3 Day
Lift ILP, 35. Lift and move the ILP,
unwinder, unwinder, utility
utility cabinets, and ink
cabinets, ink cabinets on page 80
cabinets
(20 mins)
36. Installing the ILP on
ILP
page 81
(120 mins)
Procedure
Install chiller pipes adapters and
connections.
Install chiller according to specifications.
Refer to the UltraFilter ultracool 0400
installation guide:
Flow rate of 56 ±5 liters/minute
Temperature (measured at the press
inlet) of 6°C
Make sure that the external filter supplied
by the supplier is installed. The filter should
be installed at the chiller return pipe.
Connect the cooling water hoses to the
press as shown in Figure 53 and Figure 54
(depending on country of installation).
Install and connect the UPS cables.
Cables to be found in cabinet M1.
Check the installation of all UPS cables
between the electrical cabinet M1, PE1,
and PE2.
Connect the cables to the internal battery.
Remove writing head from box 8.
Remove under-plate at heater window.
Install and align writing head.
Install HVPS units and covers.
Install roof covers.
Install utility cabinet top cover.
Install the following in each engine:
PTE/air knife.
Scorotron units.
Cleaning station and wiper blade.
ITM cover.
BID units.
Thoroughly clean the BID units.
Ametek filters.
Lift the ILP, unwinder, utility cabinets, and
ink cabinets to the raised platform floor.
Position ILP near PE1. Position ILP feed
and exit stepping plate assemblies near
ILP.
CA294-03070 rev 00
Installation Manual
Notes and
check
Hoses from chiller
should be prepared
page 10 of 153